2017 Subaru BRZ Technical Service Bulletins

199 technical service bulletins (TSBs) are on record for the 2017 Subaru BRZ. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10163525Jul 11, 2019Brakes. This Service Information bulletin announces instruction for application of additional lubrication between the brake caliper support and pad clips. This will prevent the pad from dragging due to corrosion buildup which may result in uneven or premature wear of the replacement brake pads. This additional instruction applies to all models with brake pads using the upper and lower pad clips and has been added to the…
• 10163017Jun 27, 2019Engine. This Service Information bulletin provides new inspection and repair procedures for AVCS (Active Valve Control System) -related DTCs on the FA and FB engine equipped models listed above. The applicable Service Manuals will be revised with this new information in the near future.
• 10163006Jun 13, 2019Body and structure. This bulletin announces availability of a new retaining plate and installation method to address gapping conditions which may develop between the front bumper cover and fender.
• 10161824May 21, 2019Equipment. Subaru Service and Technical Support Line Newletter.
• 10161823May 20, 2019Fuel system, Equipment. This bulletin provides an additional service procedure for replacing the pulsation dampers located on both low-pressure fuel delivery pipes as shown in the illustration below. Although the BRZ Service Manual does not currently show the dampers and the required replacement seals as separate components, the Electronic Parts Catalog (EPC) does provide exploded view and individual part number ordering information.
• 10161813May 6, 2019Equipment. To help reduce confusion and increase technician efficiency, Subaru of America, Inc. (SOA) has developed the following cross reference list to help locate the appropriate Special Service Tool.
• 10160214Apr 23, 2019Electrical system, Engine. This bulletin announces part information for new Active Valve Control System (AVCS) oil control solenoid valves (OCV) which contain a redesigned internal oil seal. The new seal will eliminate potential oil seepage into the wire harness connector portion of the valve. If oil seeps into the connector, over time, the Check Engine lamp may illuminate and set various AVCS-related DTCs.
• 10160490Mar 8, 2019Engine cooling, Equipment. This Service Information bulletin provides new inspection and repair procedures for AVCS (Active Valve Control System) -related DTCs on the FA and FB engine equipped models listed above. The applicable Service Manuals will be revised with this new information in the near future.
• 10155225Feb 22, 2019Equipment. This Service Information bulletin announces a design change made to the rubber timing hole access plug to improve its retention and prevent water intrusion into the converter case.
• 10154426Jan 31, 2019Equipment. This bulletin announces manufacturing process changes made to address small number of cases where the cover (outer skin) of the visor above the combination meter and / or the center panel in the area just above the audio unit has begun to peel. The peeling condition can result from extended periods of exposure to sunlight and the related temperature variations.
• 10154424Jan 31, 2019Equipment, Engine. The purpose of this bulletin is to clarify the proper installation direction of the valve springs used on the FA engine. The springs have a light blue paint mark identifier as shown in the chart below.
• 10154419Jan 25, 2019Brakes. This Service Information bulletin announces instruction for application of additional lubrication between the brake caliper support and pad clips. This will prevent the pad from dragging due to corrosion buildup which may result in uneven or premature wear of the replacement brake pads. This additional instruction applies to all models with brake pads using the upper and lower pad clips and has been added to the…
• 10154207Jan 10, 2019Equipment, Air bags. This Bulletin provides information regarding Event Data Recorder (EDR) functionality which has been incorporated into the airbag system.
• 10153614Dec 10, 2018Engine, Fuel system. This bulletin provides a procedure to address customer concerns of a high-pitched ?chirp?, ?squeak? or ?cricket? sound heard coming from the engine?s Direct Injection (DI) high-pressure fuel pump. Not all DI pumps may exhibit this sound. Some vehicles may have components which in combination with certain fuel temperatures and / or formulations, may result in aeration of the fuel within the body of the pump and…
• 10153613Dec 10, 2018Electrical system, Fuel system. This bulletin announces reprogramming file availability to optimize the ECM. These new files prevent an incorrect diagnosis of DTC P119F: AIR FUEL RATIO IMBALANCE FOR DIRECT INJECTION (BANK 1 FLUCTUATION ENGINE SPEED) and DTC P219A: AIR FUEL RATIO IMBALANCE (BANK 1).
• 10153209Nov 16, 2018Engine, Fuel system. This bulletin provides a procedure to address customer concerns of a high-pitched ?chirp?, ?squeak? or ?cricket? sound heard coming from the engine?s Direct Injection (DI) high-pressure fuel pump. Not all DI pumps may exhibit this sound. Some vehicles may have components which in combination with certain fuel temperatures and / or formulations, may result in aeration of the fuel within the body of the pump and…
• 10153187Nov 14, 2018Engine. This Service Information Bulletin announces design changes to the engine?s knock sensor which will help improve vehicle assembly line efficiency and increase durability. In some cases, the Check Engine light may illuminate and a knock sensor-related DTC set in the ECM memory: P0327, P0328, P0332 and P0333. The knock sensor for DIT engines is now utilized for NA engines to improve durability and resistance to heat.
• 10150937Oct 12, 2018Electrical system, Equipment. This bulletin announces reprogramming file availability and the software installation procedure to address a group of operational concerns received from the field and listed below involving the Clarion Display Audio unit with 6.2? display.
• 10150912Oct 12, 2018Electrical system. This bulletin announces reprogramming file availability and the software installation procedure to address a group of operational concerns received from the field and listed below involving the Clarion Display Audio unit with 6.2? display.
• 10150932Oct 9, 2018Latches, locks and linkages, Body and structure. This bulletin provides a service procedure to address a gap between the top edge of the door and the instrument panel on the models listed as shown in the photo below. The gap may also make the glove box door difficult to close fully.There is a latch to keep the glove box closed on both sides of the glove box door. If the door is closed without using enough force to engage both latches or by pushing it shut on just…
• 10150887Oct 9, 2018Electrical system, Body and structure. This bulletin provides a service procedure to address a gap between the top edge of the door and the instrument panel on the models listed as shown in the photo below. The gap may also make the glove box door difficult to close fully.There is a latch to keep the glove box closed on both sides of the glove box door. If the door is closed without using enough force to engage both latches or by pushing it shut on just…
• 10146480Sep 18, 2018Exterior lighting. This Service Information bulletin provides a measurement and adjustment procedure for the stop lamp switch. An improperly adjusted (or faulty) stop lamp switch can cause any of the DTCs listed above to set and result in the related system?s warning lamp to illuminate.
• 10145074Aug 24, 2018Body and structure. This bulletin announces a design change made to the rear bumper cover (face). To insure a proper fit of the new cover, the rear edge portion of the existing inner mud guards (splash shields) will need to be modified slightly in specific areas. In addition, plastic arch caps (plugs) are inserted into unused holes in the rear wheel arch lip of the new cover to fill unused mounting holes for optional accessory mud…
• 10144882Aug 21, 2018Equipment. This bulletin contains illustrations of exchange components and their manufacturer as well as a description of the proper exchange procedure. Within the terms of the Basic New Car Warranty and the one year Replacement Parts Warranty, the Exchange Program provides for replacement of a defective unit from the manufacturer.
• 10143872Jul 31, 2018Suspension. This bulletin announces a change made to the front lower control arm ball joint boots. The boot material has been changed to provide increased resistance to damage from ozone.
• 10141487May 30, 2018Engine cooling, Equipment. This Service Information bulletin announces a change to the flywheel (pilot) bearing to a ?environmentally friendly? type which is compliant with the REACH (Registration, Evaluation, Authorization and restriction of CHemicals) guidelines being used in the European Union (EU). This change is not intended to address any specific customer concern.
• 10133529Mar 2, 2018Equipment. The purpose of this bulletin is to provide a description of current changes to Service Manuals available via the Subaru Technical Information System (STIS) web site. The tables contained within this bulletin are to be used as guides for becoming aware of the latest changes.
• 10140485Feb 13, 2018Body and structure, Equipment. This bulletin announces a design change to the air vent grille located in the lower portion of the trunk (or cargo) area. The shutters of the vent grille are designed to open briefly and relieve cabin pressure when the doors are shut with the windows fully closed. The vent grilles have rubber ?shutters? which occasionally, may catch on the frame (case) portion and not close properly allowing outside air / odor to…
• 10140470Feb 13, 2018Equipment, Body and structure. This bulletin announces a design change to the air vent grille located in the lower portion of the trunk (or cargo) area. The shutters of the vent grille are designed to open briefly and relieve cabin pressure when the doors are shut with the windows fully closed. The vent grilles have rubber ?shutters? which occasionally, may catch on the frame (case) portion and not close properly allowing outside air / odor to…
• 10130270Jan 24, 2018Brakes, Exterior lighting. This Service Information bulletin provides a measurement and adjustment procedure for the stop lamp switch. An improperly adjusted (or faulty) stop lamp switch can cause any of the DTCs listed above to set and result in the related system?s warning lamp to illuminate.
• 10130277Jan 11, 2018Body and structure. ( 2017-2018MY Impreza - 5 Dr Only)
• 10138778Dec 15, 2017Air bags, Electrical system, Equipment. NOTE: The Airbag systems used on previous and current WRX, STI and Tribeca models are NOT equipped with EDR functionality. This Bulletin provides information regarding Event Data Recorder (EDR) functionality which has been incorporated into the airbag system. The function of the EDR is best explained using the following statements found in the vehicle Owner?s Manual: ?This vehicle is equipped with an event data…
• 10131632Sep 11, 2017Engine cooling. This bulletin announces part information for new Active Valve Control System (AVCS) oil control solenoid valves (OCV) which contain a redesigned internal oil seal. The new seal will eliminate potential oil seepage into the wire harness connector portion of the valve. If oil seeps into the connector, over time, the Check Engine lamp may illuminate and set various AVCS-related DTCs.
• 10117528Jun 26, 2017Engine cooling. This bulletin outlines design changes made to the upper oil pan assembly on FA and FB engines used on the models listed above. There have been isolated cases where the sealer used between the upper oil pan and the crankcase has become displaced resulting in engine oil seepage. Revisions made to the upper oil pan casting: * The mating flange thickness of the casting in the area identified as the cause for the…
• 10111085Apr 25, 2017Electrical system. ONLY 2016-2017MY: Those Models equipped with STARLINK Telematics. Provisioning is the process by which the DCM receives the subscription request and activates the related DCM features requested as outlined in the specific subscription contract. If provisioning is not successful then the DCM may remain in an inactive state and the requested services may not be activated for the customer. Field investigation has…
• 10111082Mar 2, 2017Equipment. This bulletin contains illustrations of exchange components and their manufacturer as well as a description of the proper exchange procedure. The exchange program policy can also be found in Sections 8.4.9 and 11.2.10 of your Claims Policies and Procedures Manual found in Subarunet. CONTENTS Within the terms of the Basic New Car Warranty and the one year Replacement Parts Warranty, the Exchange Program provides for…
• 10120997Nov 16, 2016Equipment. The purpose of this bulletin is to provide replacement key and immobilizer information along with an overview of the Subaru Lock Information web-site.
• 10120983Oct 27, 2016Equipment. This bulletin contains illustrations of exchange components and their manufacturer as well as a description of the proper exchange procedure. The exchange program policy can also be found in Sections 8.4.9 and 11.2.10 of your Claims Policies and Procedures Manual found in Subarunet.
• 10120984Oct 26, 2016Equipment. This Service Information bulletin provides notice of an additional step to follow when diagnosing DTC P219A- ?Air-Fuel Ratio Imbalance (Bank 1)?.
• 10131647Sep 30, 2016Equipment. The purpose of this bulletin is to provide replacement key and immobilizer information along with an overview of the Subaru Lock Information web-site.
• 10182596Aug 26, 2016Equipment. Various paint manufacturers designate their own stock numbers and coding information although many of the major suppliers are now using the SOA paint codes to help eliminate possible confusion. Their color formulations are updated on a continual basis. Some vendors may have different color names than those provided to them by SOA. Be sure to double-check the codes and formulas beforehand to help insure an accurate…
• 10182589Aug 12, 2016Equipment, Engine. This Service Information bulletin provides new inspection and repair procedures for AVCS (Active Valve Control System) -related DTCs on the FA and FB engine equipped models listed above. The applicable Service Manuals will be revised with this new information in the near future.
• 10139508May 18, 2016Equipment. This bulletin provides information to help diagnose and address different conditions relating to customer concerns which may arise when operating the new-generation ?Gen 2? and ?Gen 2.1? F10 Navigation and Display Audio systems.
• 10232535Jul 17, 2014Electrical system. Replacement Key and Immobilizer Info
• 10234841May 20, 2014Equipment, Air bags, Other or unknown. Event Data Recorder (EDR) Function of Airbag Module
• 10232894Mar 7, 2014Engine cooling. Effective with all 2015 model year cars and forward, the oil change interval is changing to 6,000 miles or 6 months, whichever comes first.
• 10233119Apr 25, 2013Engine cooling. Oil Filler Cap Gasket Coming Unseated
• 10233435Mar 18, 2013Air bags. Event Data Recorder (EDR) Function of Airbag Module
• 10232869Feb 19, 2013Equipment, Other or unknown. Puddle Light Recall

← All problems reported for the 2017 Subaru BRZ