2000 Saab 9-5 Recalls
NHTSA lists 3 recall campaigns for the 2000 Saab 9-5. A recall applies only to vehicles built within the affected range, so check your own VIN at nhtsa.gov/recalls. Repairs for recalls are free at a franchised dealer.
- Electrical system › Ignition › ModuleCovers: Saab 9-5 2000–2002, 9-3 2000–2002
Reported issue: Certain passenger vehicles equipped with b205/b235 4-cylinder gasoline engines and b308 6-cylinder gasoline engines may experience overheating and burnout of the isolated gated bipolar transistor (igbt) within the ignition discharge module (idm) due to increased susceptibility to electrical loads.
Possible consequence: Overheating of the igbt occurs most often at engine start-up, but it may also occur while the engine is running. Engine stalling may occur, which could result in a crash.
Remedy: Dealers will inspect to see what version idm is in the vehicle and replace the idm if it is a version built prior to the introduction of qp3. An interim letter will be mailed to owners in october 2005, informing them of the condition. Parts are now available and owners will be notified to bring their vehicles in to…
- Wheels › HubCovers: Saab 9-5 1999–2003
Reported issue: On certain passenger vehicles, if an owner changes their wheels/tires between summer and winter using a steel wheel in the winter and an alloy wheel in the summer, it is possible for rust and contamination to build up on the wheel hub during the steel wheel usage. If this occurs and the contamination is not removed, it is possible that after the tire change service, some of this contamination could flake or grind…
Possible consequence: These fractures would result in wheel bolt breakage, allowing the wheel to detach from the wheel hub, increasing the risk of a crash.
Remedy: Owners will be contacted by mail and asked whether they change between steel and alloy wheels. If they do engage in this practice, they will be instructed to bring their cars to an authorized dealer. The dealer will remove the wheels, clean any contamination from the wheel and wheel hub, and replace the wheels using…
- Air bagsCovers: Saab 9-5 2000–2001, 9-3 2000–2001
Reported issue: Vehicle description: certain passenger vehicles fail to comply with requirements of fmvss no. 208, "occupant crash protection." the air bag alert labels may not be permanently affixed as required by this standard.
Possible consequence: These vehicles do not comply with the requirements.
Remedy: Dealers will clean the sunvisor surface and apply a new air bag alert label on both sunvisors. Owner notification began july 30, 2001. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact saab at 1-800-955-9007.
← All problems reported for the 2000 Saab 9-5
About this data. Data from NHTSA (ODI) complaints, recalls, TSBs and investigations, updated Oct 28, 2026. Complaints are unverified consumer reports and may be duplicated or inaccurate.