2009 Pontiac G8 Technical Service Bulletins

996 technical service bulletins (TSBs) are on record for the 2009 Pontiac G8. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10126198Nov 12, 2012Equipment. This informational bulletin provides a list of newly released PI and Bulletins in regards to recent released vehicles so that vehicles can be fixed right the first time in for service.
• 10112560Nov 9, 2012Brakes. This Preliminary Information communication provides information to the technician about brake rotors on new vehicles and replacement parts from General Motors Service Parts Operations. Technician should be advised the costing should not be removed from the brake rotor it will wear off with normal brake usage. Dealer should communicate to the customer this condition is a normal operating characteristic of their…
• 10126203Nov 8, 2012Equipment. This warranty administration bulletin provides information on what should be considerd warranty damage or damage that was at fault of the cutomer and how to properly claim them on the warranty paperwork
• 10112529Nov 1, 2012Equipment. This Preliminary Information communication provides information to the technician about vehicles that have an OnStar system that will not power up. Technician should turn off the ignition and cancel retained accessory power. After the vehicle has powered down, remove power to the OnStar module for five minutes. After the power has been removed for five minutes, if the OnStar system is working release the vehicle.
• 10112528Nov 1, 2012Electrical system. This Preliminary Information communication provides information to the technician about vehicles that during battery parasitic drain test, there may be some confusion as to what the normal power consumption reading should be from the OnStar system. Technician should understand the power cycles of the various OnStar systems. All Generation 6, 7, 8, and 9 systems are powered up continuously for 48 hours from ignition…
• 10112494Oct 18, 2012Equipment. This Preliminary Information communication provides information to the technician about installing General Motors Accessory parts. Technician can check Service Information for some accessories. Technician can also contact Partech for assistance.
• 10118645Oct 16, 2012Wheels, Tires. This informational bulletin provides information on Driving Characteristics of Rear Wheel Drive Vehicles and Available Winter Tires.
• 10118643Oct 16, 2012Equipment. This preliminary informational bulletin provides a list of corrections for multiple concerns regarding Unexpected Loss of Radio Audio (Radio Goes Silent/No Sound) and Other Blackberry Phone - Bluetooth Issues
• 10084191Oct 16, 2012Equipment, Electrical system. This preliminary informational bulletin provides a list of corrections for multiple concerns regarding unexpected loss of radio audio (radio goes silent/no sound) and other blackberry phone - bluetooth issues
• 10118638Oct 15, 2012Engine cooling. This informational bulletin provides information on Identifying Non-GM (Aftermarket) Engine Calibrations for Gasoline Engines Using Tech 2 or GDS 2
• 10118637Oct 15, 2012Equipment. This informational bulletin provides information on dealer responsibility for cargo carrying capacity labeling and the part numbers for the labels.
• 10118635Oct 15, 2012Visibility (wipers, defrost, mirrors). This preliminary informational bulletin provides a procedure for relearning the power folding mirriors and road testin to verify they correct a condtion of the power folding mirriors glass shakes, flutters at normal driving conditions.
• 10118634Oct 15, 2012Transmission and drivetrain. This warranty administration bulletin provides information on the change in automatic transmission add conditions documentation and claim submissions
• 10084683Oct 15, 2012Equipment, Body and structure, Visibility (wipers, defrost, mirrors). This preliminary informational bulletin provides a procedure for relearning the power folding mirriors and road testin to verify they correct a condtion of the power folding mirriors glass shakes, flutters at normal driving conditions.
• 10112465Oct 11, 2012Equipment. This Preliminary Information communication provides information to the technician about vehicles that have a message on the radio "maximum number of phones are currently paired to the vehicle". Dealer should advise the customer this is normal operation of the vehicle due to the maximum number of five phones can be paired to a vehicle.
• 10118626Oct 10, 2012Equipment. This warranty administrational bulletin provides information on Clarification of Use - Dealer Empowerment Labor Operations and Customer Enthusiasm
• 10118623Oct 9, 2012Equipment. This warranty administrational bulletin provides information on courtesy transportation and roadside assistance programs offered through GM.
• 10118619Oct 5, 2012Equipment. This informational bulletin provides information on newly release bulletins used to fi the vehicles in the field the first time.
• 10246951Oct 1, 2012Equipment. Programming And Activation Of Replacement OnStar Modules.
• 10118610Oct 1, 2012Engine cooling. This technical bulletin provides a procedure to replace the AFM oil deflector, rocker arm cover and clean the carbon deposits for conditons related to Engine Oil Consumption on Aluminum Block/Iron Block Engines with Active Fuel Management
• 10062524Oct 1, 2012Engine. Summary to be provided on a future date.
• 10062496Oct 1, 2012Equipment. Summary to be provided on a future date.
• 10055803Jul 1, 2012Transmission and drivetrain. Cadillac/chevrolet/gmc/hummer/pontiac: there is slipping or have no fourth, fifth or sixth gear and malfunction indicator lamp (mil) would be on, with diagnostic trouble code (dtc) p0796 found as active.
• 10044242May 1, 2012Electrical system. Gm: j-35616-64b terminal test probe and replacement terminal. Also included models verano, regal, lacrosse, cts, srx, volt, sonic, malibu, impala, equinox, cruze, avalanche, tahoe suburban, silverado, sierra, yukon, and terrain for model year 2013. Model escalade model year 2012-2013. Model pontiac g3 model year 2007. Model wave model years 2005-2010. Denali models model years 2007-2013.
• 10038345Feb 1, 2012Engine cooling. Buick/cadillac/chevrolet/gmc/pontiac/saturn: there may be an intermittent engine hesitation or flutter. The camshaft sensor terminals likely have poor connections. *rm updated 8/1/11. *pe updated 4/16/12.
• 10043579Jan 1, 2012Engine cooling. Chevrolet/pontiac: while engine is running, the belt squeaks and crankshaft balancer appears wobbly or out of balance.
• 10038294Jan 1, 2012Seat belts. Gm: there are seat belt problems: difficulty latching and unlatching buckle. Buckle release button is sticking. Seat belt warning light illuminated. Likely caused by sticky beverages that are spilled into the buckle assembly. *rm updated 4/3/12.
• 10029924Dec 1, 2011Air bags. General motors: diagnostic information for intermittent restraints, air bag (sir) indicator/lamp on with dtc(s) b0012, b0013, b0016, b0016, b0019, b0020, b0022, b0023, b0026, b0033, b0040, b0042 or b0044 set. This may be caused by a loose, missing, or broken connector position assurance (cpa) retainer at the air bag for the set dtc. Includes trailblazer ext. *pe updated 8/16/10. *pe updated 3/12/12.
• 10037184Oct 1, 2011Seat belts. Gm: service bulletin explaining when the safety belts are supposed to lock. *rm updated 12/6/11.
• 10022693Jun 1, 2011Electronic stability control. Service stability lamp dtc c0131. *nj updated 4/1/08. *nj updated 6/26/08. *nj updated 12/18/08. *pe updated 8/1/11.
• 10036464May 1, 2011Engine cooling. Buick/cadillac/chevrolet/gmc/hummer/pontiac/saab: oil consumption and/or exhaust smoke-possible pcv baffle or lifter concern. Upon inspection, obvious oil will be found in the intake manifold and/or pcv vacuum tube. *pe updated 3/21/11. *pe updated 5/9/11. *pe updated 5/25/11. *pe updated 06/16/2011. *kb updated a second time on 06/16/2011. *kb updated 6/27/11.
• 10038759Apr 1, 2011Electrical system. Gm: onstar is making incomplete calls without the driver knowing. When have a data connection.
• 10038261Feb 1, 2011Engine cooling. Gm: check engine light is on with multiple trouble codes present.
• 10037941Jan 1, 2011Engine cooling. Gm: service engine soon light is on with a misfire and a possible tick noise.
• 10037933Jan 1, 2011Engine cooling. Gm: the service engine soon light is on, there is also a misfire or engine noise. There are multiple possible causes.
• 10037345Nov 1, 2010Fuel system. Gm: there may be a vapor leak at the fuel tank filler cap on some 2008-2009 g8 models.
• 10036324Sep 1, 2010Engine cooling. Pontiac/saturn/buick/gmc/chevrolet/cadillac/hummer: vehicle start and stalls after theft deterrent module replacement. Model years 2006-2011. Does not apply to vehicles with keyless access system.
• 10028264Sep 1, 2010Equipment, Electronic stability control, Electrical system. General motors: during normal diagnostics and/or repair verification the abs light, traction control and/or stabilitrak indicators may be on with no dtc's displayed by the ebcm. *pe updated 11/17/10. *pe updated 3/14/11.
• 10036550Jun 1, 2010Electrical system. Buick/cadillac/chevrolet/gmc/hummer/pontiac/saturn: additional diagnostic information for u0140 or u0073. Vehicle may exhibits some symptom(s) as door locks cycle while driving; intermittent no start; service stabilitrak dic message; speedometer and tachometer freeze while driving.
• 10034368Jan 1, 2010Tires, Wheels, Fuel system, Brakes. Pontiac: shake/vibration in steering wheel, boom/moan noise at highway speeds on smooth roads (replace engine mounts, propshaft, balance wheel and tire assemblies or correct brake rotor runout).
• 10026626Jan 1, 2010Exterior lighting, Electronic stability control, Vehicle speed control. Pontiac: diagnosis: brake lights stay on, cruise control inoperative, stability control off message displayed in dic, dtc c0161 set-perform brake position sensor (pps) calibration using tech 2. Condition may be intermittent. *pe updated 11/1/10.
• 10031444Sep 1, 2009Suspension. Pontiac: front suspension clicking/knocking. Certain vehicles may have a condition in which the sealing boots on the front suspension lower control arm ball joints may not seal correctly in extreme cold temperatures. *pe updated 1/27/10. Csc letter was received.
• 10032388Aug 1, 2009Other or unknown, Brakes. Pontiac: abs/ses/traction control off indicators/messages and or loss of power with the radio turned up.
• 10030607May 1, 2009Electrical system, Air bags. General motors: to provide a service procedure to reprogram the ip cluster on certain g8 and export caprice and lumina vehicles. During vehicle service, if the battery is disconnected and the air bag diagnostic module is subsequently disconnected, and then the battery reconnected without reconnecting the air bag diagnostic module, the supplemental inflatable restraints (sir) may be disabled.
• 10026149Aug 1, 2008Transmission and drivetrain. Gmc: flare and or harsh 2-3 shifts. This condition may be caused by leaking 1-2-3-4 and 3-5-r clutch fluid seal rings (230). Models cadillacs, chevrolets, gmc, hummers, pontiacs. Equipped with 6l80 (rpo myc) or 6l90 (rpo myd) automatic transmission.
• 10026670Jun 1, 2008Electrical system, Equipment. Gmc: rke, ipc/dic, radio, hvac, center stack lighting, onstar, inoperative or no electrical power. Hvac will go into a fixed setting of medium blower and defrost and the hvac controls will be inoperative.

← All problems reported for the 2009 Pontiac G8