2016 Subaru Forester Technical Service Bulletins

455 technical service bulletins (TSBs) are on record for the 2016 Subaru Forester. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10182589Aug 12, 2016Equipment, Engine. This Service Information bulletin provides new inspection and repair procedures for AVCS (Active Valve Control System) -related DTCs on the FA and FB engine equipped models listed above. The applicable Service Manuals will be revised with this new information in the near future.
• 10182588Aug 12, 2016Electrical system, Equipment. This bulletin provides a procedure for diagnosis and repair of DTC P0300 which may result from fluctuation of the alternator?s current output outside of the specified limits.
• 10111097Jul 22, 2016Electrical system, Transmission and drivetrain, Engine. This bulletin announces the availability of reprogramming files to optimize the ECM. These files will address customer concerns of a slight surging / decrease in engine power condition between approx. 2000-2500 RPM on light acceleration during high ambient temperatures (intake air temperatures exceeding 104 deg. F).
• 10111095Jul 20, 2016Body and structure. This bulletin provides potential source locations and procedures to help isolate areas of the vehicle which may be generating popping, clicking or creaking sounds when the body is in a "twisting" condition. This can occur while driving on rough, irregular or uneven road surfaces or even during lowspeed maneuvers such as pulling into or backing out of a driveway.
• 10111092Jul 13, 2016Equipment, Electrical system. TSB: Only those models equipped with Starlink Telematics. Data Communication Module (DCM) Procedures for Provisioning Failure, Inspection / Repair. VERY IMPORTANT: This procedure applies to vehicles with VINs shared with your retailer as leads through the STARLINK Notifications Dashboard found on Subarunet (see example below) which indicate a possible concern with the activation status of the SUBARU STARLINK Safety…
• 10111091Jul 11, 2016Transmission and drivetrain. TSB: All Models Equipped with CVT Transmissions. This Service Information bulletin provides a new flow chart and additional diagnostic tools to assist Technicians with troubleshooting DTC P0841- SECONDARY OIL PRESSURE SENSOR PERFORMANCE.
• 10111103Jul 8, 2016Electrical system, Equipment. This bulletin announces reprogramming file availability and the software installation procedure to address a group of operational concerns received from the field listed below involving "Gen 2" F10 Navigation and Display Audio units with 7" display. The procedure will involve downloading the applicable software update files from Subarunet then loading them onto a flash drive for audio unit installation. It is…
• 10120977Jun 24, 2016Exterior lighting, Brakes. (ALL EXCEPT Hybrid Models) REVISED This bulletin announces a design change to the brake light switch (BLS) to reduce the possibility of improper illumination of the ABS and/or VDC warning lamp. In the event a product containing silicone is used to lubricate the BLS or for other purposes in the area around the switch, a non-conductive coating may develop over time on the internal electrical contacts and affect…
• 10120981Jun 22, 2016Electrical system, Equipment. Revised TSB: This bulletin announces reprogramming file availability and the software installation procedure to address a group of operational concerns received from the field listed below involving ?Gen 2? F10 Navigation and Display Audio units with 7? display. The procedure will involve downloading the applicable software update files from Subarunet then loading them onto a flash drive for audio unit installation.
• 10120975Jun 14, 2016Engine cooling, Transmission and drivetrain, Electrical system. This bulletin announces the availability of a new Air Conditioning compressor / clutch assembly to address customer concerns of the system not operating. Electrical windings located inside the clutch assembly have been changed to eliminate the condition. The service procedure will involve replacement of the A/C compressor and clutch as a complete assembly.
• 10139521May 24, 2016Equipment. Models with Fujitsu-TEN / FTEN / (F10) Gen2 Navigation System only. Fujitsu-TEN / FTEN / (F10) Navigation: Voice Recognition Concerns with Finding Addresses in Some Metro Areas.
• 10139508May 18, 2016Equipment. This bulletin provides information to help diagnose and address different conditions relating to customer concerns which may arise when operating the new-generation ?Gen 2? and ?Gen 2.1? F10 Navigation and Display Audio systems.
• 10139476May 5, 2016Equipment, Electrical system. This bulletin announces reprogramming file availability and the software installation procedure to address a group of operational concerns received from the field and listed below involving the Clarion Display Audio unit with 6.2? display. The procedure will involve downloading the applicable software update files from Subarunet then loading them onto a flash drive for audio unit installation.
• 10139447May 2, 2016Equipment. This bulletin announces reprogramming file availability and the software installation procedure to address a group of operational concerns received from the field listed below involving ?Gen 2? F10 Navigation and Display Audio units with 7? display. The procedure will involve downloading the applicable software update files from Subarunet then loading them onto a flash drive for audio unit installation. It is…
• 10139470Apr 29, 2016Engine cooling. Dated 4/29/2016 although posted on 5/2/2016. 2.0L DI Turbo models only. This bulletin announces the availability of reprogramming files to optimize the ECM. These files will address customer concerns of a slight surging / decrease in engine power condition on light acceleration during high ambient temperatures.
• 10140511Apr 28, 2016Electrical system, Equipment. This Service Information bulletin provides IMPORTANT information regarding diagnosis and replacement (when applicable) of the STARLINK Telematics Data Communication Module (DCM) along with a new claim submission requirement.
• 10140529Apr 27, 2016Equipment. Reminder: Only those vehicles with Telematics. On Friday, April 15, 2016, a letter will be sent out to a select group of customers regarding their current SUBARU STARLINK subscription. The letter will inform the customer that their services may not be active. In an effort to provide a resolution for these customers, SOA is recommending they bring their vehicle to a Retailer for inspection and repair.
• 10140532Apr 26, 2016Equipment. When ordering exchange units from Fujitsu Ten through their online web site, some new information will soon be requested and in some cases required. To assist with that, a new Bluetooth Interview Form is available to facilitate the completion of an exchange order. The form is available on Subarunet at Service Operations & Technical >> Forms.
• 10140510Apr 25, 2016Equipment, Electrical system. Although Fujitsu TEN (F10) Navigation units utilize an externally (faceplate) accessible MicroSD memory card, the MicroSD card used in Clarion display audio units is internal and not accessible. In the event a ?Check SD Memory Card? alert message appears on the faceplate display, an exchange display audio unit must be ordered through the applicable Clarion audio exchange procedure.
• 10140509Apr 25, 2016Equipment. Only those vehicles with Telematics. Provisioning is the process by which the DCM receives the subscription request and activates the related DCM features requested as outlined in the specific subscription contract. If provisioning is not successful then the DCM may remain in an inactive state and the requested services may not be activated for the customer. Field investigation has found that this may be a result…
• 10140503Apr 18, 2016Equipment, Seats. This Service Information bulletin provides a procedure for diagnosis of Occupant Detection System (ODS) DTC B1760 / Sensor Mat Abnormal. This information replaces the current procedure until the Service Manual is updated in the near future. DTC B1760 may set if liquid inadvertently spilled onto the seat cushion (or rain water entering from a window left open) penetrates the upholstery and reaches the sensor mat…
• 10140528Apr 15, 2016Equipment, Electrical system. Only those vehicles with Telematics. On Friday, April 15, 2016, a letter will be sent out to a select group of customers regarding their current SUBARU STARLINK subscription. The letter will inform the customer that their services may not be active. In an effort to provide a resolution for these customers, SOA is recommending they bring their vehicle to a Retailer for inspection and repair.
• 10140504Apr 14, 2016Equipment, Electrical system. This bulletin announces the availability of a new Air Conditioning compressor / clutch assembly to address customer concerns of the system not operating. Electrical windings located inside the clutch assembly have been changed to eliminate the condition. The service procedure will involve replacement of the A/C compressor and clutch as a complete assembly.
• 10140502Apr 12, 2016Suspension. This bulletin announces a design change to the front strut mounts intended to address customer concerns of a popping-type sound which may be heard when making low speed turns.
• 10140499Apr 12, 2016Equipment. Revised TSB. The Subaru Lock Information Site (SLIS) is located at http://lockinfo.subaru.com, and provides information on how to obtain immobilizer codes and key cut codes for Subaru vehicles from the 2000MY to present. This bulletin identifies the equipment required to initialize (reset) the immobilizer code and cut the key blanks, for both immobilizer and non-immobilizer type keys.
• 10140524Apr 11, 2016Equipment. When ordering exchange units from Fujitsu Ten through their online web site, some new information will soon be requested and in some cases required. Exchange order entry will now request a date and time when condition was last duplicated. The customer?s phone carrier, phone make and model will be required when Bluetooth or Connectivity failure sections are selected.
• 10140525Apr 4, 2016Engine cooling, Equipment. Subaru Safety Recall Campaign/ STOP SALE: WTA?62 Turbo Engine Air Intake Duct. The turbocharger air intake duct on affected vehicles may have been produced with incorrect material that is susceptible to cracking.
• 10140498Apr 4, 2016Engine cooling, Equipment. Turbo models only. Service Procedure Bulletin. The repair procedure will involve inspecting and possibly replacing the turbocharger air intake duct. Inspection of the turbocharger air intake duct lot number (date) molded on the duct will be necessary to determine if replacement is required.
• 10140497Apr 4, 2016Equipment, Engine cooling. Turbo models only. Subject: Update ? Subaru Safety Recall Campaign/ STOP SALE: WTA?62 Turbo Engine Air Intake Duct. Owner Notification: All potentially affected vehicle owners will be notified by first class mail on or around April 15, 2016. As previously announced on March 17, 2016, Subaru of America, Inc. (Subaru) is recalling certain 2015 and 2016 model year Forester 2.0XT and WRX vehicles due to a possible…
• 10140495Apr 1, 2016Equipment. Revised TSB. Models with "Gen 2" F10 Audio/Navigation Systems. ?Gen 2? & ?Gen 2.1? Operating Tips. This bulletin provides information to help diagnose and address different s relating to customer concerns which may arise when operating the new-generation ?Gen 2? F10 Audio / Navigation system.
• 10084125Feb 5, 2016Fuel system. This service information bulletin serves as a reminder to always follow the proper procedures when diagnosis of a dtc b1500 leads to replacement of a faulty main and / or sub fuel level sensor.
• 10234286Feb 1, 2016Equipment. This is the final PDF for the 2016 January TechTIPS, please use and distribute as needed.
• 10084297Jan 14, 2016Equipment. Technical support guide - gen 2.0 & 2.1 micro sd navigation (avn) display audio (da)
• 10094362Dec 16, 2015Equipment. This service information bulletin announces a new requirement regarding one-time use parts which must replaced whenever disconnecting or replacing the prg rod. The spring steel retaining clips (stop rings) which lock the prg rod to the ball studs (pivot points) on either end are now one-time use items and must be replaced whenever they are removed. If the stop rings are not replaced, the rod may come off the ball…
• 10094342Dec 14, 2015Body and structure, Visibility (wipers, defrost, mirrors). Should you receive a customer concern of vibration or looseness in either of the door mirrors, a design change has been made to the 3 mirror head mounting holes in the mounting base. In addition, a new retaining bolt and tightening torque specification are now used to secure the mirror head to the mounting base. This bulletin provides a procedure for repairing the existing mirror assembly by replacing the three…
• 10094228Dec 7, 2015Electrical system. This service information bulletin provides a procedure to follow for initial diagnosis of the eyesight system. When receiving a customer concern of a problem, e.g., an indicator lamp illuminates or a warning message appears on the information display, it is important to understand the cancel code information which will be displayed after connecting the select monitor (ssm).
• 10093914Nov 25, 2015Equipment. This service information bulletin provides precautions to use when removing the hvac control panel to prevent damaging the blower fan speed switch. When removing the control panel, if the fan speed switch wiring harness is pulled taught or becomes stressed, the switch may be damaged. If the connector (lower) portion of the switch becomes separated from the switch body even slightly (see fig. 1 on page 2), the hvac…
• 10093861Nov 4, 2015Transmission and drivetrain. This bulletin provides a procedure for diagnosing a customer concern of a delayed and / or harsh engagement of the cvt (model tr580) when shifting into reverse or drive from neutral. All 2013-16my, 4-cylinder, n/a models with cvt
• 10093622Oct 2, 2015Equipment, Electrical system. This service information bulletin provides a procedure for resetting the lifetime fuel consumption function of the mfd. Whenever replacing the mfd and / or combination meter, the lifetime fuel consumption function of the mfd must be reset for accurate information to display going forward. If not reset, erroneous values (either extremely high in the case of a mfd replacement or extremely low for a combination meter…
• 10197411Oct 1, 2015Equipment. Tehnical Suppurt Guide Gen 2.0 & 2.1 Micro SD Navigation (AVN) Gen 2.0 & 2.1 Display Audio (DA)
• 10093129Sep 28, 2015Transmission and drivetrain. Subaru of america, inc. Has extended the availability of remanufactured cvt transmissions to include crosstrek, forester and impreza applications. Please check applications and availability through normal parts channels prior to making vehicle repairs. Retailers are required to use a remanufactured unit for all repairs reimbursed by subaru that require a major repair or replacement, except in the case of a “new”…
• 10093105Sep 11, 2015Equipment. "this service information bulletin announces a design change to the oil pressure switch assembly. Nickel plating has been applied to the internal switch contacts to enhance their durability and reduce the possibility of poor contact which could affect operation or cause improper illumination of the oil pressure warning lamp. A small pilot portion was added to the threaded area on p.n. 25240ka051 as shown in the…
• 10093067Sep 10, 2015Engine. "this service information bulletin announces a design change to the oil pressure switch assembly. Nickel plating has been applied to the internal switch contacts to enhance their durability and reduce the possibility of poor contact which could affect operation or cause improper illumination of the oil pressure warning lamp. A small pilot portion was added to the threaded area on p.n. 25240ka051 as shown in the…
• 10092010Jul 28, 2015Equipment. The 2016 my forester service manual (located in the service diagnostics section of stis) requires internet explorer (ie) 11 or higher. All sds notebooks are currently running internet explorer 8 and will be upgraded to internet explorer 11 by early fall 2015. This is the only service manual that requires internet explorer 11 at this time. All other service manuals will work with internet explorer 8.
• 10232535Jul 17, 2014Electrical system. Replacement Key and Immobilizer Info
• 10232507Jun 16, 2014Equipment. Diagnosis and Repair for AVCS-Related DTCs
• 10234841May 20, 2014Equipment, Air bags, Other or unknown. Event Data Recorder (EDR) Function of Airbag Module
• 10232894Mar 7, 2014Engine cooling. Effective with all 2015 model year cars and forward, the oil change interval is changing to 6,000 miles or 6 months, whichever comes first.
• 10234829Jan 15, 2014Fuel system. Repair Procedure for High-Pitched Sound from Extension Housing Area Using Latest Generation Production Parts
• 10234828May 22, 2013Transmission and drivetrain. This Bulletin provides production change, repair procedure and parts information to address a customer concern of a high-pitched sound coming from the transmission extension housing area.

← All problems reported for the 2016 Subaru Forester