2004 Pontiac Grand AM Technical Service Bulletins

387 technical service bulletins (TSBs) are on record for the 2004 Pontiac Grand AM. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10012694Aug 1, 2007Steering. Release of steering gear stub shaft bearing kit for service. *tt updated 08-15-07. *kb updated 10/09/07.
• 10021347Apr 5, 2007Electrical system. Numerous electrical conditions which include windshield wipers, turn signal lamps, air bags, stop lamps, and hazard lamps.
• 10021412Mar 1, 2007Brakes. Incorrect outer backing plate. Outer backing plate has short centre protusion. Outer backing plate should have tall center protrusion.
• 10021074Mar 1, 2007Other or unknown. Parts update - timing chain tensioner design change.
• 10020923Jan 30, 2007Engine cooling. Low oil pressure - inspect oil filter for damage. *kb updated 10/18/07.
• 10020731Sep 1, 2006Steering. Revised tilt steering wheel and column fastener tightening specifications.
• 10019423Mar 15, 2006Transmission and drivetrain. Clutch pedal stays to floor.
• 10019420Mar 15, 2006Engine cooling. Supplement to engine replacement instructions for part number 12607031.
• 10019228Feb 21, 2006Transmission and drivetrain. M86/m94 transmission information to disassemble third fourth and fifth gear.
• 10018915Jan 25, 2006Electrical system. Hesitation on acceleration after internal engine repairs - check injector harness orientation.
• 10017096Oct 24, 2005Transmission and drivetrain. Vehicle will not move in either direction. Transmission may show over full. P90 4t40e 4t45e no movement drive or reverse. Converter may be empty of fluid.
• 10017086Oct 24, 2005Transmission and drivetrain. 4t40e or 4t45e will not shift no diagnostic trouble codes.
• 10017032Oct 21, 2005Engine cooling. Service engine soon (ses) light and severe engine misfire on cylinders 1 and 4 or cylinders 2 and 3. *tt updated 08-15-07.
• 10016520Sep 20, 2005Vehicle speed control. Supplement to 05-06-01-003a - wrong throttle gasket part number.
• 10018156Sep 1, 2005Brakes, Visibility (wipers, defrost, mirrors), Fuel system. Car issues - fix it right the first time (new issues in bold). To include 2006 and 2007 models. Gm. Tech link.
• 10013473Aug 1, 2005Engine cooling. Higher than expected oil consumption blue smoke on acceleration.
• 10014875May 11, 2005Brakes. Tech 2 displays asterisk for the left front wheel speed sensor.
• 10017407May 1, 2005Engine cooling. Vehicle hesitates, no start, lack of power, low fuel pressure.
• 10014985Mar 1, 2005Brakes. Revised brake system specifications.
• 10011819Feb 1, 2005Suspension. Front suspension noise on turns.
• 10013475Jan 1, 2005Engine cooling. Whistle noise on light acceleration.
• 10015768Oct 1, 2004Engine cooling. Engine idle flare when the clutch is depressed. Also low speed engine decel stall when coming to a stop. Gm tech link.
• 10012744Oct 1, 2004Visibility (wipers, defrost, mirrors). Front door power window inoperative.
• 10014346Aug 1, 2004Engine cooling. Oil life system reset procedures - cars.
• 10013147Jul 27, 2004Electrical system. Intermittent or inoperative functions of the windshield wipers, the trunk release, the radio, the turn signal lamps, power mirrors, the airbag lamp, door locks, the stop lamps, hazard lamps, heater and air condition systems, power seat, or a water leak on the driver side of the vehicle with the driver side carpet being wet or water dripping from the park brake release handle area onto the floor.
• 10013189Jul 14, 2004Electrical system. Numerous intermittent or hard failure electrical problems.
• 10012116Jul 1, 2004Transmission and drivetrain. Growl or howl type noise from transmission/engine compartment during light to moderate acceleration from a stop.
• 10012103Jul 1, 2004Engine cooling. New cylinder bore liner replacement procedure. This service bulletin replaces 030601018a.
• 10012093Jul 1, 2004Steering. Momentary reduction of power steering ps assist on initial start up with low ambient temperatures. This service bulletin replaces 030232001a.
• 10012182Jun 1, 2004Suspension. Changes to labor time guide relating to front suspension labor operations components.
• 10012147Jun 1, 2004Exterior lighting. Stop tail lamp inoperative or intermittent and or water in lamp.
• 10012628Apr 1, 2004Body and structure. Water leak in trunk.
• 10013047Mar 25, 2004Body and structure. Water leak in the trunk area.
• 10013045Mar 24, 2004Body and structure. Dirty or marked door panels at delivery.
• 10012980Jan 26, 2004Visibility (wipers, defrost, mirrors). This is a product service message regarding the new part number for the heater blower resistor for customer concern of the heater motor not blowing on one up to all speeds.
• 10011117Jan 1, 2004Engine cooling. Guidelines for cylinder bore liner/piston sleeve replacement on the l4 ecotec engine.
• 10013142Nov 6, 2003Engine cooling. Intermittent stall rough idle engine misfire.

← All problems reported for the 2004 Pontiac Grand AM