2009 MINI Cooper Technical Service Bulletins

92 technical service bulletins (TSBs) are on record for the 2009 MINI Cooper. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10056114Jun 1, 2014Visibility (wipers, defrost, mirrors). Mini: there is a disconnection or kink, in wnidshield washer hose, which is too short, causing windshield front washer jet to fail. Model f56 (cooper, cooper s).
• 10056104Jun 1, 2014Equipment. Mini: suction line (low side) of air conditioner, vibrates, and compressor is excessively loud and runs rough when air conditioner system is on and compressor is active. Model 2009-2010 r55 (cooper clubman, cooper s clubman, r56 (cooper, cooper s), r7 (cooper convertible, cooper s convertible), r60 (cooper countryman, cooper countryman s, cooper countryman all4).
• 10148358May 1, 2014Equipment. Automatic Deactivation of Recirculation Mode. The customer states the recirculation display goes out, even though the recirculation button was switched on. CAUSE The automatic recirculation air deactivation feature was introduced in July 2012. Note: If the customer dislikes this feature, it can be deactivated by using the following steps.
• 10148349May 1, 2014Electrical system, Brakes. Erroneous "Service due" Message Although Brake Lining Thickness is Above Minimum Specification. The yellow "Service Due" warning message lights up in the instrument cluster, even though the brake pad thickness is more than 4.2mm (above the thickness at which the pad sensor intervenes). The calculated remaining service life for the brake pads (front and/or rear axle) from the CBS data does not match the actual brake…
• 10148346May 1, 2014Engine cooling. N16: Fault 274D Mixture Adaptation Is Stored in the DME. Certain low speed, light-load driving conditions at lower outside temperatures could cause the Service Engine Soon lamp (MIL) to illuminate. The following fault would be stored in the DME: Fault 274D: Mixture adaptation, lower engine speed range (mixture too lean) CAUSE 1. Possible intake/exhaust leaks, or a faulty component as listed in the test plan 2…
• 10148293Apr 1, 2014Engine, Equipment. N16 and N18 Engine Oil Leak. The customer states that a small engine oil leak can be seen from the underside of the engine. CAUSE The internal sealing of the oil pump volume control solenoid valve is compromised, allowing engine oil to leak from the oil pump volume control solenoid.
• 10147958Jan 1, 2014Electrical system, Engine. N16: Fault 274D Mixture Adaptation Is Stored in the DME. Certain low speed, light-load driving conditions at lower outside temperatures could cause the Service Engine Soon lamp (MIL) to illuminate. The following fault would be stored in the DME: ??Fault 274D: Mixture adaptation, lower engine speed range (mixture too lean) CAUSE 1. Possible intake/exhaust leaks, or a faulty component as listed in the test plan 2…
• 10147956Jan 1, 2014Electrical system, Engine. "N16 and N18 Engine Oil Leak. The customer states that a small engine oil leak can be seen from the underside of the engine. CAUSE The internal sealing of the oil pump volume control solenoid valve is compromised, allowing engine oil to leak from the oil pump volume control solenoid. DIAGNOSTIC Below is the procedure for identifying how far the engine oil has migrated inside the engine electrical harness, when this…
• 10044680Jan 1, 2014Engine. Mini: on certain model vehicles, an engine oil leak may occur, due to the compromised oil pump volume control solenoid valve, from the underside of engine. No model years listed. *pe updated 4/19/2013. *kb updated 3/11/14.
• 10150203Nov 1, 2013Engine cooling. N16 Engine: FC 2D9B Knock Sensor, Signal Is Stored in the DME. Certain areas of the US experience extremely cold climate conditions during the winter months, which can cause the Service Engine Soon lamp to illuminate while the engine temperature is increasing to full operating temperature. The following fault may be stored in the DME: ??FC 2D9B Knock Sensor, Signal CAUSE Unfavorable DME knock sensor diagnostic at…
• 10150309Oct 1, 2013Seats. Squeaking Noise from Front Seat. A noise may be heard from the front driver's seat back when the customer applies sideways pressure during cornering. CAUSE Surface corrosion on the metal seat back frame can make a squeaking noise when rubbing against the foam rubber padding of the seat back.
• 10150308Oct 1, 2013Latches, locks and linkages. Bonnet Lock Difficult to Open or Close. The bonnet lock fails to operate correctly and is difficult to open or close. CAUSE Corrosion in the bonnet lock assembly
• 10150305Oct 1, 2013Wheels. Adjusting Rear Camber. Rear camber cannot be adjusted properly. CAUSE Repair instructions not followed properly
• 10150301Oct 1, 2013Fuel system. DMTL Pump: Warranty Extension to 10 Years/120,000 Miles. On affected vehicles, the Tank Leak Diagnostic Module (DMTL) pump can fail. Some vehicles will have the Service Engine Soon lamp illuminated, but the vehicle's drivability and engine performance will not be reduced by this DMTL pump malfunction.
• 10150241Aug 1, 2013Equipment. Incorrect Customer Relations Telephone Number Is Saved in the Vehicle. The customer is not connected to MINI Customer Relations after dialing the number displayed in the vehicle Kombi or radio. CAUSE During the Pre-Delivery Inspection (PDI), the incorrect telephone number is being written into the vehicle. INFORMATION 1. When performing the PDI test plan, it is extremely important that you select MINI if the ISID…
• 10150237Aug 1, 2013Electrical system. ?N18 Engine: FC 2BF2 Rail Pressure Sensor Is Stored in DME Fault Memory. The customer states that the Service Engine Soon lamp is illuminated and the following fault is stored in the DME: FC 2BF2 Rail pressure sensor, workspace: pressure too high CAUSE A DME calibration error in the fuel pressure diagnostics results in an increased sensitivity.
• 10053604Aug 1, 2013Equipment. Mini: there is a procedural error in the removing and installing or replacing high pressure pump current version that has been replaced with the corrected repair instruction portion for the n14 and n18 engine. Models r55, 56, 57, 58, 59, 60, 61. No model years listed.
• 10150046Jul 1, 2013Brakes. Clicking Noise from Front Axle Brakes.
• 10150091Jun 1, 2013Equipment, Electrical system. "DWA (Anti-theft Alarm System): False Alarm Is Triggered Intermittently. INFORMATION Parts replacement will not solve the problem if one or more of the conditions described in the situation above caused the alarm to trigger. The sensitivity of the interior ultrasonic sensor cannot be reduced.
• 10149623May 1, 2013Vehicle speed control, Electrical system. "Discharged Battery: Energy Diagnosis Must Be Performed. MINI electrical systems and advancements in vehicle technology have resulted in an increased demand on the vehicle battery. This SI will help the dealer handle ""discharged battery"" complaints. A discharged battery can have various causes, most unrelated to the battery. A failed battery is often the symptom and not the cause.
• 10149621May 1, 2013Engine. Whistling Noise from the Water Pump Area. A whistling or squealing noise is heard from the engine at idle and/or at higher engine speeds. CAUSE 1. Noise is caused by the water pump. 2. Noise is caused by the friction wheel of the belt tensioner.
• 10149507Apr 1, 2013Equipment, Visibility (wipers, defrost, mirrors). Red or Blue Cap Missing from Temperature Control Wheel. The customer states the red or blue cap is missing from the temperature control wheel of the heat and air conditioning control panel.
• 10149504Apr 1, 2013Tires, Wheels, Equipment. "MINI GP: Choice of Tire Option Agreement and Alternate Tire Retrofit. The Kumho 215/40 R17 Ecsta V700 sport tire performance optimization results in vehicle operation limitations, specifically when operated in cold climates or on wet, slushy or snow-covered roads.
• 10149500Apr 1, 2013Engine. Engine Oil Leak. The customer states that a small engine oil leak can be seen from the underside of the engine. CAUSE The internal sealing of the oil pump volume control solenoid valve is compromised, allowing engine oil to leak from the oil pump volume control solenoid.
• 10149464Feb 1, 2013Engine cooling. "N16 Engine: FC 2D9B Knock Sensor, Signal Is Stored in the DME. Certain areas of the US experience extremely cold climate conditions during the winter months, which can cause the Service Engine Soon lamp to illuminate while the engine temperature is increasing to full operating temperature.
• 10149332Jan 1, 2013Brakes. Erroneous "Service due" Message Though Brake Lining Thickness Sufficient. The CBS data calculated for the remaining distance of the front and/or rear brake pads does not agree with the actual brake pad thickness. The yellow brake lining service due indicator illuminates even though the pad thickness is greater than the minimum wear limit (approximately 3.7 mm); the brake wear sensor has not yet been activated (from…
• 10150357Oct 1, 2012Electrical system. ?SUBJECT DWA (Anti-theft Alarm System): False Alarm Is Triggered Intermittently. When the vehicle is parked and locked (DWA active), the alarm system is triggered intermittently. One or more of the following conditions may trigger the alarm system: Sun roof in the tilted/open position, Window partially open, Excessive local noise (for example, near an airport, on a busy road, or in heavy rain) CAUSE Normal…
• 10150356Oct 1, 2012Electrical system. "Discharged Battery: Energy Diagnosis Must Be Performed. MINI electrical systems and advancements in vehicle technology have resulted in an increased demand on the vehicle battery. This SI will help the dealer handle ""discharged battery"" complaints. A discharged battery can have various causes, most unrelated to the battery. A failed battery is often the symptom and not the cause.
• 10150347Oct 1, 2012Engine cooling. During Engine Oil Service a Small O-Ring Is Found in the Oil Filter Housing. No customer complaint has been received. During the scheduled engine oil service, the technician notices a black rubber o-ring lying on the bottom of the engine oil filter housing. The o-ring has been dislodged from the non-return valve inside the engine oil filter housing. No subsequent engine damage occurs from the dislodged o-ring.
• 10044699Jun 1, 2012Engine. Mini: when resealing engine oil pan, engine oil pan gasket replacement should no longer be used due to causing sealing flange becoming deformed. Models r55, r56, r59, r60, r57, and r58. No model years listed.
• 10043927Mar 1, 2012Air bags. Bmw mini: airbag warning light is on: mrs fc 02, 03, 05, 06.
• 10043722Feb 1, 2012Fuel system. Mini: information provided regarding procedure of replacing fuel level sensor due to failure on the right and/or left side.
• 10043725Jan 1, 2012Other or unknown, Latches, locks and linkages. Mini: after drive-away locking activates, it is not possible to unlock the boot.
• 10040855Jul 1, 2011Electrical system. Bmw: a software error is causing a hesitation or jerking when accelerating under higher loads between 3000 ¿ 4000 rpm.
• 10039593May 1, 2011Air bags. Bmw: the airbag warning light is on with a fault stored. The wiring under the seat may be pinched or damaged.
• 10040741Feb 1, 2011Engine cooling. Bmw: engine too hot message is displayed with stored trouble codes. The water pump doesnt power up.
• 10037305Nov 1, 2010Engine cooling. Bmw: description and specifications of crankcase ventilation system.
• 10035904Oct 1, 2010Electrical system. Mini: check control message but lights are operating normally. Intermittently, a bulb out check control message is displayed, but all bulbs appear to be working normally. Models r55, 56, 57.
• 10035884Oct 1, 2010Engine cooling, Fuel system. Mini: teileclearing for n14/n18 engine drivability and fuel system. Enhanced technical support (teileclearing) process has been developed to help identify the root causes ofcustomer complaints relating to the n14/n18 drivability and fuel system *e.g., long crank, loss of power, ses lamp on, etc.). This process can also help expedite the defect eradication process, once the root cause has been determined. No model…
• 10030667Mar 1, 2009Exterior lighting. Mini vehicles: while driving or at idle, the headlamps flicker or sporadically move up or down by themselves. The headlamp wiring harness is damaged due to chaffing at the engine ground point.
• 10030164Mar 1, 2009Exterior lighting. Mini: while driving or at idle, the headlamps flicker or sporadically move up or down by themselves. The headlamp wiring harness is damaged due to chaffing at the engine ground point. R55 (cooper clubman, cooper s clubman); r56 (cooper, cooper s).
• 10032985Dec 1, 2007Engine cooling. Mini: electric cooling fan runs after engine is shut off. After the engine is shut off, the electric cooling fan continues to run. Due to the operating strategy of the dme, the electric cooling fan may continue to run after the engine is shut off in two different scenarios. Engine coolant temp reaches 108 degrees celsius (due to heat soak), cooling fan will activate til coolant temp drops below 105 degrees celsius.

← All problems reported for the 2009 MINI Cooper