2022 Ram 2500 Technical Service Bulletins

541 technical service bulletins (TSBs) are on record for the 2022 Ram 2500. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10223811Jul 27, 2022Electrical system, Equipment. Flash: Display Screen Module (DSM) Updates This bulletin involves reprogramming the DSM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find that the following Diagnostic Trouble Code (DTC) has been set: B22A9 - ECU Internal Performance. Customers may also comment on the following:Black radio screen with…
• 10223782Jul 27, 2022Engine cooling. Malfunction Indicator Lamp (MIL) Illumination. Diagnostic Trouble Code (DTC) P0471 ? Exhaust Pressure Sensor 1 Performance, Set.
• 10230307Jul 19, 2022Equipment. Audio Cuts Out When Volume Level is At 30 or Above
• 10223771Jul 19, 2022Equipment. Audio Cuts Out When Volume Level is At 30 or Above
• 10230293Jul 1, 2022Engine cooling. Malfunction Indicator Lamp (MIL), Service Air Filter Message Illuminated. Diagnostic Trouble Code (DTC) P227F ? Air Flow Restriction ? Air Leak Between Air Filter and MAF, Set.
• 10223757Jul 1, 2022Electrical system. Malfunction Indicator Lamp (MIL), Service Air Filter Message Illuminated. Diagnostic Trouble Code (DTC) P227F ? Air Flow Restriction ? Air Leak Between Air Filter and MAF, Set.
• 10221380Jun 29, 2022Other or unknown, Electrical system. CONNECTOR/WIRING, Trailer Tow If the connector or wiring is physically damaged, burned, melted or corroded, prior to replacing the part, please contact FCA Redacted Content If no response in 15 minutes, proceed with repair. Please send pictures of the failed part to FCA Redacted Content
• 10221378Jun 29, 2022Equipment. DOOR, Storage Bin (Rambox Lid) If the Rambox storage bin Lid (Door) is being replaced for the Lid loose or warped issue, replace the complete Rambox Bin and Lid assembly with all of the sub components instead of just replacing the Lid only. Please ship the complete Rambox Bin and Lid assembly without dis-assembling the lid or hinges to QEC. Please contact FCA Redacted Content to set up the part return to QEC. If no…
• 10221505Jun 25, 2022Electrical system, Back-over prevention (rear camera), Exterior lighting. Flash: Display Screen Module (DSM) Updates This bulletin involves reprogramming the DSM with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technicianmay find that the following Diagnostic Trouble Code (DTC) has been set: B22A9 - ECU Internal Performance. Customers may also comment on the following:Black radio screen with audio…
• 10221503Jun 24, 2022Back-over prevention (rear camera), Air bags. UPD UFD UBD UED UBC UEC Radio Enhancements This bulletin involves inspecting the software level and updating the software if needed. The software will be updated to 141.01.12.00. Customers may experience one or more of the following:Phone notification volume pops up while switching between driver profiles. Media widget gets "blacked out" on SXM? after switching user profiles. In light theme mode and in balance/fade…
• 10221496Jun 22, 2022Equipment. Amplifier (AMP) Drone Noise This bulletin involves replacing the amplifier. Customers may experience the following: Audible drone after initial start up or during idle.
• 10221432Jun 17, 2022Brakes, Engine cooling. REV. A - Oil Pressure And Or Coolant Temp Readouts Are Not Shown In The Off Road Application
• 10221427Jun 15, 2022Equipment. : Wireless Charging Pad Slow Wireless Charging, No Wireless Charging
• 10221482Jun 10, 2022Back-over prevention (rear camera). Radio Over The Air Software Version Updates This bulletin provides information regarding the latest Flash Over The Air (FOTA) update and provides the service technician an overview of the steps a customer will need to take to complete the update. The radio software will be updated from S23.13 to S24.13The national launch for the FOTA is expected to begin June 11, 2022. Customers may experience one or more of the…
• 10221423Jun 10, 2022Equipment. An incorrect PDF document S228A000004 Rev. A - Panasonic VP4R Wi-Fi New Enrollment Pause was uploaded for this communication during publishing and was corrected with S228A000009 Rev. A
• 10221416Jun 9, 2022Air bags, Seats, Exterior lighting, Vehicle speed control. Tailgate Ajar Indicator Light Is On And Or High Effort Required To Close And Latch The Tailgate
• 10221476Jun 8, 2022Air bags, Back-over prevention (rear camera). UPD UFD UBD UED UBC UEC Radio Enhancements This bulletin involves inspecting the software level and updating the software if needed. The software will be updated to 141.01.12.00. Customers may experience one or more of the following: Phone notification volume pops up while switching between driver profiles. Media widget gets "blacked out" on SXM? after switching user profiles. In light theme mode and in…
• 10221414Jun 7, 2022Vehicle speed control, Brakes. Upper Glove Box Door Does Not Open When Button Is Pressed
• 10221412Jun 4, 2022Equipment. SXM Loss of Meta Data and Audio Intermittently
• 10221411Jun 4, 2022Engine cooling, Brakes. Oil Pressure And Or Coolant Temp Readouts Are Not Shown In The Off Road Application
• 10221402Jun 2, 2022Electrical system. Hill Descent Control Inoperative, No LED Function On Switch After Sales Code Was Added
• 10221401Jun 2, 2022Back-over prevention (rear camera). Radio Screen Changes Modes Without Input
• 10221399Jun 2, 2022Brakes, Transmission and drivetrain, Exterior lighting. Malfunction Indicator Lamp (MIL) Illumination. Diagnostic Trouble Codes (DTCs) P0765 ? UD Solenoid Circuit, P0871 ? Transmission Fluid Pressure Sensor/Switch ?C? Circuit Performance, and/or P0755 ? 2C Solenoid Circuit, Set.
• 10221398Jun 2, 2022Engine cooling. Malfunction Indicator Lamp (MIL) Illumination, Diagnostic Trouble Code (DTC) P026B ? Injection Timing Performance, Set.
• 10221381Jun 1, 2022Visibility (wipers, defrost, mirrors). Control - hvac control
• 10214580May 25, 2022Equipment, Seats. Rear Seat Back Trim Cover Loose J-Clip Retainer
• 10214533May 25, 2022Equipment, Visibility (wipers, defrost, mirrors). Rain Sensor Before replacing the rain sensor during a front windshield replacement, contact: FCA Redacted Content If no response in 15 minutes, proceed with repair. If there is no visible damage to the original rain sensor it should be transfered to the new windshield using a new gel pad rather than replacing it.
• 10214577May 21, 2022Equipment. Uconnect Box Error Message On Radio Screen And DTC code B22A9-96 Set
• 10214576May 21, 2022Equipment, Electrical system. Uconnect Box Error Message, With Active or Stored Cellular Antenna Open or Short DTC B1560-11, B1560-13, B1561-11 or B1561-13
• 10214572May 18, 2022Equipment, Electrical system. Uconnect Box Error Message, With Active or Stored Cellular Antenna Open or Short DTC B1560-11, B1560-13, B1561-11 or B1561-13
• 10214528May 18, 2022Equipment, Electrical system. INSTRUMENT PANEL, Base Panel (Top Pad, Leather) If you are replacing a leather instrument panel top pad for any leather defects (bubbling, delamination, wrinkling, etc.), please contact FCA Redacted Content. If no response in 15 minutes, proceed with repair. Please send pictures of the leather defect to FCA Redacted Content.
• 10214527May 18, 2022Electrical system, Other or unknown. CONNECTOR/WIRING, Trailer Tow If the connector or wiring is physically damaged, burned, melted or corroded, prior to replacing the part, please contact FCA Redacted Content If no response in 15 minutes, proceed with repair. Please send pictures of the failed part to FCA Redacted Content
• 10214566May 13, 2022Equipment. Blank Radio Display Screen
• 10214599May 10, 2022Transmission and drivetrain, Engine cooling, Electrical system. Flash: Powertrain Control Module (PCM) Updates This bulletin involves reprogramming the Engine Control Module/Powertrain Control Module (ECM/PCM) with the latest available software. Customers may experience a Malfunction Indicator Lamp (MIL) illumination. Upon further investigation the technician may find that one or more of the following Diagnostic Trouble Codes (DTCs) have been set: P0401-00 - EGR System…
• 10214522May 4, 2022Suspension, Wheels. RECEIVER, Hub The final drop shipment of CSN Z23, P/N 68379519AL, has taken place. No further parts distribution will be taking place. All distributed parts would cover all sold and unsold needs. Please use all stock that your dealer has before asking for parts assistance. If part assistance is still required, please provide the following information to your Area Manager for review: 1. Dealer Code 2. Last eight…
• 10214519May 4, 2022Brakes. CALIPER ASSEMBLY, Disc Brake, Front/Rear For brake feel/sensation concerns, please call engineering FCA Redacted Content before performing repairs. If no response in 15 minutes, proceed with repair.
• 10228016Apr 30, 2022Other or unknown, Seats, Electrical system. Left Front Driver Seat Power Functions Inoperative
• 10227978Apr 28, 2022Body and structure. Latch - front door
• 10228077Apr 26, 2022Equipment. UPD UFD UBD UED UBC UEC Radio Enhancements
• 10227977Apr 22, 2022Suspension. RECEIVER - HUB
• 10227976Apr 22, 2022Steering. Damper - steering
• 10227975Apr 21, 2022Exterior lighting. LAMP - TAIL
• 10227974Apr 13, 2022Steering. Damper - steering
• 10227994Apr 8, 2022Equipment. Wireless Android Auto Or Apple CarPlay Intermittent Operation From Interference
• 10227993Apr 8, 2022Electrical system. Audible Drone Noise After Initial Start Up Or During Idle
• 10227961Apr 6, 2022Engine cooling, Fuel system. DRIVE, Fan If a heavy duty diesel vehicle comes in with reports of loud fan noise or fan always on, please call FCA Redacted Content. If no response within 15 minutes, proceed with repair
• 10227983Apr 2, 2022Engine cooling, Equipment. If a Mopar oil filter is not available, use a filter that meets or exceeds USCAR36 specification and is compatible with semi and full synthetic oils.
• 10229095Mar 30, 2022Equipment. Warranty Bulletin D-20-13-13 STAR Center Uconnect 5 (R1) Radio Pre-Authorization Program ? Select Radios (New and Exchange) ?2021 - 2022 Jeep Grand Cherokee (WL), 2022 Wagoneer and Grand Wagoneer (WS), 2022 Ram 1500 Pickup (DS/DT) and 2022 Ram Heavy Duty Pickup (DD/DF/DJ/ DP/D2) (Rev. D)
• 10223133Mar 30, 2022Equipment. Warranty Bulletin D-20-13-13 STAR Center Uconnect 5 (R1) Radio Pre-Authorization Program ? Select Radios (New and Exchange) ?2021 - 2022 Jeep Grand Cherokee (WL), 2022 Wagoneer and Grand Wagoneer (WS), 2022 Ram 1500 Pickup (DS/DT) and 2022 Ram Heavy Duty Pickup (DD/DF/DJ/ DP/D2) (Rev. D)
• 10220751Mar 30, 2022Equipment. Warranty Bulletin D-20-13-13 STAR Center Uconnect 5 (R1) Radio Pre-Authorization Program ? Select Radios (New and Exchange) ?2021 - 2022 Jeep Grand Cherokee (WL), 2022 Wagoneer and Grand Wagoneer (WS), 2022 Ram 1500 Pickup (DS/DT) and 2022 Ram Heavy Duty Pickup (DD/DF/DJ/ DP/D2) (Rev. D)

← All problems reported for the 2022 Ram 2500