2005 Nissan Pathfinder Technical Service Bulletins

90 technical service bulletins (TSBs) are on record for the 2005 Nissan Pathfinder. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10192217Jul 23, 2013Wheels, Steering, Brakes. If YOU CONFIRM: A vehicle needs to have the brake rotors resurfaced (front or rear). ACTION: Use the ProCut PFM Series on-car brake lathe to perform brake rotor resurfacing and follow the tips listed in this bulletin. - The ProCut PFM Series brake lathe has been chosen as the approved tool for rotor resurfacing. - The ProCut PFM Series brake lathe can be ordered from TECH-MATE at 1-800-662-2001. - ProCut technical…
• 10192216Jul 23, 2013Suspension, Steering, Brakes, Wheels. SERVICE INFORMATION - This bulletin is to assist you in responding to customer questions about brake operation, and provides diagnostic and repair information for each item listed, if any should occur. - Most brake incidents fall into the following categories: a. Brake Noise: A squeak, squeal, clunk, or groan that occurs when the brakes are applied or released. b. Brake Judder: A vibration that can be felt in the…
• 10192192Jun 7, 2013Electrical system. As part of an enhanced emissions test for Inspection & Maintenance (I/M), some States may require the System Readiness Test (SRT) status be checked. - The SRT is used to indicate whether the engine control module (ECM) has completed self diagnosis of major emissions systems and components. - In these instances the State may require completion of the SRT before permitting the emissions inspection to proceed. Refer…
• 10051767Apr 3, 2013Latches, locks and linkages. Nissan: lock/unlock request button on outside handle does not respond.
• 10192145Mar 19, 2013Suspension. SERVICE INFORMATION This bulletin provides information to identify: - A leaking strut or a shock absorber that qualifies for replacement under warranty. - A strut or shock absorber that has slight oil seepage, a condition which is considered normal, does not affect strut/shock absorber operation or performance, and does not require replacement. - A strut or shock absorber that should be replaced due to rod…
• 10192051Oct 12, 2012Transmission and drivetrain. Nissan has decided in the interest of customer satisfaction, to further extend the warranty for the Radiator Assembly on all 2005-10 Frontier, Pathfinder, and Xterra vehicles equipped with automatic transmissions.
• 10043950Apr 10, 2012Transmission and drivetrain. Nissan: ecm replacement procedures with consult iii plus. Applies to all 2004 and later (does not apply to leaf/ev) vehicles.
• 10043771Mar 22, 2012Steering. Nissan: pathfinder, xterra, and frontier; power steering hose service part change.
• 10035684Jan 14, 2011Equipment. Nissan: navigation map data update matrix. Affecting all vehicles 2003-11 except leaf, equipped with navigation system. Customer is mailed update disc(s) or sd card and installs data; dealership is mailed update disc(s) and the dealership installs data when vehicle is brought in.
• 10032627Nov 30, 2010Fuel system. Nissan: fuel gauge issues and/or dtc p0461/2/3. The fuel gauge is erratic, inaccurate, or inoperative. The mil is on with dtc p0461, p0462, or p0463 stored in self diagnosis. Replace the fuel level sending unit with the one from the parts information section. *pe updated 1/24/11. *pe amendment updated. 2/28/11.
• 10034904Oct 6, 2010Suspension. Nissan: front suspension noise. A noise (clunking, squeaking, popping) can be heard when performing at least one of the following actions: turning the steering wheel left or right, driving over speed bumps, driving on rough roads, accelerating or decelerating and noise is coming from the front stabilizer bar bushing.
• 10031305Sep 30, 2010Tires. Nissan: tire pressure monitoring system (tpms) warning light on/flashing. No models or model years listed. *pe updated on 08-11-2011.
• 10032506Sep 13, 2010Equipment. Nissan: vent control valve replacement. When replacing the evap canister vent control valve for reason: use the one listed on page 2; for vent control valve replacement procedure, refer to the appropriate section of the electronic service manuals (esm; when installing the new valve, do not add any lube to its o ring; for frontier (d40 series) only, install the protector listed in parts information. *pe includes…
• 10032992Apr 27, 2010Exterior lighting. Nissan: xenon head lamp service. A xenon headlamp is not functioning because of an issue inside the headlamp assembly (an internal issue). In most cases, replacement of a bulb or hid control unit will solve the incident. This includes all models with xenon head lamps. No models listed.
• 10033710Apr 20, 2010Engine cooling, Equipment. Nissan: blower motor does not work. The blower motor for heater and air conditioner does not operate. There are signs of water intrusion in the blower motor.
• 10032628Apr 8, 2010Equipment, Suspension. Nissan: the propeller shaft u joint (journal/journal bearings) is the source of noise and/or vibration on an applied vehicle. Diagnose by evaluating the u joint with the propeller shaft removed. Replace the u joint (journal/journal bearings).
• 10033345Mar 19, 2010Transmission and drivetrain. Nissan: oil leaking from transfer case. Oil is leaking from one or a combination of three bolts at the rear of the transfer case. If bolts are not missing, do not replace transfer case, transfer control device; or transfer control unit for this incident, it should occur.
• 10030165Apr 6, 2009Electrical system. Nissan: the 12 volt battery is an important part of the vehicle electrical system and is required to stay connected when the engine is running. To prevent damage to vehicle electronic components follow the instructions/cautions. No model years listed.
• 10025003Jun 13, 2008Seats. Seat back board removal/installation.
• 10024689Apr 28, 2008Transmission and drivetrain. Nissan; special automatic transmission fluid requirement. 2004 to current nissan vehicles.
• 10022421Jul 17, 2007Engine cooling. Buzzing/whining noise from timing chain area.
• 10021508Apr 18, 2007Exterior lighting. Exterior lamp fogging.
• 10020267Aug 3, 2006Body and structure, Transmission and drivetrain. Pop/clunk noise from the front of the vehicle.
• 10020081Jun 13, 2006Air bags. Driver's seat side air bag open circuit (dtc b1134).
• 10019780Apr 12, 2006Brakes. Squeaking noise from brakes.
• 10019613Mar 31, 2006Engine cooling. Mil on with dtc u1000 or u1010 stored in engine control unit.
• 10019625Mar 30, 2006Fuel system. Squeak from fuel pump.
• 10019300Feb 8, 2006Engine cooling. Malfunction indicator lamp on with diagnostic trouble code u1000 or u1010 stored in engine control unit.
• 10017420Nov 22, 2005Seats. Right front seat back assembly rattles and excessive side-to-side movement.
• 10012840Oct 31, 2005Engine cooling. Rattle noise from vias power valve actuator / intake manifold collector.
• 10017471Oct 27, 2005Suspension. Cam bolts for front wheel alignment.
• 10017475Oct 19, 2005Seats. Driver's power seat up/down function does not move.
• 10017410Sep 22, 2005Electrical system. Voluntary service campaign body control module sub-harness. Enhanced electronic circuitry which may help furtherprotect a vehicle from damage or fire caused by a short circuit in the electrical system of a towed trailer.
• 10017401Sep 16, 2005Seats. Front passenger flod flat seat manual recliner inoperative.
• 10016510Jul 26, 2005Seats. Front seat manual recliner inoperative.
• 10016135Jun 22, 2005Equipment. Voluntary service campaign-2005 pathfinder vehicle dynamic control (vdc)
• 10015340Jun 22, 2005Electrical system. Vehicle dynamic control (vdc) voluntary service campaign p5219.
• 10015998Mar 29, 2005Electrical system. 2005 pathfinder with 4wd; dtc p1720 v/sp sen (a/t out) stored in the ecm.
• 10012866Mar 16, 2005Equipment. Poor radio reception in am fm modes.
• 10012899Mar 9, 2005Body and structure. Rattle at sunroof frame and #1 roof bow.

← All problems reported for the 2005 Nissan Pathfinder