2017 Nissan Titan Technical Service Bulletins

249 technical service bulletins (TSBs) are on record for the 2017 Nissan Titan. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10120566Jul 21, 2017Equipment. NISSAN; DTC P0456 CAUSED BY EVAP LEAK AT VENT CONTROL VALVE O-RING IF YOU CONFIRM The MIL is ON in an APPLIED VEHICLE with DTC P0456 (EVAP VERY SML LEAK) AND - DTC P0456 is not caused by a loose fuel fill cap (refer to NTB13-097). - An EVAP leak has been detected where the vent control valve mounts to the canister. - The vent control valve O-ring seal is determined to be the cause. ACTION 1. DO NOT REPLACE the vent…
• 10120574Jul 13, 2017Equipment. Bed Welds Voluntary Service Campaign ***** Campaign Summary ***** Nissan is conducting a voluntary service campaign on certain 2017 Titan vehicles to repair the right and left hand bed side rails. Due to a manufacturing issue that has since been corrected, the welds between the mating materials on the side rails of the Titan truck bed may not meet Nissan design specifications. In extreme conditions, deformation to…
• 10119229Jul 12, 2017Equipment. VOLUNTARY SERVICE CAMPAIGN 2017 TITAN AND TITAN XD; BED RAIL REPAIR INTRODUCTION Nissan is conducting this voluntary service campaign on certain specific 2017 Titan and Titan XD vehicles to add rivets to the left and right bed rails. This service will be performed at no charge to the customer for parts or labor. IDENTIFICATION NUMBER Nissan has assigned identification number PC577 to this campaign.
• 10116285Jun 29, 2017Engine. 2016-2017 TITAN XD; TRANSMISSION SHIFT QUALITY ISSUES This bulletin applies only to vehicles equipped with a Cummins 5.0L V8 Diesel engine. IF YOU CONFIRM Any of the following issues: - When cold (transmission fluid below 140°F [60°C]), there is an engine RPM rise (200 to 500 RPM flare) during the 1-2 shift, 2-3 shift, and/or the 3-4 shift. - While slowing to a stop, a 2-1 down shift bump is felt just before…
• 10116283Jun 27, 2017Equipment. 2016-2017 TITAN AND TITAN XD; A/C COMPRESSOR SERVICE INFORMATION This bulletin has been amended. The Title and APPLIED VEHICLES section have been revised. No other changes have been made. Please discard previous versions of this bulletin.
• 10119200Jun 21, 2017Brakes. 2016-2017 TITAN AND TITAN XD; NOISE FROM REAR PARKING BRAKES IF YOU CONFIRM The rear parking brake shoes are dragging against the drum surface of the brake rotor and causing noise. ACTION Replace the rear parking brake shoes and retainer springs on both sides of the vehicle.
• 10119199Jun 14, 2017Engine. 2016-2017 TITAN XD; MIL ON WITH DTC U3017 This bulletin applies only to vehicles equipped with a Cummins 5.0L V8 Diesel engine. IF YOU CONFIRM The MIL is ?ON? with DTC U3017 (CAN Communication), and There are no drivability issues. ACTION 1. Save Computer Data with CONSULT-III plus (C-III plus). 2. At step 6 of the reprogramming procedure, confirm this bulletin applies to the vehicle you are working on. 3. If this…
• 10119198Jun 14, 2017Equipment. 2017 TITAN XD; MIL ON WITH DTC P0605 This bulletin applies only to vehicles equipped with a Cummins 5.0L V8 Diesel engine. IF YOU CONFIRM The MIL is ?ON? with DTC P0605 (ECM), and There are no drivability issues. ACTION 1. Save Computer Data with CONSULT-III plus (C-III plus). 2. At step 6 of the reprogramming procedure, confirm this bulletin applies to the vehicle you are working on. 3. If this bulletin applies…
• 10119196Jun 8, 2017Engine. 2016-2017 TITAN XD; MIL ON WITH DTC P0604 AND/OR P2299 This bulletin applies only to vehicles equipped with a Cummins 5.0L V8 Diesel engine. IF YOU CONFIRM The MIL is ON with one or both of the following DTCs stored: - P0604 (ECM [Internal Control Module Random Access Memory (RAM) Error]) - P2299 (ACCEL PEDAL POS BRAKE SWITCH) And There are no drivability issues. ACTION 1. Save Computer Data with CONSULT-III plus…
• 10116290Jun 8, 2017Electrical system. 2016-2017 TITAN XD; MIL ON WITH DTC P218F WHEN OPERATED IN AMBIENT TEMPERATURE AT 32°F OR BELOW This bulletin applies only to vehicles equipped with a Cummins 5.0L V8 Diesel engine. IF YOU CONFIRM The MIL is ON with DTC P218F (REDUCTANT NO FLOW DETECTED) stored When The vehicle is operated in ambient temperatures at 32°F (0°C) or below And There are no drivability issues. ACTION 1. Save Computer Data with…
• 10116289Jun 8, 2017Electrical system. 2016-2017 TITAN XD; DELAY WITH RE-ACCELERATION This bulletin applies only to vehicles equipped with a Cummins 5.0L V8 Diesel engine. IF YOU CONFIRM Re-acceleration delay as follows: - Driving at a moderate steady speed, then - Reduce accelerator position to slow down, then - Increase accelerator position to bring the vehicle back to the previous speed, then - There is a delay/hesitation before the vehicle begins to…
• 10109262Apr 28, 2017Steering, Transmission and drivetrain. Automatic Transmission Dealer Inventory This bulletin applies to diesel Titan XD 4WD vehicles. *****Dealer Announcement***** Nissan is conducting a dealer inventory quality action to perform several inspections on 3,366 specific 2017 Titan XD Diesel 4-wheel drive vehicles identified in Service Comm.
• 10109261Apr 28, 2017Steering, Transmission and drivetrain. Automatic Transmission Dealer Inventory This bulletin applies to diesel Titan XD 2WD vehicles. *****Dealer Announcement***** Nissan is conducting a dealer inventory quality action to perform several inspections on 974 specific 2017 Titan XD Diesel 2-wheel drive vehicles identified in Service Comm.
• 10109260Apr 28, 2017Transmission and drivetrain, Steering. Automatic Transmission Dealer Inventory This bulletin applies to gasoline Titan XD 4WD vehicles. *****Dealer Announcement***** Nissan is conducting a dealer inventory quality action to perform several inspections on 1,113 specific 2017 Titan XD Gasoline 4-wheel drive vehicles identified in Service Comm.
• 10109259Apr 28, 2017Steering, Transmission and drivetrain. Automatic Transmission Dealer Inventory This bulletin applies to gasoline Titan XD 2WD vehicles. *****Dealer Announcement***** Nissan is conducting a dealer inventory quality action to perform several inspections on 430 specific 2017 Titan XD Gasoline 2-wheel drive vehicles identified in Service Comm.
• 10109256Apr 18, 2017Transmission and drivetrain. 2017 ARMADA, TITAN AND TITAN XD SHIFT SHOCK, LACK OF POWER, AND/OR RPM FLUCTUATES This bulletin applies only to vehicles equipped with gasoline engine. This bulletin has been amended throughout. Please discard previous versions of this bulletin.
• 10109254Apr 11, 2017Engine cooling. NISSAN; OIL LEAKING AROUND VALVE TIMING CONTROL SOLENOID VALVE This bulletin applies to vehicles equipped with 6-cylinder engines. For Titan and Titan XD, this bulletin applies only vehicles equipped with gasoline engines. This bulletin has been amended in the PARTS INFORMATION and CLAIMS INFORMATION sections. Discard previous versions of this bulletin.
• 10120562Apr 6, 2017Transmission and drivetrain. Automatic Transmission Dealer Inventory This bulletin applies to 2WD vehicles, it does not apply to Titan XD. *****Dealer Announcement***** Nissan is conducting a dealer inventory quality action to perform several inspections on 6,705 specific 2017 Titan (non-XD) Gasoline 2-wheel drive vehicles identified in Service Comm.
• 10109258Apr 6, 2017Transmission and drivetrain, Steering. Automatic Transmission Dealer Inventory This bulletin applies to 4WD vehicles, it does not apply to Titan XD. *****Dealer Announcement***** Nissan is conducting a dealer inventory quality action to perform several inspections on 5,209 specific 2017 Titan (non-XD) Gasoline 4-wheel drive vehicles identified in Service Comm.
• 10109214Mar 20, 2017Fuel system. NISSAN; FUEL TANK IS SLOW OR DIFFICULT TO FILL IF YOU CONFIRM The fuel tank is slow or difficult to fill (filling nozzle shuts off before tank is full). IMPORTANT: Make sure this incident has been duplicated at a gas station by dealer service staff. ACTION Perform the Service Procedure in this bulletin, starting on the next page.
• 10109215Mar 16, 2017Engine cooling. 2016 - 2017 TITAN XD; COOLANT HEATER (ENGINE BLOCK HEATER) INSTALLATION This bulletin applies only to vehicles equipped with Cummins 5.0L Diesel engine. SERVICE INFORMATION Some customers may want to use a coolant heater (engine block heater) for their vehicle when ambient temperatures are below 32°F (0°C). 2016 Titan XD: - Some were not equipped from the factory with a coolant heater or cord. - Some were equipped…
• 10109206Mar 16, 2017Equipment, Electrical system. 20172016-2017 NISSAN CONNECT NAVIGATION SYSTEM SOFTWARE UPDATE This bulletin applies only to vehicles equipped with navigation system. This bulletin has been amended. The APPLIED VEHICLES section has been revised. No other changes have been made. Please discard previous versions of this bulletin.
• 10109204Mar 10, 2017Equipment, Engine cooling. 2016-2017 TITAN XD; EXHAUST SMELL INSIDE VEHICLE WHEN HVAC IS ON FRESH AIR This bulletin has been amended to update Applied Vehicles, add step 11 to the Service Procedure and add a flowchart. No other changes have been made. Please discard previous versions of this bulletin.
• 10109211Mar 7, 2017Suspension, Equipment. BALL JOINT AXIAL END PLAY PROCEDURE SERVICE INFORMATION When working on the front suspension, use the updated service information in this bulletin along with the Electronic Service Manual (ESM). The updated information in this bulletin is a correction and a supplement to the ESM.
• 10109178Feb 21, 2017Engine, Electrical system, Equipment. ECM Reprogram Dealer Inventory *****Dealer Announcement***** Nissan is conducting a dealer inventory service action to update Electronic Control Module (ECM) software on 7,719 specific 2017 Titan and 4,759 Armada vehicles identified in Service Comm. On the affected vehicles, the ECM software is being updated to refine the MIL illumination logic for the exhaust gas temperature sensor.
• 10109173Feb 1, 2017Body and structure. 2016 - 2017 TITAN AND TITAN XD; STEP RAIL END CAP CHROME TRIM AVAILABLE AS SEPARATE PART This bulletin applies only to Crew Cab models. SERVICE INFORMATION The end cap chrome trim (front and rear) on the step rails (running boards) is now available as a separate part (see Parts Information). If the end cap chrome trim needs to be replaced for any reason (fell off, damaged, etc.), replace only the end cap chrome trim.
• 10109159Jan 27, 2017Equipment, Engine. NISSAN; OIL LEAKING AROUND VALVE TIMING CONTROL SOLENOID VALVE This bulletin applies only to Maxima, Quest, Altima Coupe, Altima, Pathfinder and Murano vehicles equipped with V6 engine OR Titan/Titan XD equipped with VK56 engine IF YOU CONFIRM Engine oil is leaking from a valve timing control solenoid valve, And The valve timing control solenoid valve operates correctly and is not externally damaged.
• 10109152Jan 25, 2017Equipment, Electrical system. 20172016-2017 NISSAN CONNECT NAVIGATION SYSTEM SOFTWARE UPDATE This bulletin only applies to vehciles equipped with navigation system. This bulletin has been amended. The APPLIED VEHICLES section has been revised. No other changes have been made. Please discard previous versions of this bulletin.
• 10109151Jan 12, 2017Transmission and drivetrain. 2016-2017 TITAN XD; 6AT TRANSMISSION CALIBRATION This bulletin has been amended to direct technicians to the ESM for transmission adjustment. Please discard previous versions of this bulletin.
• 10109154Jan 6, 2017Engine cooling. 2016-2017 TITAN XD; CORRECT PARKING ANGLE OF VEHICLE WHEN USING ENGINE BLOCK HEATER SERVICE INFORMATION When using the engine block heater (if equipped) on an Applied Vehicle (engine block heater is plugged in): - Vehicle should be parked on a level surfaces. Or - If a level surface is not available, the vehicle should be parked with the front of the truck lower than the rear (nose down).
• 10109116Dec 20, 2016Fuel system. 2016-2017 TITAN XD; DIESEL EXHAUST FLUID (DEF) AND DIESEL FUEL CONTAMINATION PRECAUTION SERVICE INFORMATION CAUTION: Contamination of the Diesel Exhaust Fluid (DEF) system with fluids other than DEF can cause permanent damage to the components of the DEF system. CAUTION: Putting DEF or gasoline into the diesel fuel system will contaminate the entire system and can cause permanent damage to the components of the…
• 10109115Dec 19, 2016Engine. 2017 ARMADA AND TITAN/TITAN XD; MIL IS ON WITH DTC P2080 AND/OR P2082 IF YOU CONFIRM: The MIL is ON with DTC - P2080 (EXHAUST GAS TEMP SENSOR 1 B1), And/or - P2082 (EXHAUST GAS TEMP SENSOR 1 B2). ACTION: 1. Refer to step 6 in the SERVICE PROCEDURE to confirm this bulletin applies to the vehicle you are working on. 2. If this bulletin applies, reprogram the ECM. NOTE: If this bulletin does apply (the ECM needs to be…
• 10109114Dec 14, 2016Equipment. PLASTIC INTERIOR TRIM PROTECTIVE COVERING REMOVAL SERVICE INFORMATION Vehicles are delivered with plastic interior trim protective covering on the front and rear seats, front and rear door panel finishers, steering wheel, and sun visors (see examples on page 2). When removing the protective covering, care must be used to avoid scuffs, scrapes, cuts, and other abrasive contact to interior trim components. DO NOT use…
• 10119266Nov 29, 2016Engine. INTELLIGENT KEY NOT DETECTED / ENGINE WILL NOT START This bulletin has been amended to update the Applied Vehicles and make changes to the body of the bulletin. Please discard previous versions.
• 10119282Nov 28, 2016Engine. NISSAN; DIAGNOSIS INFORMATION FOR ABS DTC C1130 SERVICE INFORMATION When diagnosing for DTC C1130 (ENGINE SIGNAL): ECM related DTCs (P-codes) must be diagnosed, repaired, and DTCs erased first. - DTC C1130 is an ABS DTC that indicates an output signal of the ECM is not recognized. - Absent or incorrect ECM signals, that are indicated by corresponding P-codes, may trigger C1130 in the ABS control unit.
• 10119274Nov 14, 2016Engine. TELEMATICS SERVICE INFORMATION This bulletin has been amended. Information for 2017 Rogue and Rogue Hybrid has been applied. No other changes have been made. Please discard previous versions of this bulletin.
• 10120591Nov 11, 2016Equipment. 2016-2017 TITAN XD; 7 A/T DTCs STORED This bulletin has been amended to update Applied Vehicles. Please discard previous versions of this bulletin.
• 10120598Nov 10, 2016Transmission and drivetrain. Transmission Control Module Reprogram ***** Detailed Information ***** Nissan is conducting a dealer inventory service action to reprogram and, if necessary calibrate, the Transmission Control Module (TCM) on specific MY2016-17 Titan XD (A61D) vehicles identified in SERVICE COMM. These vehicles are either currently in dealer inventory or assigned and in transit to the dealer. No parts are required for this action…
• 10120593Nov 8, 2016Transmission and drivetrain. 2016-2017 TITAN XD; TRANSMISSION SHIFT QUALITY ISSUES This bulletin has been amended. Changes have been made throughout. Please discard previous versions of this bulletin.
• 10120590Nov 8, 2016Transmission and drivetrain. 2016-2017 TITAN XD; 6AT TRANSMISSION CALIBRATION This bulletin has been amended. Steps 13, 16, 17, 19, 22 and 23 have been revised, the APPLIED VEHICLES section has been updated, and page 10 has been created for distribution to the customer. No other changes have been made. Please discard previous versions of this bulletin.
• 10109130Oct 17, 2016Suspension, Wheels. 2016-2017 TITAN AND TITAN XD; REVISED WHEEL ALIGNMENT SPECIFICATIONS SERVICE INFORMATION Some of the wheel alignment specifications listed in the Front Suspension (FSU) and Rear Suspension (RSU) sections of the 2016 and 2017 Titan Electronic Service Manual (ESM) have been revised. Updated ESMs will be distributed to the field as quickly as possible. Until the updated ESMs are made available, please use the revised…
• 10109124Oct 12, 2016Exterior lighting. 2016 ? 2017 TITAN XD; HEADLAMP AIMING This bulletin has been amended. LED headlamp adjustment information has been corrected. Please discard previous versions of this bulletin.
• 10120589Oct 10, 2016Equipment. TELEMATICS SERVICE INFORMATION ONLY SPECIFIC TRIM PACKAGES ARE AFFECTED This bulletin has been amended. Information for 2017 Altima, Murano, Pathfinder, Sentra, and Titan/Titan XD vehicles has been applied. No other changes have been made. Please discard previous versions of this bulletin.
• 10091582Sep 27, 2016Fuel system. "fuel tank breather tube dealer inventory ***** detailed information ***** nissan is conducting a dealer inventory service action to inspect the routing of the fuel tank breather tube on approximately 6,379specific my2016-17 titan xd (a61d) vehicles. During vehicle assembly, the fuel tank breather tube may not have properly routed and installed. No parts are required for this action."
• 10091503Aug 4, 2016Equipment. "all model year 2012 and newer nissan vehicles; evap leak dtc p0442, p0455, p0456 information this bulletin has been amended. The title has been revised, and the bulletin now includes vehicles in production as of the date of this update. No other changes have been made. Please discard all previous versions of this bulletin."
• 10192827May 19, 2016Equipment. SERVICE INFORMATION The Applied Vehicles are equipped with a wireless communication device called a Telematics Communication Unit (TCU). With an active NissanConnectSM Services subscription, the TCU communicates with the NissanConnectSM Services Data Center to provide various security and convenience services. This bulletin contains important service procedures that must be performed properly in order to set-up and…
• 10192810Apr 21, 2016Transmission and drivetrain, Equipment. SERVICE INFORMATION IMPORTANT: If you confirm one or more of the following transmission DTCs are stored: P0729: 6GR Incorrect Ratio P0730: Incorrect Gear Ratio P0731: 1GR Incorrect Ratio P0732: 2GR Incorrect Ratio P0733: 3GR Incorrect Ratio P0734: 4GR Incorrect Ratio P0735: 5GR Incorrect Ratio P1734: 7GR Incorrect Ratio Before performing any transmission repairs: 1.
• 10192574May 7, 2015Wheels. SERVICE INFORMATION The appearance of painted alloy wheels can be damaged if acidic cleaners are used. DO NOT use Chrome Wheel Cleaner on Painted Wheels. Many chrome wheel cleaners have acidic ingredients. Make sure to follow all instruction in the Appearance and Care Section of the Owner?s Manual. Damage to wheel appearance due to the use of inappropriate chemicals or cleaning products is not covered under…
• 10192354Apr 29, 2014Electrical system. SERVICE INFORMATION Warranty claims coding for repairing wiring harnesses for all Nissan vehicles has changed. This bulletin gives an outline of the technician?s responsibilities in assisting the dealer?s claims administrator to properly code a harness repair. Failure to provide correct information may result in claims suspension or rejection. See this bulletin for further detail.

← All problems reported for the 2017 Nissan Titan