2016 Nissan Titan XD Technical Service Bulletins

304 technical service bulletins (TSBs) are on record for the 2016 Nissan Titan XD. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10109116Dec 20, 2016Fuel system. 2016-2017 TITAN XD; DIESEL EXHAUST FLUID (DEF) AND DIESEL FUEL CONTAMINATION PRECAUTION SERVICE INFORMATION CAUTION: Contamination of the Diesel Exhaust Fluid (DEF) system with fluids other than DEF can cause permanent damage to the components of the DEF system. CAUTION: Putting DEF or gasoline into the diesel fuel system will contaminate the entire system and can cause permanent damage to the components of the…
• 10109108Dec 15, 2016Engine cooling. High Pressure Turbocharger Voluntary Emissions Service Campaign The announcement from October 13th, 2016 has been revised to include: o Campaign Bulletin NTB16-097 has been amended to include instructions for repair if the High Pressure turbo fails inspection and DTC P0524 (Engine Oil Pressure) is stored. - Please discard earlier versions of this bulletin.
• 10119178Dec 14, 2016Engine cooling. VOLUNTARY EMISSIONS SERVICE CAMPAIGN 2016 TITAN XD WITH CUMMINS 5.0L; HIGH PRESSURE TURBOCHARGER This bulletin has been amended to include instructions for repair if DTC P0524 is stored and, if the HP turbo fails inspection. Please discard previous versions of this bulletin.
• 10109114Dec 14, 2016Equipment. PLASTIC INTERIOR TRIM PROTECTIVE COVERING REMOVAL SERVICE INFORMATION Vehicles are delivered with plastic interior trim protective covering on the front and rear seats, front and rear door panel finishers, steering wheel, and sun visors (see examples on page 2). When removing the protective covering, care must be used to avoid scuffs, scrapes, cuts, and other abrasive contact to interior trim components. DO NOT use…
• 10119266Nov 29, 2016Engine. INTELLIGENT KEY NOT DETECTED / ENGINE WILL NOT START This bulletin has been amended to update the Applied Vehicles and make changes to the body of the bulletin. Please discard previous versions.
• 10119282Nov 28, 2016Engine. NISSAN; DIAGNOSIS INFORMATION FOR ABS DTC C1130 SERVICE INFORMATION When diagnosing for DTC C1130 (ENGINE SIGNAL): ECM related DTCs (P-codes) must be diagnosed, repaired, and DTCs erased first. - DTC C1130 is an ABS DTC that indicates an output signal of the ECM is not recognized. - Absent or incorrect ECM signals, that are indicated by corresponding P-codes, may trigger C1130 in the ABS control unit.
• 10119274Nov 14, 2016Engine. TELEMATICS SERVICE INFORMATION This bulletin has been amended. Information for 2017 Rogue and Rogue Hybrid has been applied. No other changes have been made. Please discard previous versions of this bulletin.
• 10119272Nov 14, 2016Engine. 2016 TITAN XD; ENGINE RPM FLUCTUATES WHILE DRIVING AT STEADY SPEED IF YOU CONFIRM While driving at a steady speed, the engine RPM goes up and down (fluctuates) a small amount. ACTION 1. Refer to step 6 in the SERVICE PROCEDURE to confirm TCM reprogramming applies. 2. If it applies, reprogram the TCM.
• 10120591Nov 11, 2016Equipment. 2016-2017 TITAN XD; 7 A/T DTCs STORED This bulletin has been amended to update Applied Vehicles. Please discard previous versions of this bulletin.
• 10120598Nov 10, 2016Transmission and drivetrain. Transmission Control Module Reprogram ***** Detailed Information ***** Nissan is conducting a dealer inventory service action to reprogram and, if necessary calibrate, the Transmission Control Module (TCM) on specific MY2016-17 Titan XD (A61D) vehicles identified in SERVICE COMM. These vehicles are either currently in dealer inventory or assigned and in transit to the dealer. No parts are required for this action…
• 10120593Nov 8, 2016Transmission and drivetrain. 2016-2017 TITAN XD; TRANSMISSION SHIFT QUALITY ISSUES This bulletin has been amended. Changes have been made throughout. Please discard previous versions of this bulletin.
• 10120590Nov 8, 2016Transmission and drivetrain. 2016-2017 TITAN XD; 6AT TRANSMISSION CALIBRATION This bulletin has been amended. Steps 13, 16, 17, 19, 22 and 23 have been revised, the APPLIED VEHICLES section has been updated, and page 10 has been created for distribution to the customer. No other changes have been made. Please discard previous versions of this bulletin.
• 10109132Oct 28, 2016Equipment. 2016 TITAN XD; BUZZ NOISE FROM SUBWOOFER IF YOU CONFIRM With the audio system ON, a buzz/vibration noise is coming from the subwoofer mounting points under the passenger side seat. NOTE: If this incident should occur, - The customer may report the noise is coming from the passenger door. - The noise may be heard inside and outside the vehicle. ACTION Install the new subwoofer mounting screws and grommets listed in…
• 10109131Oct 27, 2016Equipment, Engine. 2016 TITAN XD WITH CUMMINS 5.0L; DPF WARNING LIGHT IS ON IF YOU CONFIRM: The Diesel Particulate Filter (DPF) warning light is ON AND/OR The Vehicle Information Display states "Exhaust Filter Overloaded See Owner's Manual For Drive Pattern" AND DTC P1451 (Diesel Particulate Filter System Performance) is stored in the ECM NOTE: This DTC will not turn the MIL ON. AND The vehicle has less than 100 miles on the…
• 10109130Oct 17, 2016Suspension, Wheels. 2016-2017 TITAN AND TITAN XD; REVISED WHEEL ALIGNMENT SPECIFICATIONS SERVICE INFORMATION Some of the wheel alignment specifications listed in the Front Suspension (FSU) and Rear Suspension (RSU) sections of the 2016 and 2017 Titan Electronic Service Manual (ESM) have been revised. Updated ESMs will be distributed to the field as quickly as possible. Until the updated ESMs are made available, please use the revised…
• 10109122Oct 17, 2016Engine. 2016 TITAN XD; MIL ON WITH ENGINE DTCs STORED AND/OR IDLE FLUCTUATION This bulletin has been amended to revise the IF YOU CONFIRM section, add information to step 6B and Table A. No other changes were made. Please discard previous versions of this bulletin.
• 10109140Oct 13, 2016Engine cooling. High Pressure Turbocharger - Voluntary Emissions Service Campaign The announcement from September 1st, 2016 has been revised to include: o Campaign Bulletin NTB16-097 is now available on NNAnet, ASIST & Dealer360. o Service Comm now active for retailed VINs. o Dealers may order parts for affected retailed units via DCS beginning October 13, 2016. - Please discard earlier versions of this bulletin.
• 10109128Oct 12, 2016Engine cooling. VOLUNTARY EMISSIONS SERVICE CAMPAIGN 2016 TITAN XD WITH CUMMINS 5.0L; HIGH PRESSURE TURBOCHARGER INTRODUCTION Nissan is conducting a Voluntary Emissions Service Campaign on certain specific Model Year 2016 Nissan Titan XD vehicles with Cummins 5.0L to inspect and replace the high pressure turbocharger assembly. This service will be performed at no charge to owners for parts or labor. IDENTIFICATION NUMBER Nissan…
• 10109124Oct 12, 2016Exterior lighting. 2016 ? 2017 TITAN XD; HEADLAMP AIMING This bulletin has been amended. LED headlamp adjustment information has been corrected. Please discard previous versions of this bulletin.
• 10109127Oct 11, 2016Steering. 2016 TITAN XD; REFILLING AND AIR BLEEDING THE POWER STEERING SYSTEM SERVICE INFORMATION The Electronic Service Manual (ESM) pages for "Refilling and Air Bleeding Hydraulic System" in the ST-Steering System section have been updated/amended. Until the updated Service Manual is made available, please refer to the link below, as needed, for any service or repairs for the 2016 Titan XD that require Refilling and Air…
• 10120589Oct 10, 2016Equipment. TELEMATICS SERVICE INFORMATION ONLY SPECIFIC TRIM PACKAGES ARE AFFECTED This bulletin has been amended. Information for 2017 Altima, Murano, Pathfinder, Sentra, and Titan/Titan XD vehicles has been applied. No other changes have been made. Please discard previous versions of this bulletin.
• 10109126Oct 7, 2016Equipment, Engine cooling. 2016 TITAN XD; MIL ON WITH DTC P226C OR P0471 IF YOU CONFIRM One or both of the following DTCs are stored: - P226C (Turbocharger Boost Control Slow Response) - P0471 (Exhaust Pressure Sensor "A" Circuit Range/Performance) and There are no drivability issues. ACTION 1. Save Computer Data with CONSULT-III plus (C-III plus). 2. At step 6 of the reprogramming procedure, confirm this bulletin applies to the vehicle you…
• 10091582Sep 27, 2016Fuel system. "fuel tank breather tube dealer inventory ***** detailed information ***** nissan is conducting a dealer inventory service action to inspect the routing of the fuel tank breather tube on approximately 6,379specific my2016-17 titan xd (a61d) vehicles. During vehicle assembly, the fuel tank breather tube may not have properly routed and installed. No parts are required for this action."
• 10192850Sep 23, 2016Electrical system, Latches, locks and linkages. vehicles to install an electronic tailgate lock that should have been installed on the vehicle from the factory, but was not.
• 10192849Sep 23, 2016Equipment. Nissan is conducting a voluntary service campaign on certain MY2016 Titan XD vehicles to install splash guards on vehicles that should be equipped with this accessory, but were shipped without the splash guards installed.
• 10192848Sep 23, 2016Equipment. Nissan is conducting a voluntary service campaign on certain MY2016 Titan XD vehicles to install step rails on vehicles that should be equipped with this accessory, but were shipped without the step rails installed.
• 10192847Sep 23, 2016Equipment. Nissan is conducting this voluntary service campaign on certain specific 2016 Titan XD vehicles to install a dual wall bedliner and a cargo tie down kit that should have been installed on the vehicle from the factory, but were not.
• 10091605Sep 8, 2016Exterior lighting. "2016 titan xd; headlamp aiming when adjusting the headlamps on a titan xd, make sure to follow the procedures in the electronic service manual (esm). - warranty claims for headlamp adjustment are subject to audit. - claims must have the measurements for dimension a, b, and c (shown in this bulletin) listed on the repair order and on the technician comments line of the claim. - claims submitted without these…
• 10091588Sep 8, 2016Engine. "2016 titan xd; engine rpm flare during up shift and/or down shift bump this bulletin has been amended. The service procedure has been revised, and applied vin and date information has been added. No other changes have been made. Please discard all previous versions."
• 10091602Sep 6, 2016Equipment. "voluntary service campaign 2016 titan xd; dual wall bedliner and cargo tie down kit this bulletin has been amended. The parts information section has been revised. No other changes have been made. Please discard previous versions of this bulletin."
• 10091584Sep 6, 2016Equipment. "titan box voluntary service campaign the announcement from august 24th, 2016 has been revised to include: o the parts information section has been revised. No other changes have been made. - please discard earlier versions of this bulletin."
• 10091590Sep 1, 2016Body and structure. "2016 titan xd; tailgate will not open or unlock this bulletin has been amended. The applied date information in the repair flow chart on page 2 and in steps 6a and 6b have been revised. No other changes have been made. Please discard all previous versions."
• 10091547Aug 31, 2016Engine cooling. "high pressure turbocharger voluntary emissions service campaign diesel engine only ***** campaign summary ***** as per our august 5th announcement, nissan is conducting a voluntary emissions service campaign on approximately 683 specific my 2016 titan xd diesel (a61) vehicles currently in dealer inventory to address an excessive oil consumption concern with the high pressure turbocharger.
• 10091501Aug 26, 2016Engine. "warranty information booklet voluntary emission service campaign gas engine only nissan is conducting a voluntary emission service campaign on approximately 1,044 model year 2016 nissan titan xd (gasoline only) vehicles. Nissan has discovered that model year 2016 warranty information booklet contains inaccurate information related to the federal emission performance and defect warranty coverage details.
• 10091546Aug 24, 2016Body and structure, Electrical system. "electronic tailgate lock voluntary service campaign ***** campaign summary ***** nissan is conducting a voluntary service campaign on certain my2016 titan xd vehicles to install electronic tailgate locks on vehicles that should be equipped with this accessory, but were shipped without the electronic tailgate locks installed. ***** what dealers should do ***** 1. Verify if vehicles are affected by this voluntary…
• 10091545Aug 24, 2016Equipment. "splash guards voluntary service campaign ***** campaign summary***** nissan is conducting a voluntary service campaign on certain my2016 titan xd vehicles to install splash guards on vehicles that should be equipped with this accessory, but were shipped without the splash guards installed. ***** what dealers should do***** 1. Verify if vehicles are affected by this voluntary service campaign using service comm…
• 10091544Aug 24, 2016Equipment. "step rails voluntary service campaign ***** campaign summary ***** nissan is conducting a voluntary service campaign on certain my2016 titan xd vehicles to install step rails on vehicles that should be equipped with this accessory, but were shipped without the step rails installed. ***** what dealers should do ***** 1. Verify if vehicles are affected by this voluntary service campaign using service comm I.d…
• 10091543Aug 24, 2016Equipment. "titan box voluntary service campaign ***** campaign summary ***** nissan is conducting a voluntary service campaign on certain my2016 titan xd vehicles to install storage boxes on vehicles that should be equipped with this accessory, but were shipped without the storage boxes installed. ***** what dealers should do ***** 1. Verify if vehicles are affected by this voluntary service campaign using service comm I.d…
• 10091524Aug 23, 2016Body and structure. "voluntary service campaign 2016 titan xd; running boards introduction nissan is conducting this voluntary service campaign on certain specific 2016 titan xd vehicles to install running boards that should have been installed on the vehicle from the factory, but were not. This service will be performed at no charge to the customer for parts or labor. Identification number nissan has assigned identification number…
• 10091523Aug 23, 2016Equipment. "voluntary service campaign 2016 titan xd; splash guards introduction nissan is conducting this voluntary service campaign on certain specific 2016 titan xd vehicles to install splash guards that should have been installed on the vehicle from the factory, but were not. This service will be performed at no charge to the customer for parts or labor. Identification number nissan has assigned identification number…
• 10091521Aug 23, 2016Equipment. "voluntary service campaign 2016 titan xd; electronic tailgate lock introduction nissan is conducting this voluntary service campaign on certain specific 2016 titan xd vehicles to install an electronic tailgate lock that should have been installed on the vehicle from the factory, but was not. This service will be performed at no charge to the customer for parts or labor. Identification number nissan has assigned…
• 10091514Aug 23, 2016Equipment. "voluntary service campaign 2016 titan xd; dual wall bedliner and cargo tie down kit introduction nissan is conducting this voluntary service campaign on certain specific 2016 titan xd vehicles to install a dual wall bedliner and a cargo tie down kit that should have been installed on the vehicle from the factory, but were not. This service will be performed at no charge to the customer for parts or labor…
• 10091567Aug 17, 2016Seats. "center seat quality assurance hold the announcement from august 1st, 2016 has been revised to include: - repair, parts, and claims information for the previously announced quality hold"
• 10091525Aug 15, 2016Transmission and drivetrain. "2016 titan xd; bump felt on light throttle application at speeds over 40 mph gas v8 engine only with 7-speed a/t if you confirm a bump or shock is felt from the drivetrain, - only while traveling at 40 mph or more, and then - lightly applying the accelerator after briefly coasting. Action 1. Refer to step 6 in the service procedure to confirm this bulletin applies to the vehicle you are working on. 2. If this…
• 10091565Aug 5, 2016Equipment. "titan xd quality assurance hold the announcement from july 22nd, 2016 has been revised to include: - information on action necessary for the previously announced quality hold"
• 10091503Aug 4, 2016Equipment. "all model year 2012 and newer nissan vehicles; evap leak dtc p0442, p0455, p0456 information this bulletin has been amended. The title has been revised, and the bulletin now includes vehicles in production as of the date of this update. No other changes have been made. Please discard all previous versions of this bulletin."
• 10091509Aug 1, 2016Body and structure. "2016 titan xd; tailgate will not open or unlock if you confirm - tailgate will not unlock with the mechanical key or electrically with the key fob. And/or - tailgate will not unlatch or requires excessive force when pulling on the tail gate handle. Action see the flow chart on page 2 for the appropriate repair for the vin and date of the vehicle being worked on."
• 10091080Aug 1, 2016Seats. "center seat quality assurance hold the announcement from july 14th, 2016 has been revised to include: - information on action necessary for the previously announced quality hold ***** detailed information ***** as per our previous announcement, nissan placed a temporary quality assurance (qa) hold on approximately 23 my 2016 titan vehicles on july 14, 2016 to ensure vehicles delivered to our customers meet our…
• 10091068Jul 30, 2016Equipment. "front prop shaft bolt torque dealer inventory inspection *****dealer announcement***** nissan is conducting a dealer inventory inspection on 963 specific 2016 titan vehicles identified in service comm. Dealers should inspect the front prop shaft bolt torque and if the bolts are found to be not torqued to specification, all bolts and nuts should be replaced and tightened to specification these vehicles are either…
• 10091413Jul 27, 2016Engine. "remote engine start not working this bulletin has been amended. Changes have been made to items 1, 4, and 13 in the supplemental diagnosis table. No other changes have been made. Please discard previous versions of this bulletin.

← All problems reported for the 2016 Nissan Titan XD