2006 Volkswagen Beetle Technical Service Bulletins

319 technical service bulletins (TSBs) are on record for the 2006 Volkswagen Beetle. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10239405Jul 5, 2013Electrical system. When adapting keys using ODIS, an error message may be displayed once the test plan directs to cycle the key off. If error is displayed, this does not necessarily indicate key adaptation has failed. If the immobilizer light turns off (instead of flashes) when key is switched on, key adaptation is in process. Continue to cycle remaining keys through ignition and then wait 2 minutes with the key off after adapting…
• 10125747Jul 5, 2013Equipment. Tech Tips (Equipped with Immobilizer III - ODIS Key Adaptation Tip): This document informs when adapting keys using ODIS, an error message may be displayed once the test plan directs to cycle the key off. If error is displayed, this does not necessarily indicate key adaptation has failed. If the immobilizer light turns off (instead of flashes) when key is switched on, key adaptation is in process.
• 10242390Jul 1, 2013Equipment. VW Elsa Newsletter
• 10241333Jul 1, 2013Engine cooling. Oil Consumption Measurement
• 10125726Jul 1, 2013Engine cooling. Technical Bulletin (Oil Consumption Measurement): Customer states oil consumption is higher than the Volkswagen oil consumption standard of up to 0.5 quarts per 600 miles, or 0.5 liters per 1000 km. In order to provide effective lubrication and cooling of internal engine components, all internal combustion engines consume a certain amount of engine oil. Oil consumption varies from engine to engine and may change…
• 10125837Jun 28, 2013Engine cooling. Tech Tips (Equipped with Turbocharged Engine Turbocharger Replacement Tip): If mechanical damage is found to the turbocharger (e.g. damaged compression wheel, loose or broken shaft), it is not enough to just replace the turbocharger. This document informs the procedure of checks for damage.
• 10125832Jun 21, 2013Transmission and drivetrain. Tech Tips (Measure Value Block Request): If a request has been made for several MVBs from a DSG transmission, the test plan "Read measured values for obligation to report" can be selected. This function will retrieve all of the MVBs from the transmission which can be attached to a VTA ticket. This selection is available under Guided Functions or GFF when using VAS-PC, an example is shown below.
• 10238566Jun 18, 2013Brakes. If mechanical damage is found to the turbocharger (e.g. damaged compression wheel, loose or broken shaft), it is not enough to just replace the turbocharger.
• 10125853Jun 13, 2013Equipment. Beetle Perfect Delivery Inspection (PDI) - Technician and Detailer Inspections: A checklist to insure a customer receives a wonderful delivery of a vehicle that looks, feels, and meets the expectations of a new vehicle that he/she has purchased
• 10253180May 31, 2013Equipment, Other or unknown. Antenna Diagnosis Overview
• 10239557May 31, 2013Equipment. Antenna Diagnosis Overview
• 10238929May 17, 2013Electrical system, Engine cooling. Engine ? Malfunction During Software Update with "$33$10" displayed
• 10070081May 17, 2013Engine. Summary to be provided on a future date.
• 10243066May 13, 2013Equipment. VW Elsa Newsletter
• 10242404May 13, 2013Other or unknown. VW Elsa Newsletter
• 10238594May 10, 2013Electrical system. When diagnosing a generator charging concern, it is recommended to verify operation of the one way clutch located in the generator pulley (if equipped) before replacing generator assembly. To check the one way clutch, remove the belt from the generator pulley and use a trim removal tool to hold fan blades inside generator, as shown below. When attempting to turn pulley by hand with fan blades held, pulley should…
• 10243065May 6, 2013Equipment. VW Elsa Newsletter
• 10238573Apr 25, 2013Engine cooling. For concerns of Fault Code P117A ?Bank 1, correction Lambda middle reached adjustment limit? stored in the ECM, check that the O2 sensors have not been installed or connected improperly.
• 10243049Apr 15, 2013Equipment. VW Elsa Newsletter
• 10242387Apr 15, 2013Engine cooling, Brakes, Seats. VW Elsa Newsletter
• 10238960Apr 8, 2013Other or unknown, Fuel system, Engine cooling. To clear static ECM fault P1250 ?Fuel Level Too Low?, add fuel to vehicle and complete a road test of at least 10 miles. Simply adding fuel without completing a road test may not allow fault to clear.
• 10238959Apr 8, 2013Other or unknown, Fuel system, Engine cooling. To clear static ECM fault P1250 ?Fuel Level Too Low?, add fuel to vehicle and complete a road test of at least 10 miles. Simply adding fuel without completing a road test may not allow fault to clear.
• 10253177Mar 27, 2013Other or unknown. Satellite Radio Overview
• 10239554Mar 27, 2013Equipment. Satellite Radio Overview
• 10242400Mar 11, 2013Equipment, Visibility (wipers, defrost, mirrors), Electrical system, Engine…. VW Elsa Newsletter
• 10252220Mar 8, 2013Equipment. All Vehicles with Bluetooth Phone Kit Installed ? Streaming Audio from Phone to Radio
• 10052040Mar 8, 2013Engine cooling. Volkswagen: it is a normal occurrence for the electric coolant fans to continue to run after the ignition is switched off.
• 10242399Mar 4, 2013Electrical system, Equipment, Fuel system, Body and structure. VW Elsa Newsletter
• 10239403Mar 1, 2013Electrical system. If key blade is found to stick or bind when opening or closing, check position of roll pin that secures key blade to mechanism. If roll pin is sticking out on either side (as shown below), do not replace key. Instead, use appropriate sized punch and hammer to drive in the roll pin so that it is flush with edge of mechanism.
• 10125635Feb 22, 2013Equipment. Tech Tips (Technician Helpline Vehicle Check Sheets): When it becomes necessary to open a VW Technician Helpline VTA case while performing diagnosis for a diesel particulate filter, manual transmission repair, or turbocharger concern, it is recommended to complete the related worksheet/check sheet before calling. This document informs where Worksheets/Check Sheets are available on ServiceNet.
• 10125626Feb 1, 2013Electrical system. Tech Tips (Instrument Cluster Production Mode): During PDI, or after installation of a replacement cluster, ?Pro? may be displayed in place of the odometer. The high beam indicator may be flashing in the instrument cluster as well. This indicates the cluster is in Production mode. Production mode is not the same as ?Transport? mode. This document infroms of the difference between Production, and Transport mode.
• 10241263Jan 15, 2013Engine cooling, Fuel system. Fuel Additive to Help Prevent Sporadic Misfire Faults
• 10122244Jan 15, 2013Engine cooling. Technical Bulletin (Fuel Additive to Help Prevent Sporadic Misfire Faults): Fuel quality impacts the operating performance, efficiency and service life of the engine. The use of poor quality fuels may result in deposit build up on the fuel injectors and intake valves. This may result in a rough running condition, sporadic misfires, or cold start misfire faults storing in the ECM fault memory.
• 10050944Dec 7, 2012Electrical system. Volkswagen: no terminal 15 power, fault 02403-012. Terminal 15 relay activation can be checked in measured value blocks for module that controls relay, and j519 vehicle electrical system control module. Measured value block number varies between vehicles. All 2006 models except routan.
• 10050079Dec 3, 2012Engine cooling. Volkswagen:evaporative (evap) emission system, diagnostic trouble code diagnosis. Revised procedure developed to test evap system without fuel cap.
• 10157655Oct 25, 2012Body and structure, Equipment. Technical Bulletin (Paint Finish, Reducing Swirl Marks and Fine Scratches): New vehicles (prior to Retail Delivery) with swirl marks and or fine scratches from polishing or cleaning. This document informs of how the Finish can be significantly improved without the use of harsh polishing compounds and high speed buffing.
• 10156059Oct 25, 2012Equipment. Technical Bulletin (Paint Finish, Reducing Swirl Marks and Fine Scratches): New vehicles (prior to Retail Delivery) with swirl marks and or fine scratches from polishing or cleaning. This document informs of how the Finish can be significantly improved without the use of harsh polishing compounds and high speed buffing.
• 10157656Oct 24, 2012Body and structure, Equipment. Technical Bulletin (Hood, Under Hood Not Painted Body Color): The paint color and/or finish of the engine compartment and underside of hood may not match the exterior paint color of the vehicle. Depending on vehicle model and production plant, the color of the engine compartment and underside hood may not match the vehicle body color.
• 10156060Oct 24, 2012Equipment. Technical Bulletin (Hood, Under Hood Not Painted Body Color): The paint color and/or finish of the engine compartment and underside of hood may not match the exterior paint color of the vehicle. Depending on vehicle model and production plant, the color of the engine compartment and underside hood may not match the vehicle body color.
• 10157732Oct 1, 2012Electrical system. Body/Infotainment Module Software Updates: This document informs of various complaints that were addressed in software updates, and technical bulletins.
• 10156127Oct 1, 2012Equipment, Electrical system. Body/Infotainment Module Software Updates: This document informs of various complaints that were addressed in software updates, and technical bulletins.
• 10072897May 11, 2012Equipment. Summary to be provided on a future date.
• 10253204May 6, 2012Visibility (wipers, defrost, mirrors), Other or unknown. Customer States Windshield Wipers Streak or Smear
• 10043602Feb 10, 2012Engine cooling. Volkswagen: gasoline engines have rough idle, have significant loss of power or stalling with reduced performance.
• 10040960Sep 1, 2011Fuel system. Volkswagen service campaign: see document search button for owner letter. Production issues may cause premature wear on the intake camshaft and camshaft follower. Malfunction light will illuminate.
• 10041250Jun 6, 2011Transmission and drivetrain, Steering. Volkswagen: the gear box has a momentarily delay while accelerating.
• 10038665Feb 17, 2011Air bags. Volkswagen: air bag light is on with an internal trouble code stored. This could be a wiring problem.
• 10253213Feb 14, 2011Exterior lighting, Other or unknown. Exterior Lights, Moisture Accumulation
• 10239590Feb 14, 2011Exterior lighting. Exterior Lights, Moisture Accumulation
• 10037805Dec 3, 2010Transmission and drivetrain. Volkswagen: warranty information for th e transmission valve body.

← All problems reported for the 2006 Volkswagen Beetle