2015 Porsche Cayenne Technical Service Bulletins

533 technical service bulletins (TSBs) are on record for the 2015 Porsche Cayenne. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10125190Dec 13, 2016Engine cooling. The turbocharger is damaged by detached parts of the cracked inner part of the manifold. A faulty turbocharger is diagnosed due to loss of power and when the "Check Engine" warning is activated. However, a faulty turbocharger can also be diagnosed if the inner part of the manifold is damaged.
• 10120623Nov 18, 2016Electrical system. Due to incorrect sealing of the electric plug connection on the transfer case servo motor, moisture can get into the connector. As a result, the contacts can become corroded. In the event of a customer complaint, check the plug connection on the servo motor and the servo motor itself for damage: ? If the electric plug connection on the transfer case servo motor is corroded, replace section of cable including…
• 10119298Nov 18, 2016Electrical system. Due to incorrect sealing of the electric plug connection on the transfer case servo motor, moisture can get into the connector. As a result, the contacts can become corroded. In the event of a customer complaint, check the plug connection on the servo motor and the servo motor itself for damage: ? If the electric plug connection on the transfer case servo motor is corroded, replace section of cable including…
• 10119334Oct 21, 2016Electrical system. The customer observes a MIL. (Please note: Often, this failure mode is not accompanied by other unwanted behavior.) The technician confirms the MIL and notes P0C4700 is present in the high voltage battery. PCNA is aware of this issue. A bad ground has been found in a number of cases. The service recommendation is to check ground continuity and replace the electric water pump and the electric water pump relay, if…
• 10119330Oct 20, 2016Equipment. Converting transfer cases that are still in stock to the new type before installing themin customer vehicles. The optimized transfer case is used during production from week 31/2016. If the transfer case needs to be replaced, check the part number of the new transfer case. If the transfer case is the old type, it must be converted to the new type before doing any other work. Conversion to the new type involves: ?
• 10122099Sep 26, 2016Engine cooling. Reworking Connector on Engine Coolant Level Sensor for Low-temperature Cooling System (Red "engine coolant level" warning message in the instrument cluster/SY2215)? Contact problems with the installed plug contacts in the connector for the engine coolant level sensor on the coolant reservoir (low-temperature cooling system). ?
• 10122094Sep 20, 2016Electrical system. The rear lid closes at a higher speed particularly at cold temperatures. The signal from the microswitch in the lid lock is too short and cannot be read out clearly by the control unit software.
• 10165170Aug 23, 2016Body and structure. Instructions for installing the Porsche Bicycle Rack on applicable models with an already installed roof transportation system
• 10081247Aug 12, 2016Electrical system. Enabling online services
• 10188295Jul 26, 2016Equipment, Electrical system, Vehicle speed control. Resubmitting at request of Mr. Bernard Hardgrave. Instructions on how to check the cable routing in the front center console area and rework it if necessary in the event that the speedometer needle in the instrument cluster is shaking.
• 10198523Apr 22, 2016Equipment. 1997 to Present - Vehicle Analysis Log Types - In an effort to prode accurate information regarding the state of the vehicle at the time fof VAL creation, a "log type" drop down menu was added at the end of the VAL creation menu.
• 10198540Apr 7, 2016Body and structure. Eliminating Symkptoms in Body Interior: Replacing A Pillar Trim Panel (A-pillar trim panel loose/SY0316)
• 10198538Mar 31, 2016Tires, Wheels, Equipment. Approved Tires, Wheels and Spacers (02/16/)
• 10076058Mar 31, 2016Tires, Wheels. Approved Tires, Wheels and Spacers (02/16) This bulletin contains information about • technically permissible wheel/tyre combinations, • measures that may be required when changing the wheel/tire combination fitted at the factory, • approved original Porsche alloy wheels and • approved summer, all-season and winter tires and their tire pressures
• 10198542Mar 24, 2016Equipment, Brakes. Circlip on bearing bracket for pedals - Checking circlip on bearing bracket for pedals to make sure it is fited correctly. A new circlip may have to be installed.
• 10198525Mar 24, 2016Equipment, Brakes. Understanding and addressing brake squeal complaints.
• 10076060Mar 24, 2016Equipment, Brakes. AG02 Stop Sale Campaign/Recall Campaign - Checking Circlip on Bearing Bracket for Pedals Internal tests have shown that a circlip on the bearing bracket for the pedals may have become detached from its locking position as a result of preassembly processes carried out by a supplier. In this case, the bearing pin for the pedals will no longer be secured axially in the bearing bracket and can come out of one of the…
• 10198516Feb 10, 2016Engine cooling, Electrical system. Red Hybrid Warning in the Instrument Cluster and Temperature Faults in High Voltage Power Electronics POAEE00, POAF300, P0BD200 stored in High Voltage Power Electronics. The coolant hose with the above part number has a built in thermostat which can sometimes stick, causing high temperature faults in the e-Machine.
• 10198515Dec 11, 2015Equipment. The Approval and Support Management Program (ASM)
• 10060324Oct 12, 2015Engine cooling. Porsche: due to incorrect usage there's a possibility that positive crankcase ventilation valves may have a burr on the cover.
• 10060323Oct 8, 2015Equipment. Porsche cayenne (92a) bulletin on replacing cowl drain. If cowl cage will not fasten properly to the body replace it.
• 10060325Oct 5, 2015Equipment. Porsche: when necessary conditions are met the dme control unit and front end electronics aren't switched to sleep mode.
• 10058887Aug 12, 2015Electrical system. Porsche: when driving extensively with a full load, remaining fuel would calculate incorrectly and range would be incorrectly displayed due to incorrect coding rule used in the instrument cluster. Model 2015 cayenne s-e hybrid.
• 10117422Jul 27, 2015Engine cooling, Engine. Concerns: DME control unit Information: This is to inform you of a voluntary Workshop Campaign on the above-mentioned vehicles.
• 10198524Apr 11, 2015Tires, Equipment. 2003 to Present All with tire pressure monitoring system.
• 10117440Apr 7, 2015Electrical system. Concerns: Power supply relays Information: There is a possibility that relays froma batch whose switching contact was not manufactured according to specifications were installed on the affected vehicles. As a result, the switching contact in the relay can stick in normal position and the relevant electrical equipment will not therefore be supplied with current. Depending on where the relay is used in the vehicle…
• 10058303Mar 19, 2015Exterior lighting. Porsche: information provided regarding led control unit, the central headlight control unit and headlights where spare parts, due to hardware fault, are requirements using piwis tester. Model 2015 cayenne.
• 10117407Feb 12, 2015Engine cooling. Concerns: Oil guide housing Information: Oil leak ("sweating", drops of oil) on engine in oil guide housing area We have discovered that the cause of some leaks in the specified area could not be detected and determined definitively in the dealer organisation when attempting to resolve the complaint "Oil leak"1 . As a result, some of the measures that were carried out were not always effective.
• 10117406Feb 2, 2015Suspension. Concerns: Suspension alignment Information: Due to amanufacturing problem, there is a possibility that the wheel alignment on the front and rear axle was not carried out correctly and the threaded connections on all toe, camber and caster threaded joints were not tightened to the specified tightening torque on the affected vehicles.
• 10117438Jan 23, 2015Equipment, Exterior lighting. Information: This is to inform you of a voluntary Workshop Campaign on the above-mentioned vehicles. There is a possibility that the lens on the tail lights was not welded sufficiently on the affected vehicles. As a result, moisture can seep in, causing the lens on the tail light to fog up from the inside. The functions of the tail light are not impaired due to the arrangement of the circuit board and lens in the…
• 10057143Nov 20, 2014Engine cooling. Porsche: cayenne s e-hybrid: software update for the cooling air flaps that will remain closed over 124 mph on selected vehicles.
• 10117495Nov 19, 2014Engine cooling. Concerns: DME control unit Information: This is to inform you of a voluntary Workshop Campaign on the above-mentioned vehicles. With the previous software for controlling the cooling-air flaps for demand-controlled regulation of engine cooling, there is a possibility that the cooling-air flaps will remain closed at speeds of over 124 mph (200 km/h) on the affected vehicles.
• 10117493Nov 19, 2014Engine cooling, Electrical system. Concerns: DME control unit Information: This is to inform you of a voluntary Workshop Campaign on the above-mentioned vehicles. With the previous software for controlling the cooling-air flaps for demand-controlled regulation of engine cooling, there is a possibility that the cooling-air flaps will remain closed at speeds of over 124 mph (200 km/h) on the affected vehicles.

← All problems reported for the 2015 Porsche Cayenne