2007 Volkswagen Beetle Technical Service Bulletins

346 technical service bulletins (TSBs) are on record for the 2007 Volkswagen Beetle. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10243065May 6, 2013Equipment. VW Elsa Newsletter
• 10238573Apr 25, 2013Engine cooling. For concerns of Fault Code P117A ?Bank 1, correction Lambda middle reached adjustment limit? stored in the ECM, check that the O2 sensors have not been installed or connected improperly.
• 10243049Apr 15, 2013Equipment. VW Elsa Newsletter
• 10242387Apr 15, 2013Engine cooling, Brakes, Seats. VW Elsa Newsletter
• 10238960Apr 8, 2013Other or unknown, Fuel system, Engine cooling. To clear static ECM fault P1250 ?Fuel Level Too Low?, add fuel to vehicle and complete a road test of at least 10 miles. Simply adding fuel without completing a road test may not allow fault to clear.
• 10238959Apr 8, 2013Other or unknown, Fuel system, Engine cooling. To clear static ECM fault P1250 ?Fuel Level Too Low?, add fuel to vehicle and complete a road test of at least 10 miles. Simply adding fuel without completing a road test may not allow fault to clear.
• 10253177Mar 27, 2013Other or unknown. Satellite Radio Overview
• 10239554Mar 27, 2013Equipment. Satellite Radio Overview
• 10242400Mar 11, 2013Equipment, Visibility (wipers, defrost, mirrors), Electrical system, Engine…. VW Elsa Newsletter
• 10252220Mar 8, 2013Equipment. All Vehicles with Bluetooth Phone Kit Installed ? Streaming Audio from Phone to Radio
• 10052040Mar 8, 2013Engine cooling. Volkswagen: it is a normal occurrence for the electric coolant fans to continue to run after the ignition is switched off.
• 10242399Mar 4, 2013Electrical system, Equipment, Fuel system, Body and structure. VW Elsa Newsletter
• 10239403Mar 1, 2013Electrical system. If key blade is found to stick or bind when opening or closing, check position of roll pin that secures key blade to mechanism. If roll pin is sticking out on either side (as shown below), do not replace key. Instead, use appropriate sized punch and hammer to drive in the roll pin so that it is flush with edge of mechanism.
• 10125635Feb 22, 2013Equipment. Tech Tips (Technician Helpline Vehicle Check Sheets): When it becomes necessary to open a VW Technician Helpline VTA case while performing diagnosis for a diesel particulate filter, manual transmission repair, or turbocharger concern, it is recommended to complete the related worksheet/check sheet before calling. This document informs where Worksheets/Check Sheets are available on ServiceNet.
• 10125626Feb 1, 2013Electrical system. Tech Tips (Instrument Cluster Production Mode): During PDI, or after installation of a replacement cluster, ?Pro? may be displayed in place of the odometer. The high beam indicator may be flashing in the instrument cluster as well. This indicates the cluster is in Production mode. Production mode is not the same as ?Transport? mode. This document infroms of the difference between Production, and Transport mode.
• 10241263Jan 15, 2013Engine cooling, Fuel system. Fuel Additive to Help Prevent Sporadic Misfire Faults
• 10122244Jan 15, 2013Engine cooling. Technical Bulletin (Fuel Additive to Help Prevent Sporadic Misfire Faults): Fuel quality impacts the operating performance, efficiency and service life of the engine. The use of poor quality fuels may result in deposit build up on the fuel injectors and intake valves. This may result in a rough running condition, sporadic misfires, or cold start misfire faults storing in the ECM fault memory.
• 10050079Dec 3, 2012Engine cooling. Volkswagen:evaporative (evap) emission system, diagnostic trouble code diagnosis. Revised procedure developed to test evap system without fuel cap.
• 10157655Oct 25, 2012Body and structure, Equipment. Technical Bulletin (Paint Finish, Reducing Swirl Marks and Fine Scratches): New vehicles (prior to Retail Delivery) with swirl marks and or fine scratches from polishing or cleaning. This document informs of how the Finish can be significantly improved without the use of harsh polishing compounds and high speed buffing.
• 10156059Oct 25, 2012Equipment. Technical Bulletin (Paint Finish, Reducing Swirl Marks and Fine Scratches): New vehicles (prior to Retail Delivery) with swirl marks and or fine scratches from polishing or cleaning. This document informs of how the Finish can be significantly improved without the use of harsh polishing compounds and high speed buffing.
• 10157656Oct 24, 2012Body and structure, Equipment. Technical Bulletin (Hood, Under Hood Not Painted Body Color): The paint color and/or finish of the engine compartment and underside of hood may not match the exterior paint color of the vehicle. Depending on vehicle model and production plant, the color of the engine compartment and underside hood may not match the vehicle body color.
• 10156060Oct 24, 2012Equipment. Technical Bulletin (Hood, Under Hood Not Painted Body Color): The paint color and/or finish of the engine compartment and underside of hood may not match the exterior paint color of the vehicle. Depending on vehicle model and production plant, the color of the engine compartment and underside hood may not match the vehicle body color.
• 10157732Oct 1, 2012Electrical system. Body/Infotainment Module Software Updates: This document informs of various complaints that were addressed in software updates, and technical bulletins.
• 10156127Oct 1, 2012Equipment, Electrical system. Body/Infotainment Module Software Updates: This document informs of various complaints that were addressed in software updates, and technical bulletins.
• 10253204May 6, 2012Visibility (wipers, defrost, mirrors), Other or unknown. Customer States Windshield Wipers Streak or Smear
• 10043602Feb 10, 2012Engine cooling. Volkswagen: gasoline engines have rough idle, have significant loss of power or stalling with reduced performance.
• 10040960Sep 1, 2011Fuel system. Volkswagen service campaign: see document search button for owner letter. Production issues may cause premature wear on the intake camshaft and camshaft follower. Malfunction light will illuminate.
• 10041250Jun 6, 2011Transmission and drivetrain, Steering. Volkswagen: the gear box has a momentarily delay while accelerating.
• 10038665Feb 17, 2011Air bags. Volkswagen: air bag light is on with an internal trouble code stored. This could be a wiring problem.
• 10253213Feb 14, 2011Exterior lighting, Other or unknown. Exterior Lights, Moisture Accumulation
• 10239590Feb 14, 2011Exterior lighting. Exterior Lights, Moisture Accumulation
• 10036493Sep 30, 2010Other or unknown. Volkswagen: child restraint latch guidance fixture; compliance with fmvss 225 (usa only). Update to existing technical bulletin. No production change required. All models.
• 10036467Aug 9, 2010Exterior lighting, Electrical system. Volkswagen: headlights may intermittently dim slightly at idle. The headlamps or inside lights intermittently dim slightly at idle speed. At idle speed the alternator voltage can fluctuate, as the alternator cannot fully compensate the fluctuations. Golf & wagon gti, new beetle & convertible, eos, jetta & wagon & sportwagon, rabbit, r32, tiguan.
• 10035204Aug 9, 2010Exterior lighting, Electrical system. Volkswagen: headlights may intermittently dim slightly at idle. At idle speed the alternator voltage can fluctuate, as the alternator cannot fully compensate the fluctuations. Some electric consumers come on in cycles or have no constant current consumption, which amplifies this effect. The load condition of the vehicle battery can also influence this effect. Models golf, gti, new beetle & convertible, eos, jetta…
• 10035104Aug 4, 2010Engine cooling. Volkswagen: gff test plan, ground connection verification. New gff function test for engine will not start or intermittently does not start conditions. Engine grounds may not be secure. Models new beetle, convertible, jetta, wagon and sportwagen. Model years 2005-2010.
• 10036970Aug 1, 2010Transmission and drivetrain. Volkswagen service campaign: see document search button for owner letter. In some vehicles it is possible that a bushing inside the mechatronic unit has the potential to wear out prematurely, causing the clutches inside the transmission to operate less smoothly than before. The driver will begin to notice changes in the way the vehicle feels as the transmission shifts (jerking). This change can become very…
• 10036496Aug 1, 2010Electrical system, Engine cooling. Volkswagen: gasoline engine vehicles inspect, and if necessary, replace ignition coils. Vehicles affected by this action may have ignition coils that could malfunction under certain conditions. Models passat and wagon; golf; gti; jetta and wagon; new beetle and convertible; phaeton; eos; rabbit, etc.
• 10033216Jul 1, 2010Electrical system, Engine cooling. Volkswagen: (revised) vehicles may have ignition coils that could malfunction under certain conditions. If this happens, the malfunction indicator lamp (mil) will illuminated to let you know that vehicle may experience some deterioration in performance. In some cases, a malfunctioning ignition coil may cause a vehicle to exceed federal and/or california emissions standards. 2001-2007 passa/passat wagon. *pe updated…
• 10034069May 7, 2010Visibility (wipers, defrost, mirrors). Volkswagen service campaign: see document search button for owner letter. Inspect, clean and modify sunroof drains for certain volkswagen vehicles and revised maintenance schedule; sunroof drain inspection and cleaning. No models or model years listed. Csc letter was rec'd. *pe model and model years included. Updated
• 10237716Nov 13, 2009Equipment. The streaming music feature on vehicles equipped with factory or dealer installed Bluetooth will be available only in certain instances. The vehicle must be equipped with the RCD 310 or RCD 510 (Premium 8) radios or the RNS 510 or RNS 315 navigation systems. The Bluetooth system must be either the UHV low (9W2), UHV?NAR (9W7 or 9ZR) factory installed systems or the Volk ? L dealer installed system.
• 10033207Oct 28, 2009Engine cooling, Electrical system. Volkswagen: vehicles may have ignition coils that could malfunction under certain conditions. If this happens, the malfunction indicator lamp (mil) will illuminated to let you know that the vehicle may experience some deterioration in performance. In some cases, a malfunctioning ignition coil may cause a vehicle to exceed federal and/or california emissions standards. No models listed.
• 10027686Oct 22, 2008Electrical system, Visibility (wipers, defrost, mirrors). Volkswagen: instrument cluster, lights flicker intermittenly when windshield wipers are in use. Models new beetle and new beetle convertibles; model years 2007 and 2008.
• 10026848Aug 28, 2008Engine cooling, Body and structure. Volkswagen: exhaust heat shield, replacement guidelines. Heat shields are to be inspected after completion o any type of repair to the underbody (exhaust system transmission, etc.), and if damaged, replaced.
• 10024403Jan 29, 2008Air bags. Airbag monitoring light on, passenger occupant detection system, dtc 02511 014 stored in memory.
• 10021963May 15, 2007Engine cooling. Update programming, mil on, dtc p0011, p000a stored in ecm fault memory.
• 10212720Jan 1, 2007Engine cooling. Pollen Filter Removal.

← All problems reported for the 2007 Volkswagen Beetle