2007 Saturn Outlook Technical Service Bulletins

979 technical service bulletins (TSBs) are on record for the 2007 Saturn Outlook. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10140363Jul 11, 2014Equipment. This information bulletin provides the dealers on how to submit a product information report.
• 10138578Jul 11, 2014Equipment. This information bulletin provides the dealers on how to submit a product information report.
• 10137828Jul 11, 2014Equipment. This information bulletin provides the dealers on how to submit a product information report.
• 10140353Jul 1, 2014Equipment. This information for Warranty administration - Changes the Service Policy and Procedures Section 1.6.2.11 and list the requirements for the dealer to comply.
• 10137818Jul 1, 2014Equipment. This information for Warranty administration - Changes the Service Policy and Procedures Section 1.6.2.11 and list the requirements for the dealer to comply.
• 10248444Jun 30, 2014Equipment. Vehicle Recalls
• 10126308Jun 26, 2014Suspension. This informational bulletin was created to aid the technician in diagnosing the difference between a shock or strut that has a fluid residule from a possible external source from a leaking shaft seal.
• 10126301Jun 24, 2014Equipment. This preliminary bulletin explains to the technician to use the vin when reprogramming the radio using the techline/service programming systems.
• 10126291Jun 18, 2014Visibility (wipers, defrost, mirrors). This preliminary bulletin provides a procedure on how to reset the power folding mirriors after they been folded manually, to fix the customers concern of the mirriors shaking or fluttering at normal driving speeds.
• 10126285Jun 16, 2014Equipment. This preliminary bulletin provides procedures on how to reset or refresh the XM radio receiver is the customers states that they only get a few channels.
• 10125956Jun 16, 2014Equipment. This Preliminary Information communication provides information to the technician about vehicles that may not receiving all channels on the XM band. Technician will need to use a scan tool and verify current Digital Radio Receiver Status under Data Display. Technician will need to look at the second line labeled Digital Radio Receiver Status will display a number of 00 - 04. Technician will repair per the status…
• 10125953Jun 16, 2014Equipment. This Preliminary Information communication provides information to the technician on the programming and activation of the OnStar system. For many 2008 and prior model year GM vehicles, the programming is performed using the Tech 2 and the activation is initiated by a Service Programming System.
• 10126280Jun 13, 2014Equipment. This preliminary bulletin provides a information to the dealer for the requirements need for equipment.
• 10126278Jun 12, 2014Equipment. This informational bulletin provides the dealer with information on what to do when requesting a new key code for the customer.
• 10126275Jun 5, 2014Equipment. This information bulletin provides dealers with more information on how to better prep a vehicle for pre-delivery.
• 10125933Jun 3, 2014Transmission and drivetrain. This Preliminary Information communication provides information to the technician about vehicle that have a Malfunction Indicator Lamp on. Technician may find Diagnostic Trouble Codes P0601, P0603, P0604, P062F or P1621 stored in the Transmission Control Module. Technician will need to ensure that the Diagnostic Trouble Codes are set in the Transmission Control Module. If the Diagnostic Trouble Codes are only set…
• 10137937May 30, 2014Tires. This informational bulletin provides explanation on using the tire sealent in the GM kit as a temporary fix only untill the tire can be properly repaired under the new tire warranty.
• 10137932May 28, 2014Electrical system, Equipment. This warranty bulletin explains how to use the EL-50313 Midtronic GR8 Battery tester to test a battery and determin if it is warranty or not.
• 10137928May 22, 2014Equipment, Tires. This informational bulletin explains a normal condition of new tires may shake and vibrate for the first few miles.
• 10137927May 22, 2014Equipment, Tires. This informational bulletin provides the technician with information on tire radial force variations and how to balance a tire using the balancer.
• 10137919May 19, 2014Equipment. This informational bulletin helps the technician quick reference repairs to bulletins as opposed to replacing parts that may be un necessary.
• 10112074May 19, 2014Brakes. This Preliminary Information communication provides information to the technician on how to diagnose and repair vehicles that may have the Antilock Braking System, Service Traction Control System, and/or Service Stabilitrak lights are on. The Electronic Brake Control Module may have one or more of the following Diagnostic Trouble Codes C0035-C0050 with specifically symptom 18, 5A, or 0F. Technician will gain access…
• 10137914May 16, 2014Equipment. This informational bulletin provides tips on how to care for the interior of the vehicle using products.
• 10137901May 9, 2014Fuel system. This informational bulletin provides the technician with information on what E85 fuel may due to a non E85 vehicle.
• 10137892May 2, 2014Suspension. This technical bulletin provides a procedure to add greese to the jounce bumper on the front struts to correct the customers concern of creaking or squawking from front end on turns.
• 10246913May 1, 2014Back-over prevention (rear camera), Wheels. EBCM Wheel Speed Sensor Diagnostic Aid for ABS Message
• 10246624May 1, 2014Equipment. Car and Truck Fix it Right the First Time Issues
• 10038468May 1, 2014Brakes. Gm: the brake, traction, or stability lights are on because of debris stuck on the wheel speed sensor. Updated on 06/15/2011. *kb updated on 06/20/2011. *rm updated 6/27/11. *pe updated 10/3/11. *pe updated 05/08/2013 *js updated on 7/9/2013. *kb updated 7/28/14.
• 10135234Apr 30, 2014Visibility (wipers, defrost, mirrors), Electrical system. This technical bulletin provides a procedure to seal the plenum, windshield, and inspect the sunroof drain to repair the Floor Wet Under Carpet/Engine Continues to Run with Key Off/Possible No Crank/No Start/Communication Loss/Various Electrical Concerns.
• 10135219Apr 22, 2014Exterior lighting. This informational bulletin explains condensation in exterior lights and replacment guidelines for warranty replacement.
• 10135218Apr 22, 2014Equipment. This informational bulletin is to assist with the identification of issues that are not considered warrantable.
• 10111815Apr 21, 2014Engine. This Preliminary Information communication provides information to the technician about vehicles that have a ticking noise on cold start after sitting more than 6 hours. Technician will inspect the oil pump pick-up tube to block seal being compressed. It the seal is compressed replace the seal and retest.
• 10111811Apr 18, 2014Electrical system, Equipment. This Preliminary Information communication provides information to the technician about vehicles that have an OnStar system that will not power up. Technician should turn off the ignition and cancel retained accessory power. After the vehicle has powered down remove power to the OnStar module for five minutes. After the power has been removed for five minutes, if the OnStar system is working release the vehicle.
• 10111810Apr 17, 2014Equipment. This Preliminary Information communication provides information to the technician about installing General Motors Accessory pats. Technician can check Service Information for some accessories. Technician can also contact Partect for assistance. Technician can also contact Techline Customer Support Center for programming issues.
• 10135207Apr 15, 2014Engine cooling. This preliminary bulletin provides a procedure to repair the PCV system to correct the customers the customers concern of poor engine performance, Ice in throttle body and MIL on.
• 10135201Apr 14, 2014Equipment. This information bulletin provides the technician with additional information on fixing the vehicle right the first time by listing possible concerns to specific vehicles.
• 10253630Apr 1, 2014Engine cooling. Malfunction Indicator Lamp.
• 10250013Apr 1, 2014Electrical system. High Voltage Safety ? High Voltage Disabling
• 10055422Apr 1, 2014Engine. Gm: some dtc codes may be set, p0016, p0017, p0018, p0019, p0008, or p0009. 3.6 ly7 with cam actuator dtc.the reluctor for the crankshaft sensor pressed on the crankshaft may have moved. Also included buick allure model year 2005.
• 10044850Apr 1, 2014Engine. General motors: malfunction indicator lamp (mil) on, poor acceleration, throttle body freezing, multiple dtcs set. Ice deposits and/or oil deposits present in air inlet duct. *js updated 9/19/12. *pe updated 12/5/12. *pe updated 05/03/2013 *js updated 09/30/2013 *js updated 7/28/14.
• 10137887Mar 28, 2014Electrical system. This warranty bulletin explains how to use the EL-50313 Midtronic GR8 Battery tester to test a battery and determin if it is warranty or not
• 10111886Mar 28, 2014Electrical system. This Preliminary Information communication provides information to the technician that Diagnostic Trouble Codes P0016, P0017, P0018, P0019, P0008 or P0009 may be set. Technician will need to inspect for loose timing chains or tensioners. If after following Service Information diagnostics the root cause is not found inspect the reluctor for the crankshaft sensor. If the reluctor has moved then replace crankshaft.
• 10137866Mar 17, 2014Equipment. This informational bulletin helps the technician quick reference repairs to bulletins as opposed to replacing parts that may be un necessary.
• 10111850Mar 5, 2014Equipment. This Preliminary Information communication provides information to the technician about vehicles that when a Canadian customer may comment that when they travel to the United States, they are unable to connect to OnStar or use hands free calling. Dealer can advise the customer that the existing cell phone provider not having roaming agreements in areas outside of Canada.
• 10111849Mar 5, 2014Electrical system, Equipment. This Preliminary Information communication provides information to the technician about vehicles that have a frequent "off route" messages while following Turn by Turn route. Technicians will need to remove power from the Vehicle Communication Interface Module for one hour and retest for the concern.
• 10111846Mar 4, 2014Electrical system. This Preliminary Information communication provides information to the technician about a customer?s request to install OnStar Bluetooth. Dealer should be advised at this time, there are no provisions to add this option to vehicles that were not built with it.
• 10111845Mar 4, 2014Equipment, Electrical system. This Preliminary Information communication provides information to the technician on how to diagnose and repair vehicles that may have an OnStar Turn-By-Turn Navigation the system that is inoperative. Technician verifies there are no Diagnostic Trouble Codes are present in the Antilock Braking System and Vehicle Communication Interface Module of the vehicle. If no Diagnostic Trouble Codes found call OnStar using…
• 10247681Mar 1, 2014Equipment. Information On Requests To Add OnStar Bluetooth Option.
• 10245950Mar 1, 2014Equipment. Canadian Customers Unable To Place Calls In The United States
• 10111966Feb 26, 2014Electrical system. This Preliminary Information communication provides information to the technician about vehicles that have an OnStar system that will not power up. Technician should turn off the ignition and cancel retained accessory power. After the vehicle has powered down, remove power to the OnStar module for five minutes. After the power has been removed for five minutes, if the OnStar system is working release the vehicle.

← All problems reported for the 2007 Saturn Outlook