2013 Volkswagen Beetle Convertible Technical Service Bulletins

1,037 technical service bulletins (TSBs) are on record for the 2013 Volkswagen Beetle Convertible. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10120243Jul 29, 2014Fuel system. 2009-2015 Model Year Volkswagen TDI® Clean Diesel Vehicles Registered in Minnesota Engine Codes CBEA, CJAA, CKRA, CATA, CNRB Using Biodiesel Blend Fuels: Biodiesel is a domestically produced, clean-burning and renewable partial substitute for conventional (petroleum) diesel fuel. The customers vehicle was originally designed to run on ?ULSD? - Ultra Low Sulfur Diesel No. 2 ? fuel that complies with ASTM D-975…
• 10120239Jul 29, 2014Electrical system. Technical Bulletin (Update Programming ECM to Correct Engine Load Calculations): Current ECM programing does not efficiently control engine valve timing causing stumbling and rough idle. This document discusses the "Fault Codes" necessary to diagnosis, and potential remedy of the issue. The fault codes for checking warranty coverage for servicing the vehicle are also available.
• 10239842Jul 28, 2014Transmission and drivetrain. Slave Cylinder - Clutch Pedal Operation Diagnosis
• 10120233Jul 28, 2014Transmission and drivetrain. Technical Bulletin (Slave Cylinder - Clutch Pedal Operation Diagnosis): Customer may comment: ? Complaints on clutch system. ? After pressing the clutch pedal, it remains on the floor. Due to mis-diagnosis of clutch systems, and to prevent incorrect parts replacement, diagnostic procedure implemented into guided fault finding (GFF). This document is for identifying the issue for diagnosis.
• 10243032Jul 21, 2014Equipment. VW Elsa Newsletter
• 10242370Jul 21, 2014Electrical system, Fuel system, Other or unknown, Equipment, Engine. VW Elsa Newsletter
• 10238619Jul 18, 2014Wheels, Suspension. This can be the due to the Encoder Ring being ground down on the wheel bearing hub unit, resulting in a damaged part.
• 10120208Jul 18, 2014Brakes. Tech Tips (ABS/TPMS light is on due to wheel speed sensor fault as a result of the Front Wheel Bearing / Wheel Speed Sensor swapping issue): This document informs of the Damage caused from swapping the speed sensors left to right (or vice versa) during diagnosis.
• 10241317Jul 15, 2014Engine cooling. MIL ON, Cylinder Contribution/Balance Faults Stored in ECM Fault Memory P0263, P0266, P0269 and/or P0272
• 10120241Jul 15, 2014Electrical system. Technical Bulletin (Cylinder Contribution / Balance Fault issues): The Diagnostic strategy for zero fuel calibration is too sensitive. The production solution for this issue was new software being implemented into production. This document discusses the "Fault Codes" necessary to diagnosis, and potential remedy of the issue. The fault codes for checking warranty coverage for servicing the vehicle are also available.
• 10239837Jul 11, 2014Engine cooling. MIL ON - Glow Plug Pressure Sensor Faults Stored in ECM Fault Memory
• 10120234Jul 11, 2014Electrical system. Technical Bulletin (Glow Plug Pressure Sensor Faults): When diagnosing MIL ON with glow plug pressure sensor DTC?s it important to perform diagnosis prior to replacing the glow plug. This document informs on the procedure to service this issue. This document discusses the "Fault Codes" necessary to diagnosis, and potential remedy of the issue. The fault codes for checking warranty coverage for servicing the vehicle…
• 10250695Jul 10, 2014Fuel system. Carefree Maintenance Coverage for Interim Oil Changes for Certain 2009 ? 2015 MY Volkswagen TDI® Clean Diesel Engine Vehicles Registered in the State of Minnesota Only (US Dealers
• 10239233Jul 10, 2014Fuel system. Because Volkswagen supports the development and use of renewable fuels (such as biodiesel fuel blends), customers with certain 2009-2015 MY Volkswagen TDI® Clean Diesel Engine vehicles registered in the State of Minnesota only will receive a communication in July 2014 regarding the use of biodiesel fuel blends in their vehicles.
• 10120244Jul 10, 2014Fuel system. Upcoming Communication to Owners of 2009-2015 MY Volkswagen TDI Clean Diesel Engine Vehicles Registered in the State of Minnesota Engine Codes CBEA, CJAA, CKRA, CATA, CNRB Using Biodiesel Fuel Blends: This document informs that Due to new Minnesota state regulations regarding biofuels, biodiesel blends of B5 or less may not be available in the State of Minnesota.
• 10238600Jul 4, 2014Transmission and drivetrain. Incorrect torque converter or flywheel/flexplate installation can result in transmission damage. When installing an engine, flywheel or transmission, please follow the installation procedures outlined in ELSA. For the flywheel/flexplate, please be certain the correct shim is installed between it and the crankshaft (reference VWIQ120). When installing a torque converter, press the torque converter hub through the…
• 10120207Jul 4, 2014Transmission and drivetrain. Tech Tips (Torque Converter/Flywheel/Flexplate installation): Incorrect torque converter or flywheel/flexplate installation can result in transmission damage. When installing an engine, flywheel or transmission, please follow the installation procedures outlined in ELSA. This document also contains advice on the installation of these devices
• 10238026Jul 3, 2014Brakes. Brake Disc Pulsation or Vibration (U.S. Only)
• 10238025Jul 3, 2014Brakes. Vibration or noise when braking may be due to brake disc corrosion protection which has not been completely removed by normal braking or surface rust built up during transportation.
• 10120231Jul 3, 2014Brakes, Suspension. Technical Bulletin (Vibration or Noise When Braking): Vibration or noise when braking may be due to brake disc corrosion protection which has not been completely removed by normal braking or surface rust built up during transportation. This document discusses the "Fault Codes" necessary to diagnosis, and potential remedy of the issue. The fault codes for checking warranty coverage for servicing the vehicle are also…
• 10120230Jul 3, 2014Suspension. Technical Bulletin (Brake Disc Pulsation or Vibration): When applying brakes at highway speeds the following symptoms may occur: ? Brake pedal pulsation ? Vibration felt in vehicle body ? Steering wheel shakes For brake vibration or pulsation concerns, brake disc machining is allowed between 6 and 12 months or 6,000 and 12,000 miles (whichever comes first) from the warranty in service date. This document discusses…
• 10241268Jul 2, 2014Equipment. PDI - Vehicle Inspection, Protection Removal and Detailing
• 10120213Jul 2, 2014Equipment. Technical Bulletin (PDI - Vehicle Inspection, Protection Removal and Detailing): This document informs on the service a vehicle shouold received when it has successfully reached a dealership. ? Inspecting vehicle for damage (to be completed within 48 hours of delivery to Dealership) ? Shipping damage ? Detailers responsibilities (to be completed prior to delivery to Customer) ? Full Body Covers (FBC), removal and…
• 10243004Jun 9, 2014Tires, Electrical system, Equipment, Interior lighting, Steering, Exterior…. VW Elsa Newsletter
• 10242342Jun 9, 2014Equipment. VW Elsa Newsletter
• 10252938Jun 6, 2014Interior lighting. Interior Light Assembly Rattle Noise
• 10238972Jun 6, 2014Tires, Wheels. The use of tire dressing gives your tires that shiny finish that completes the image of a clean (new) vehicle. There are many different tire dressing products available. When choosing a product please pay close attention to its contents. Always use a water based product.
• 10237762Jun 6, 2014Equipment, Interior lighting. For concerns of rattle noise from the interior light assembly, the issue can be corrected with self-adhesive felt from the squeak and rattle kit or by using part number 533-863-288-A (Felt Strip) from ETKA. Cut the felt strip to 5mm x 30mm and place it in the left rear corner of the interior light assembly housing, see figure 1 below. For best results use felt strip that is 1.5mm ? 3mm thick.
• 10120158Jun 6, 2014Interior lighting. Tech Tips (Interior Light Assembly Rattle Noise Issue): For concerns of rattle noise from the interior light assembly, the issue can be corrected with self-adhesive felt from the squeak and rattle kit or by using part number 533-863-288-A (Felt Strip) from ETKA. This document informs of the procedure to service the rattle noise issue
• 10120155Jun 6, 2014Wheels, Tires. Tech Tips (All vehicles-Tire dressing for vehicle detailing): The use of tire dressing gives your tires that shiny finish that completes the image of a clean (new) vehicle. This document informs that The use of non-water based products will increase the risk of causing damage to painted surfaces. The document also gives graphical examples of the dame that can occur if non-water based products are used.
• 10253215Jun 4, 2014Exterior lighting, Other or unknown. Exterior Lights, Moisture Accumulation
• 10239592Jun 4, 2014Exterior lighting. Exterior Lights, Moisture Accumulation
• 10120169Jun 4, 2014Exterior lighting, Equipment. Technical Bulletin (Exterior Lights, Moisture Accumulation): This document informs of the Condensation and or water droplets visible on inside of exterior light lenses. The document also informs how to service the issue.
• 10243003Jun 2, 2014Electrical system, Engine cooling. VW Elsa Newsletter
• 10253207May 30, 2014Other or unknown, Electrical system. Washer Level Sensor
• 10239584May 30, 2014Visibility (wipers, defrost, mirrors). Washer Level Sensor
• 10124402May 30, 2014Equipment. Technical Bulletin (Washer Level Sensor): The issue is caused by the outside influence of non-approved formulated washer fluids. Non-approved washer fluids leave a clear film coating on the sensor probes, insulating the probes so they cannot read the fluid level. This This document informs Validate the washer reservoir is full with the proper washer solvent. Refer to Elsa for proper fluid type and fluid quantities…
• 10239391May 28, 2014Engine cooling, Transmission and drivetrain. For an upcoming campaign that will include all MY09-14 TDI (CBEA/CJAA) vehicles, we need to test the SVM3339 code in 200 vehicles of various model-years and engine/transmission combinations.
• 10243009May 5, 2014Steering, Electrical system, Visibility (wipers, defrost, mirrors), Engine…. VW Elsa Newsletter
• 10242347May 5, 2014Steering, Electrical system, Equipment, Engine cooling. VW Elsa Newsletter
• 10252941May 2, 2014Visibility (wipers, defrost, mirrors). Washer Level Sensor
• 10252922May 2, 2014Visibility (wipers, defrost, mirrors). Washer Level Sensor
• 10237765May 2, 2014Visibility (wipers, defrost, mirrors). The indicator lamp in the I.P. for washer fluid remains illuminated and the washer reservoir is full. Validate the washer reservoir is full with the proper washer solvent (G-052-164). Refer to Elsa for proper fluid type and fluid quantities under repair manual, maintenance, fluid capacity table. If the fluid is not blue in color, drain the fluid, remove the sensor and clean with cleaner (D-009-401-04) or equivalent.
• 10237746May 2, 2014Visibility (wipers, defrost, mirrors). The indicator lamp in the I.P. for washer fluid remains illuminated and the washer reservoir is full. Validate the washer reservoir is full with the proper washer solvent (G-052-164). Refer to Elsa for proper fluid type and fluid quantities under repair manual, maintenance, fluid capacity table. If the fluid is not blue in color, drain the fluid, remove the sensor and clean with cleaner (D-009-401-04) or equivalent.
• 10124408May 2, 2014Visibility (wipers, defrost, mirrors). Tech Tips (Washer Level Sensor issues): This document discusses approved windshield washer fluids and the damages non - approved fluids can cause. The document also informs on the procedure to Validate the washer reservoir is full with the proper washer solvent
• 10124407May 2, 2014Visibility (wipers, defrost, mirrors). Washer Level Sensor issues: The indicator lamp in the I.P. for washer fluid remains illuminated and the washer reservoir is full. This documet explains thelocation of the procedure to Validate that the washer reservoir is full with the proper washer solvent
• 10241261May 1, 2014Body and structure. Removing Paint Contaminants from Exterior Paint
• 10239812May 1, 2014Engine cooling. Engine will not start after standing in cold weather below 0°C (32°F), MIL may be illuminated with various induction and/or boost system faults stored in ECM.
• 10124404May 1, 2014Engine. Technical Bulletin (Frozen Charge Air Cooler ? Engine Will Not Start): Engine will not start after standing in cold weather below 0°C (32°F), MIL may be illuminated with various induction and/or boost system faults stored in ECM. Moisture from the intake air condenses and collects in the charge air cooler. At cold temperatures this moisture can freeze causing blockage of the intake air system. This document…
• 10124367Apr 29, 2014Electrical system. Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle

← All problems reported for the 2013 Volkswagen Beetle Convertible