2014 Ram 2500 Technical Service Bulletins

516 technical service bulletins (TSBs) are on record for the 2014 Ram 2500. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10218244Jun 1, 2016Visibility (wipers, defrost, mirrors), Brakes, Transmission and drivetrain. Power Fold Rearview Mirror Prior to replacing this part for a loose mirror, please first follow this procedure to reset the pivot mechanism. Move the mirror to its full forward position and then to full retract position using the power fold mirror button located on drivers side door panel. Perform this procedure three times.
• 10139934Jun 1, 2016Engine cooling. Pentastar Oil Filter Adapter: Before replacing this part, please call any one of the following people. Engineering is seeking information regarding this part.~ Dye must be used to determine where the leak is coming from before replacing. Also please check the recently updated Service Bulletin Number 09-008-15.
• 10139930Jun 1, 2016Visibility (wipers, defrost, mirrors). Power Fold Rearview Mirror Prior to replacing this part for a loose mirror, please first follow this procedure to reset the pivot mechanism. Move the mirror to its full forward position and then to full retract position using the power fold mirror button located on drivers side door panel. Perform this procedure three times.
• 10228098May 18, 2016Engine cooling. 3.2L - 3.6L Cylinder Head Assy Multiple cylinder head replacement. If cylinder head is replaced on a vehicle more than 1 time for any reason, please call any of the following people.~ First: Ron Dallison ? Cell (248) 292-9510 [email protected] ~ Second: Joe Lovell - Cell (734) 309-6467 [email protected]~ If a response is not received within 15 mins, then proceed with the necessary repair.~
• 10228142May 11, 2016Engine cooling, Equipment. Pentastar Oil Filter Adapter
• 10228112May 7, 2016Exterior lighting, Brakes, Back-over prevention (rear camera), Fuel system…. Flash: 6.7L Diagnostic And System Improvements This bulletin involves reprogramming the Engine Control Module/Powertrain Control Module (ECM/PCM) with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) Illumination. Upon further investigation, a technician may find one or more of the following Diagnostic Trouble Codes (DTCs) set in the PCM memory: · **P218F - Reductant No…
• 10140226May 6, 2016Equipment. You have been identified as either having stock, or have stock in transit to your dealership. As per regulatory compliance: Please return follow ing stock of part numbers: 82214711, 82214712, 82214713, 82214714, 82214715, 82214716, 82214717, 82214718, 82214720, 82214721, 82214722, 82214723, 82214724, 82214725, 82214726, 82214727, 82214728, 82214729, 82214730, 82214731, 82214732. Please return parts back to your…
• 10218303May 4, 2016Electrical system, Equipment. RES / RHA / REB radio that supports Bluetooth and Hands-Free For issues with Bluetooth, Hands-Free Calling, and/or Voice Commands, DO NOT replace the radio. Diagnose the Hands-Free Module system (also called the Telematics Module). The Telematics Module (and associated components) is the system responsible for these features.
• 10140254May 4, 2016Equipment, Electrical system. RES / RHA / REB radio that supports Bluetooth and Hands-Free For issues with Bluetooth, Hands-Free Calling, and/or Voice Commands, DO NOT replace the radio. Diagnose the Hands-Free Module system (also called the Telematics Module). The Telematics Module (and associated components) is the system responsible for these features.
• 10140249May 4, 2016Equipment. You have been identified as either having stock, or have stock in transit to your dealership. Please return all stock of part number 68288760AA. Replacement part number is 68288760AB. Replacement parts w ill be available w eek ending 5/6/16. Please return suspect parts back to your facing depot using Return Code 02, before 26 May, 2016. Return any open orders in process too. Direct all questions via email to…
• 10140248May 3, 2016Equipment. You have been identified as either having stock, or have stock in transit to your dealership. Please return suspect stock of part numbers: 68003062AB, 68003083AB, 68003085AB. See attachments for identifying suspect stock. Please return suspect parts back to your facing depot using Return Code 02, before 24 May, 2016. Return any open orders in process too. Direct all questions via email to [email protected].
• 10140227May 3, 2016Equipment. You have been identified as either having stock, or have stock in transit to your dealership. Please return suspect stock of part numbers: 1PE001W 7AB, 1PE011W 7AB. See attachments for identifying suspect stock. Please return suspect parts back to your facing depot using Return Code 02, before 24 May, 2016. Return any open orders in process too. Direct all questions via email to [email protected].
• 10219794Apr 29, 2016Equipment, Electrical system. RA3 RA4 Radio Enhancements This bulletin involves inspecting and updating the radio software, if required. **Improvements: · Ability to communicate with Siri via UConnect. · Ability to press Voice Recognition (VR) button for more than one second.** A customer may experience one or more of the following conditions: · **Poor or no connection to cellular network (U.S. market only).
• 10138978Apr 29, 2016Equipment, Back-over prevention (rear camera), Electrical system. RA3 RA4 Radio Enhancements This bulletin involves inspecting and updating the radio software, if required. Improvements: · Ability to communicate with Siri via UConnect. · Ability to press Voice Recognition (VR) button for more than one second.** A customer may experience one or more of the following conditions: · Poor or no connection to cellular network (U.S. market only). HVAC temperature out of sync with radio…
• 10076511Apr 29, 2016Electrical system. SUBJECT: RA3 RA4 Radio Enhancements OVERVIEW: This bulletin involves inspecting and updating the radio software, if required. SYMPTOM/CONDITION: **Improvements: · Ability to communicate with Siri via UConnect. · Ability to press Voice Recognition (VR) button for more than one second.**
• 10224659Apr 22, 2016Electrical system. This Bulletin involves updating the (ASCM) software.
• 10139959Apr 22, 2016Suspension. Flash: Air Suspension Control Module (ASCM) System Enhancements This Bulletin involves updating the (ASCM) software. A customer may describe the following: · **Cluster stays awake after ignition is turned off for 10 minutes or more.** · False message Battery Voltage Low - Start Engine to Change Ride Height which appears in the Electronic Vehicle Information Center (EVIC).
• 10076503Apr 22, 2016Electrical system, Suspension. SUBJECT: Flash: Air Suspension Control Module (ASCM) System Enhancements SYMPTOM/CONDITION: A customer may describe the following: · **Cluster stays awake after ignition is turned off for 10 minutes or more.** · False message “Battery Voltage Low - Start Engine to Change Ride Height” which appears in the Electronic Vehicle Information Center (EVIC). This condition may happen when the vehicle is first started and…
• 10076282Apr 22, 2016Suspension, Electrical system. SUBJECT: Flash: Air Suspension Control Module (ASCM) System Enhancements OVERVIEW: This Bulletin involves updating the (ASCM) software. SYMPTOM/CONDITION: A customer may describe the following: • **Cluster stays awake after ignition is turned off for 10 minutes or more.** • False message “Battery Voltage Low - Start Engine to Change Ride Height” which appears in the Electronic Vehicle Information Center (EVIC).
• 10139956Apr 20, 2016Vehicle speed control. Adaptive Cruise Control Sensor 1) If you are replacing this part due to the cluster displaying Clean Radar Sensor in Front of Vehicle or DTC C1266 ACC Sensor Blinded, please verify that there is no blockage in front of the sensor. Blockage can occur from mud, ice, snow, front end damage, bracket damage, the sensor not attached to the bracket properly or an aftermarket fascia installed. This fault can occur…
• 10218068Apr 9, 2016Engine cooling. This bulletin involves replacing the engine assembly.
• 10215102Apr 9, 2016Engine cooling. This bulletin involves replacing the engine assembly.
• 10138953Apr 9, 2016Equipment, Engine cooling. Cummins Service Engine Replacement This bulletin involves replacing the engine assembly. Remanufactured long block or short block was installed during a prior repair. A new replacement engine will be installed.
• 10140211Mar 22, 2016Seats, Latches, locks and linkages. Inspect and Return: Latch Seat, and Latch Seat Back You have been identified as either having stock, or have stock in transit to your dealership. Please return suspect stock of following part numbers: 68050625AA, 68050626AA, 68050627AA, 68050628AA, 68050743AA, 68050744AA, 68050839AA, 68050841AA, 68257133AA, 68257134AA, 68264578AA, 68264579AA, 68264580AA, 68264581AA. See attachments for identifying suspect stock.
• 10142203Mar 15, 2016Electrical system, Equipment. RE2 RE6 RB5 RB6 Radio Software Enhancements This bulletin involves updating the radio software and navigation if equipped. A customer may experience one or more of the following conditions: · Radio display screen will lock up and reset intermittently. · Incorrect routing directions to fuel stations when using Travel Link. · Unable to turn on heated seats; icon is greyed out. · Navigation screen goes blank. ·…
• 10140234Mar 11, 2016Exterior lighting, Electrical system. Flash: 2.4L Powertrain Diagnostic and System Improvements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. A small number of customers may experience a Malfunction Indicator Lamp (MIL) illumination or one or more of the following conditions. Upon further investigation the technician may find the following Diagnostic Trouble Codes (DTCs) set in the PCM…
• 10140228Mar 9, 2016Visibility (wipers, defrost, mirrors). Turn Signal, Outside Rearview Mirror The Turn Signal in the outside rearview mirror has been revised. Ensure it visually matches the Turn Signal on the opposite mirror. If not, both sides will need to be replaced.
• 10139827Mar 9, 2016Visibility (wipers, defrost, mirrors). Auxiliary Lamp, Outside Mirror The Auxiliary Lamp (Puddle Lamp) in the outside rearview mirror has been revised. Ensure it visually matches the Puddle Light on the opposite mirror. If not, both sides will need to be replaced
• 10139826Mar 9, 2016Exterior lighting. Mirror, Outside Rearview Replacement outside rearview mirror assembly comes equipped with Turn Signal and Auxiliary (Puddle) Light. If Turn Signal/Puddle Lamp is visually different from OE, you will need to swap the original lamp to the new mirror unit.
• 10141316Mar 3, 2016Engine cooling, Equipment. Cummins Service Engine Replacement This bulletin involves replacing the engine assembly. Remanufactured long block or short block was installed during a prior repair. A new replacement engine will be installed.
• 10141310Feb 26, 2016Equipment. Bumper Kit If you are ordering a Center Console bumper kit to repair a vehicle for TSB 23-001- 16 or RRT 16-011 and you receive kit PN 68315574AA, discard the instruction sheet shipped with the kit and reference TSB 23-001-16 REV. B for correct bumper installation instructions. ~ Note: This only applies to the AA level of the kit
• 10121927Jan 26, 2016Engine cooling. NAG1 (5A580) Valve Body As per Warranty Bulletin D-13-22, please use R2108213A$ valve body for all Warranty (W), Mopar (M) and Mopar Vehicle Protection (F) claims.~ Assembly also includes Filter (52108325AA) and Gasket (52108332AA).~
• 10119646Jan 20, 2016Equipment. FLOOR CONSOLE ASSEMBLY Please call Mike Wicker on cell (248) 821-9350 regarding Center Floor Console Armrest Lid not latching properly. If you don't receive a response within 20 minutes, then continue with normal repair procedure.~ Please follow this procedure to resolve Center Floor Console noise (e.g.
• 10119653Jan 16, 2016Engine. Engine Mounts Replacement This bulletin involves replacing the right and left engine mounts. The customer may describe a drone/noise or excessive vibration condition when the engine is operating in ECO mode.
• 10160075Dec 23, 2015Transmission and drivetrain. Flash: Powertrain System Improvements/Enhancements This bulletin involves reprogramming the Powertrain Control Module (PCM) with the latest available software. The following powertrain system improvements/enhancements are included in this software release. These enhancements are listed by vehicle application. DS vehicles equipped with a 3.6L engine (sales code ERB).
• 10160059Dec 19, 2015Electrical system. Flash: Incorrect Language Displayed In The Cluster And Odometer Line Disappears This bulletin involves reprogramming the Instrument Panel Cluster (IPC) with updated software. ? Customer may report that the odometer line disappears sometimes and comes back with an ignition cycle or changing cluster screens. ? The customer may notice when trying to switch the language from English to Spanish/French, only the radio…
• 10160041Dec 12, 2015Suspension. Air Suspension Compressor Inoperative This bulletin involves replacing the Air Suspension Compressor Assembly. A small number of customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the Technician may find the following Diagnostic Trouble Code may have been set: ? C1556-14-Ride Height Air Pressure Sensor - Circuit Short To Ground Or Open In addition to the DTC listed…
• 10218012Dec 10, 2015Brakes, Seat belts, Electrical system. Anti Lock Brake (ABS) Module System Enhancements.
• 10215046Dec 10, 2015Brakes. Anti Lock Brake (ABS) Module System Enhancements.
• 10160034Dec 10, 2015Brakes, Electrical system, Electronic stability control. Flash: Anti Lock Brake (ABS) Module System Enhancements This bulletin involves updating the Anit-Lock Brake System (ABS) module software. The customer may describe the Electronic Stability Control (ESC) Warning lamp is illuminated on the instrument cluster. Upon further inspection, the technician may find the following Diagnostic Trouble Code (DTC): C006A-49 - Multi-Axis Acceleration Sensor - Internal Electronic…
• 10160026Dec 5, 2015Transmission and drivetrain. Vibration During Quick Launch While Towing This bulletin involves replacing the rear prop shaft, if required. The customer may describe a vibration feeling during a fast launch from 0 mph (0 kph) to 11 mph (18 kph) and the vehicle hauling a heavy load. This vibration is most noticeable at a launch from a stop, at Wide Open Throttle (WOT) while towing a heavy trailer.
• 10218070Dec 1, 2015Suspension, Electronic stability control. This bulletin involves replacing the Air Suspension Compressor Assembly.
• 10215104Dec 1, 2015Electronic stability control, Equipment, Suspension. This bulletin involves replacing the Air Suspension Compressor Assembly.
• 10159962Nov 26, 2015Engine cooling, Equipment. P20EE SCR NOX Catalyst Efficiency Below Threshold Bank 1 This bulletin involves verifying the proper operation of the Diesel Exhaust Fluid (DEF) system and, if necessary, replacing the Selective Catalyst Reduction (SCR) Catalyst assembly. Customers may experience a Malfunction Indicator Lamp (MIL) illumination.
• 10159935Nov 13, 2015Equipment, Electrical system. RA1 Radio Enhancements This bulletin involves updating the software on the RA1 Radio. A customer may experience, one or more of the following conditions: ? Radio may reset, turn itself off and then back on again. All Symptom Listed Below Are For 2013 Vehicles Only: ? Radio may be muted.
• 10218060Nov 11, 2015Electrical system. This bulletin involves configuring the Body Control Module (BCM).
• 10215094Nov 11, 2015Equipment, Electrical system, Body and structure. This bulletin involves configuring the Body Control Module (BCM).
• 10159925Nov 11, 2015Electrical system. LED Lamp Configuration Update This bulletin involves configuring the Body Control Module (BCM). The customer may describe LED Turn Signals do not properly display.
• 10159918Nov 7, 2015Transmission and drivetrain, Engine cooling, Electrical system. Flash: 6.7L Diagnostic And System Improvements This bulletin involves reprogramming the Engine Control Module/Powertrain Control Module (ECM/PCM) with the latest available software. A small number of customers may experience a Malfunction Indicator Lamp (MIL) Illumination. Upon further investigation, a technician may find one or more of the following Diagnostic Trouble Codes (DTCs) set in the PCM memory: ?
• 10218058Nov 5, 2015Electrical system. This bulletin involves reprogramming the Vehicle System Interface Module (VSIM) with the

← All problems reported for the 2014 Ram 2500