2005 Pontiac Montana Recalls
NHTSA lists 5 recall campaigns for the 2005 Pontiac Montana. A recall applies only to vehicles built within the affected range, so check your own VIN at nhtsa.gov/recalls. Repairs for recalls are free at a franchised dealer.
- Suspension › RearCovers: Pontiac Montana 2005–2008, Buick Terraza 2005–2008, Chevrolet Uplander 2005–2008
Reported issue: The braun corporation has notified nhtsa about a defect in certain model year 2005-2008 general motors mobility conversion, handicapped accessible low floor minivans. During conversion, the driver or passenger side trailing arm modification may not have been adequately welded.
Possible consequence: A squeaking or clunking noise may develop. The trailing arm bushings may prematurely wear and the trailing arm may fracture or separate, allowing the rear axle to become partially separated from the chassis increasing the risk of a crash.
Remedy: Dealers will inspect and will have a supply of retrofit parts available to remedy the vehicles free of charge. The safety recall began on june 4, 2010. Owners may contact braun at 1-800-488-0359.
- Air bags › FrontalCovers: Pontiac Montana 2005, Buick Lacrosse 2005–2006, GMC Envoy 2005–2006 +9 more
Reported issue: Certain vehicles originally built with cloth seats that were equipped with an automatic air bag passenger sensing system and later reupholstered with aftermarket leather seat cover kits are involved. Testing has indicated that the aftermarket leather seat covers can cause the passenger sensing system to malfunction.
Possible consequence: If the passenger sensing system malfunctions, the front air bag on the passenger side may be disabled when it should be enabled, or enabled when it should be disabled. In either case, in the event of a crash that requires air bag deployment, a front passenger's level of injury may be increased.
Remedy: Because a replacement leather seat cover that is compatible with the passenger sensing system is not available, general motors (gm) will repurchase these vehicles in accordance with the terms stated in gm's letter to owners. The recall began on november 6, 2006. Owners should contact gm at 1-877-477-1022 to begin the…
- Parking brakeCovers: Pontiac Montana 2005, Buick Terraza 2005, Saturn Relay 2005 +1 more
Reported issue: Certain sport utility vehicles fail to conform to the requirements of federal motor vehicle safety standard no. 135, 'passenger car brake systems.' to meet the standard, the vehicle must not move for five minutes when stopped on a steep hill with the parking brake applied and the vehicle in neutral (n). Some of these vehicles failed this test.
Possible consequence: When the parking brake is released, the driver may notice unintended braking when accelerating, decelerating, or coasting, and a noise coming from the rear of the vehicle. Unintended vehicle movement could occur increasing the risk of a crash.
Remedy: Dealers will inspect for parking brake lever slippage at each rear brake caliper and replace the caliper if lever slippage is identified. The recall began on november 14, 2005. Owners may contact buick at 1-866-608-8080, chevrolet at 1-800-630-2438, pontiac at 1-800-620-7668, or saturn at 1-800-972-8876.
- Seats › Mid/rear assemblyCovers: Pontiac Montana 2005, Saturn Relay 2005, Chevrolet Uplander 2005
Reported issue: On certain minivans, the outboard release handle on the impact-side second-row bucket seat may be actuated and the rear latches may unlatch early in a side impact crash. This was discovered in a side impact test run by gm, under conditions similar to nhtsa's new car assessment program (ncap) side impact test.
Possible consequence: If the rear latches of the seat release early in a severe side impact, the front outboard latch may disengage and increase the potential for injury to the occupant of the seat.
Remedy: Dealers will remove the seat latch release handle and install a black plastic cap over the exposed metal stud to eliminate the side impact safety concern free of charge. The recall began on april 5, 2005. Owners may contact saturn at 1-800-972-8876, chevrolet at 1-800-630-2438, and pontiac at 1-800-620-7668.
- Latches/locks/linkages › Doors › LatchCovers: Pontiac Montana 1997–2005, Chevrolet Venture 1997–2005, Oldsmobile Silhouette 1997–2004 +1 more
Reported issue: On certain minivans equipped with second-row bucket seats or captain's chairs and a power sliding door on the passenger side of the vehicle, a passenger using the interior handle to open the power sliding door could be injured.
Possible consequence: If a passenger uses the interior handle to open the power sliding door and holds onto the handle while it is being opened by the motor, the passenger's arm may be pushed into the seat back or armrest and a wrist or lower arm injury may result.
Remedy: Dealers will replace the power sliding door interior handle on the passenger-side. If the vehicle is equipped with a power or manual sliding door on the driver-side, the interior handle will also be replaced for appearance reasons. Note: before the vehicle is serviced, gm advises owners to not use the interior door…
← All problems reported for the 2005 Pontiac Montana
About this data. Data from NHTSA (ODI) complaints, recalls, TSBs and investigations, updated Nov 1, 2026. Complaints are unverified consumer reports and may be duplicated or inaccurate.