2004 Pontiac Grand Prix Recalls
NHTSA lists 7 recall campaigns for the 2004 Pontiac Grand Prix. A recall applies only to vehicles built within the affected range, so check your own VIN at nhtsa.gov/recalls. Repairs for recalls are free at a franchised dealer.
- Engine and engine cooling › Exhaust system › Manifold/header/muffler/tail pipeCovers: Pontiac Grand Prix 1997–2004, Buick Regal 1997–2004, Chevrolet Monte Carlo 1998–2004 +3 more
Reported issue: General Motors LLC (GM) is recalling certain model year 1998-1999 Chevrolet Lumina and Oldsmobile Intrigue, 1997-2004 Buick Regal and Pontiac Grand Prix, 2000-2004 Chevrolet Impala, and 1998-2004 Chevrolet Monte Carlo vehicles. The affected vehicles were previously repaired under recalls 08V-118, 09V-116, and 15V-201 to address the possibility that engine oil may drip onto the hot exhaust manifold.
Possible consequence: Engine oil that drips onto the hot surface of the exhaust manifold may result in a fire.
Remedy: The remedy applied under recalls 08V-118, 09V-116, and 15V-201 did not adequately remove the safety risk. Under the improved remedy, dealers will replace the engines front valve cover and gasket. Vehicles that are covered by recalls 08V-118, 09V-116, or 15V-201 that have not yet received the original remedy will…
- Engine and engine cooling › EngineCovers: Pontiac Grand Prix 2004, Chevrolet Impala 2004, Buick Regal 2004 +1 more
Reported issue: General Motors LLC (GM) notified the agency on April 2, 2015, that they are is recalling certain model year 2004 Buick Regal vehicles manufactured April 9, 2003, to June 1, 2003, 2004 Chevrolet Impala vehicles manufactured April 8, 2003, to June 23, 2003, and 2004 Chevrolet Monte Carlo vehicles manufactured April 7, 2003, to June 23, 2003. On May 18, 2015, GM expanded the recall to cover an additional 49,751 2004…
Possible consequence: The leaking engine oil can drip onto the hot surface of the exhaust manifold, increasing the risk of a fire.
Remedy: GM will notify owners, and dealers will remove the plastic cover and plastic oil fill tube extension and replace the front valve cover and gasket. These repairs will be done free of charge. The recall began on April 24, 2015. Owners may contact Buick customer service at 1-800-521-7300, Pontiac customer service at…
- Electrical system › IgnitionCovers: Pontiac Grand Prix 2004–2008, Chevrolet Malibu 1997–2003, Pontiac Grand AM 1999–2005 +5 more
Reported issue: This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003…
Possible consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
- Vehicle speed control › Accelerator pedalCovers: Pontiac Grand Prix 2004, Cadillac SRX 2004, XLR 2004
Reported issue: Certain passenger vehicles fail to comply with the requirements of federal motor vehicle safety standard no. 124, 'accelerator control systems.' if one of the two accelerator pedal return springs fails and the temperature is -22 degrees f to -40 degrees f, the engine may not return to idle within three seconds, as required.
Possible consequence: If this were to occur, greater brake pedal force and a longer distance may be required to stop the vehicle.
Remedy: Dealers will replace the accelerator pedal assembly. This recall began on march 8, 2005. Owners may contact cadillac at 1-866-982-2339 or pontiac at 1-800-620-7668.
- Service brakes, hydraulicCovers: Pontiac Grand Prix 2004, Chevrolet Impala 2004, Monte Carlo 2004
Reported issue: Certain passenger vehicles were produced with lower than specified torque on both front brake caliper to steering knuckle attachment bolts. With improper torque, the clamp load at the joint may not be adequate to prevent movement between the caliper bracket and knuckle.
Possible consequence: Depending on whether one or both bolts backs out or fractures, the result can be locking of the affected wheel during braking and an abrupt steering input in the direction of the locked wheel, reduced braking and noise from the affected wheel, or severing of a brake hose, increased brake pedal travel, and reduced…
Remedy: Dealers are to tighten both bolts to the specified torque. Owner notification began on june 28, 2004. Owners should contact chevrolet 1-800-630-2438 or pontiac 1-800-620-7668.
- Structure › Frame and membersCovers: Pontiac Grand Prix 2004
Reported issue: Certain passenger vehicles have a condition where the front frame rear body mount bracket may fracture.
Possible consequence: If ignored, the bracket would fracture and degrade to the point where the intermediate steering shaft could separate, resulting in loss of steering control and a crash could occur.
Remedy: Dealers will inspect the front frame assembly and replace it if necessary. The recall began on august 16, 2004. Owners should contact pontiac at 1-800-620-7668.
- Service brakes, hydraulic › Foundation components › Hoses, lines/piping, and fittingsCovers: Pontiac Grand Prix 2004
Reported issue: Certain passenger vehicles fail to comply with the requirements of federal motor vehicle safety standard no. 135, "passenger car braking systems." on some of these vehicles, the right rear brake hose fitting may not be tightened properly, and a brake fluid leak could occur.
Possible consequence: If enough fluid leaks, the brake pedal will be lower than normal, and stopping distances will be longer. If this occurs when stopping distance is limited, a crash could occur.
Remedy: Dealers will tighten the right rear brake hose fitting to the proper torque specification, and add brake fluid if necessary. Owner notification began august 28, 2003. Owners should contact pontiac at 1-800-620-7668.
NHTSA investigations
- DP05010Unstable headlampsClosed · Dec 21, 2005
← All problems reported for the 2004 Pontiac Grand Prix
About this data. Data from NHTSA (ODI) complaints, recalls, TSBs and investigations, updated Oct 31, 2026. Complaints are unverified consumer reports and may be duplicated or inaccurate.