2012 MINI Cooper S Technical Service Bulletins

152 technical service bulletins (TSBs) are on record for the 2012 MINI Cooper S. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10244507Oct 25, 2023Electrical system. MINI electrical systems have continued to develop over the past few years. As a result, the demand on the batteries has increased. Breakdowns due to an empty battery or problems in the vehicles electrical system can have various causes, most of which are not due to the battery itself. For this reason, a battery replacement will permanently eliminate the problem only in the rarest of cases. The energy diagnosis test…
• 10206696Dec 1, 2021Electrical system, Wheels, Equipment. New RDC wheel electronics will be introduced with future generation MINI models. The new wheel electronics are identified as Huf Generation 5. These new wheel electronics will need to be programmed using the new tool when replaced or when depressurized (0 psi) for more than 2 minutes.
• 10179827Aug 1, 2020Seats. OC3 SEAT OCCUPANCY MAT - LIMITED WARRANTY EXTENSION TO 10 YEARS/120,000 MILES: Component-Specific Limited Warranty Extension For the above-referenced vehicles, MINI USA, a division of BMW of North America, LLC (MINI USA) is extending the limited warranty for the front passenger's OC3 seat occupancy mat (shown) to: 10 years/120,000 miles as determined by the vehicle's original in-service date.
• 10171506Jan 1, 2020Electrical system, Fuel system, Engine. CLASS ACTION SETTLEMENT: N14 HIGH-PRESSURE FUEL PUMP (HDP) SERVICE BENEFIT CLASS VEHICLES: The MINI vehicle may experience a sudden engine operational failure reduced or loss of power while driving and the malfunction indicator lamp (MIL) may be illuminated along with high-pressure fuel pumprelated faults stored in the Engine Control Module (DME). PROCEDURE Perform the corresponding diagnosis/vehicle test and run…
• 10162461Jul 12, 2019Equipment. Air Conditioning System Leak Testing. The customer complains of poor or no air conditioning cooling. After further diagnosis, the system is found to be low or empty of a refrigerant charge, but when using an electronic leak detector, no leak can be found. CAUSE: In most cases, an electronic leak detector is not sufficient for identifying small leaks in the system. Electronic leak detectors can give false alarms and…
• 10162460Jul 12, 2019Body and structure, Equipment. Service Action: Checking or Replacing the Door Sill Trim Strips. The door sill trim strips are deformed and/or peeling up at the corners. CAUSE: Insufficient surface preparation of the door sill.
• 10162442Jul 12, 2019Engine cooling. "Service Action: Retrofit of the Engine Coolant Temperature Sensor. Internal corrosion could form in the engine coolant temperature sensor. This corrosion leads to internal bridging of the contacts, which can cause an inaccurate engine temperature reading. This false reading could lead to difficulty in the engine starting and/or a ""Service Engine Soon"" lamp being illuminated."
• 10153778Jan 1, 2019Equipment. Oc3 seat occupancy mat: limited warranty extension to 10 years/120.
• 10152680Nov 1, 2018Transmission and drivetrain. "MANUAL TRANSMISSION - STIFF DIAGONAL GEARSHIFT LEVER MOVEMENT. The customer may complain of a ""stiff diagonal shift"" (e.g., N-R, R-N, 2-3/3-2 or 4-5/5-4). Also, in some cases, gears cannot be selected, or the selector gear does not go into the neutral position. CAUSE 1. The deflection lever circlip of the gearshift mechanism is damaged or missing. 2. Possible corrosion at the gearshift mechanism (shift cables or…
• 10145369Jul 1, 2018Engine cooling. ENGINE CRANKS, NO START AND/OR ENGINE COOLANT TEMPERATURE FAULTS: NOTE: The engine may also exhibit the same starting behavior as in Situation1.
• 10145368Jul 1, 2018Engine cooling. ENGINE MISFIRE DUE TO FAILED IGNITION COIL: The Check Engine or Service Engine Soon (MIL) lamp is on with misfire fault(s) stored in the DME.
• 10145311Jun 1, 2018Equipment. NAVIGATION SYSTEM HAS MISSING OR INCORRECT ROAD MAP DATA: The route guidance is inaccurate and therefore irritating to the customer; or it is not possible to locate certain addresses, for instance:
• 10143579May 1, 2018Electrical system, Equipment. NAVIGATION SYSTEM HAS MISSING OR INCORRECT ROAD MAP DATA: The route guidance is inaccurate and therefore irritating to the customer; or it is not possible to locate certain addresses, for instance:
• 10135058Feb 1, 2018Equipment. N16 engine ignition coils: limited warranty extension to 10 years/120,000 miles
• 10135055Feb 1, 2018Equipment. N18 engine turbocharger: limited warranty extension to 10 years/120,000 miles
• 10134994Feb 1, 2018Transmission and drivetrain. Aisin automatic transmisison: right side output shaft seal replacement
• 10146752Aug 1, 2017Equipment. Automatic Deactivation of Recirculation Mode. The customer states the recirculation display goes out, even though the recirculation button was switched on. CAUSE The automatic recirculation air deactivation feature was introduced in July 2012. Note: If the customer dislikes this feature, it can be deactivated by using the following steps.
• 10146720Jun 1, 2017Fuel system, Engine. "N18 Engine High-Pressure Fuel Pump (HDP): Limited Warranty Extension to 10 Years/120,000 Miles This Service Information bulletin supersedes SI M01 01 16 dated March 2016..
• 10150985Jan 1, 2017Electrical system, Equipment. ?OC3 SEAT OCCUPANCY MAT: LIMITED WARRANTY EXTENSION TO 10 YEARS/120,000 MILES. This Service Information bulletin supersedes SI 01 11 16 dated December 2016.
• 10146802Dec 1, 2016Engine cooling. "Service Action: Retrofit of Engine Coolant Temperature Sensor. Internal corrosion could form in the engine coolant temperature sensor. This corrosion leads to internal bridging of the contacts, which can cause an inaccurate engine temperature reading. This false reading could lead to difficulty in the engine starting and/or a ""Service Engine Soon"" lamp being illuminated."
• 10146799Dec 1, 2016Engine cooling. "ENGINE MECHANICAL WATER (COOLANT) PUMP: LIMITED WARRANTY EXTENSION TO 7 YEARS/84,000 MILES. INFORMATION As part of a Class Action Suit Settlement for the vehicles listed above (""Class Vehicles""), MINI USA, a division of BMW of North America, LLC, is extending the limited warranty for the engine mechanical water pump to: z Item #1: This ""component-specific"" limited warranty extension applies to defects in…
• 10146796Dec 1, 2016Engine cooling. "Update MINI Water Pump Class Action Settlement: Herremans v. BMW of North America, LLC. MINI USA, a division of BMW of North America, LLC (""MINI USA"") has entered into a nationwide settlement with the plaintiffs in the above referenced class action and the Court has granted final approval of the settlement. This DCS message provides you with the latest information about this case and the settlement. Class…
• 10146981Nov 1, 2016Electrical system, Equipment. "USB DEVICE IS NOT DETECTED BY CHAMP2 HEAD UNIT. Media connected to the USB connector is not recognized by the audio system. Playback of files from the media is not possible. Message displayed on the audio system display: ""Title cannot be reproduced"" ""Is being read"" (but never plays back any audio) CAUSE Media with data files stored in more than 32 directories or 32 subdirectories within a directory. Media with…
• 10146930Oct 1, 2016Electrical system, Equipment. No sound from the radio, telephone, gong signal and or PDC. Poor radio reception and failure of the telematics systems. Possible Check Control system message: Battery discharge when engine off, Caution, no acoustic warning signals. CAUSE Non MINI approved (third-party supplier) USB cable plugged into the USB port. CORRECTION Install new MINI approved USB cable.
• 10146924Oct 1, 2016Transmission and drivetrain. "ENGINE POWER REDUCTION WITH "CLUTCH DAMAGED"" FAULTS STORED This Service Information bulletin supersedes SI M12 06 15 dated July 2015. A drivetrain malfunction check control message is displayed, prompting the customer to contact the dealer for a service visit. F54, F55, F56, F57Target Integration level: F056-16-11-501 or higherThe vehicle drives normally, but fault(s) for a damaged clutch are stored in the DME. ?…
• 10147573Aug 1, 2016Electrical system. FOOTWELL MODULE: LIMITED WARRANTY EXTENSION TO 8 YEARS/125,000 MILES. When performing ISTA/D diagnosis and/or a programming procedure (software update) on an affected vehicle, the Footwell Module could fail. There is a compatibility issue with certain combinations vehicle software (Plant Integration ILevel) and the Footwell Module hardware installed in the vehicle.
• 10146985Jul 1, 2016Fuel system, Engine. "Technical Service N18 Engine High-Pressure Fuel Pump (HDP): Limited Warranty Extension to 10 Years/120,000 Miles This Service Information bulletin supersedes SI M01 01 16 dated March 2016. INFORMATION For the above-referenced vehicles, MINI USA, a division of BMW of North America, LLC ("MINI USA") is extending the limited warranty for the engine's High-Pressure Fuel Pump (HDP) to: 10 years/120,000 miles as…
• 10151349May 1, 2016Electrical system, Equipment. Bluetooth Connection Failures This Service Information bulletin supersedes SI M84 01 14 dated February 2016.. There are various connectivity failures with the following devices: Apple iPhones Samsung S6 and the S6 Edge. Connectivity failure examples are: Call disconnection - Call is transferred back to the handset. In some instances the call is then transferred back to the vehicle.
• 10151347May 1, 2016Exterior lighting. Delay in Automatic Driving Light Switching on/off. When driving out of a tunnel or exiting underground parking, the automatic driving light remains switched on for two minutes. Shut-off period varies based on detected situation. This is normal operational behavior.
• 10151221Mar 1, 2016Fuel system. "N18 Engine High-Pressure Fuel Pump (HDP): Limited Warranty Extension to 10 Years/120,000 Miles. For the above-referenced vehicles, MINI USA, a division of BMW of North America, LLC (""MINI USA"") is extending the limited warranty for the engine's High-Pressure Fuel Pump (HDP) to: 10 years/120,000 miles as determined by the vehicle's original in-service date Item #1: This ""componentspecific"" limited warranty…
• 10151060Feb 1, 2016Electrical system, Equipment. This Service Information bulletin supersedes SI M84 01 14 dated November 2014. SUBJECT Bluetooth Connection Failures. There are various connectivity failures with the following devices: z Apple iPhones z Samsung S6 and the S6 Edge. Connectivity failure examples are: z Call disconnection - Call is transferred back to the handset. In some instances the call is then transferred back to the vehicle.
• 10147906Dec 1, 2015Engine. Surface Cracks on the Water Pump Drive Pulley. During a repair, service or inspection, the drive pulley on the water pump shows signs of cracking. No part replacement is necessary unless there is another issue found that will be corrected by replacing the drive pulley.
• 10147904Dec 1, 2015Electrical system. New programming feature: Exclusion of Infotainment Control Units from Programming.
• 10147800Oct 1, 2015Engine cooling, Visibility (wipers, defrost, mirrors). The Blower Motor is Faulty. The blower motor does not operate at any fan speed. The blower motor may work intermittently with the blower fan speed operating only on FULL speed. CAUSE The blower motor is faulty and causes the blower resistor to fail.
• 10147794Oct 1, 2015Equipment. "MINI Motorer-Focused Satisfaction (MFS) Program. Based on Motorer feedback, MINI has determined that during the first three years of service, some vehicles may require specific additional service work to be performed. To address this issue, MINI USA, a division of BMW of North America, LLC (""MINI USA"") is providing the following Motorer-Focused Satisfaction (MFS) Program. This program's procedures have been…
• 10147290Sep 1, 2015Equipment. NAV Road Map Installation Using USB Stick. The Navigation road map can be installed onto the head unit in the vehicle using a USB stick connected to the USB connector in the center console in the vehicle. 32GB USB stick is necessary Desired NAV road map version can be retrieved from the HDD-Update console PROCEDURE 1. Copy the desired NAV road map from the HDD-Update console onto a 32GB USB stick. Refer to the…
• 10147288Sep 1, 2015Equipment. This Service Information bulletin supersedes SI M64 02 15 dated August 2015. SUBJECT The Blower Motor is Faulty. The blower motor does not operate at any fan speed. The blower motor may work intermittently with the blower fan speed operating only on FULL speed. CAUSE The blower motor is faulty and causes the blower resistor to fail.
• 10147226Jul 1, 2015Equipment, Visibility (wipers, defrost, mirrors). Service Action: Replace Both Sun Visors. When opening the sun visor mirror cover, the pivot pins bind. CAUSE The spring tension is too great and weak pivot pins can break.
• 10059112Jul 1, 2015Engine, Electrical system. Mini: because of the dme software, and a damaged clutch, the drivetrain malfunction check message appear.
• 10059098Jul 1, 2015Engine, Electrical system. Mini: different faults activates engine malfunction and oil warning.
• 10147748Jun 1, 2015Electrical system, Equipment. "CHAMP2: Stored Radio Stations Deleted After Ignition Off. After ignition off, the stored radio stations (AM/FM and Satellite radio) are no longer available in: ? Menu ""PRESETS"" ? Preset buttons on the head unit Hardware error in the CHAMP2 head unit"
• 10059113Jun 1, 2015Electrical system, Engine. Mini: faulty software causes the check control and engine power reduced light to appear.
• 10059111Jun 1, 2015Engine, Electrical system. Mini: due to faulty dme software, the service engine lights comes on, including the check control message for motor force decrease.
• 10059094Jun 1, 2015Engine. Mini: a mechanical failure and dme software error of the vanos actuators cause the engine to run rough which activates the malfunction warning light.
• 10058544Jun 1, 2015Engine. Mini: some vehicles are experiencing several issues as when idling power is loss, before engine starts, extended cranking, clutch pedal fails to return to disengaged position, a high pitched whine noise from lower area of engine. Model f55, 56 (cooper, cooper s, jcw). No years listed.
• 10057380May 22, 2015Engine. Mini: see document search button for owner letter. Questions and answers for timing chain of various mini.
• 10147163May 1, 2015Wheels, Tires. Valve Stem Replacement with Wheel Electronics. Tire pressure loss after replacement of the RDC/RDCi wheel electronics. Valve stems are not being replaced in conjunction of the RDC/RDCi wheel electronics replacement.
• 10152335Apr 1, 2015Brakes. Brake Fluid Maintenance Service: 36-Month Interval. The CBS displays the first brake fluid service as a 36-month interval from the date of production, instead of the appropriate 24-month interval. Only vehicles within the specified production range can be serviced and covered by this bulletin. For vehicles outside of the production range specified in this bulletin, refer to the CBS and/or Key Read information for…
• 10147704Mar 1, 2015Electrical system. "Discharged Battery: Energy Diagnosis Must Be Performed. MINI electrical systems and advancements in vehicle technology have resulted in an increased demand on the vehicle battery. This SI will help the dealer handle ""discharged battery"" complaints. A discharged battery can have various causes, most unrelated to the battery. A failed battery is often the symptom and not the cause.
• 10147700Mar 1, 2015Engine cooling, Engine. "Engine Cranks, No Start and/or Engine Coolant Temperature Faults. 1 The engine either exhibits a crank, no start or a hard start (long crank), usually on a cold engine. No faults are stored in the DME. Proceed to Correction 1 for further diagnosis. 2 NOTE: The engine may also exhibit the same starting behavior as in Situation1. The Service Engine Soon lamp is illuminated, with one or more of the following fault…

← All problems reported for the 2012 MINI Cooper S