2009 Volkswagen Beetle Technical Service Bulletins

586 technical service bulletins (TSBs) are on record for the 2009 Volkswagen Beetle. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10238929May 17, 2013Electrical system, Engine cooling. Engine ? Malfunction During Software Update with "$33$10" displayed
• 10070081May 17, 2013Engine. Summary to be provided on a future date.
• 10241350May 16, 2013Brakes, Fuel system. High Pressure Fuel Pump Diagnosis
• 10052337May 16, 2013Fuel system. Volkswagen: some vehicles may run rough, experience engine crank, or no start. Also included model beetle convertible model years 2008-2013
• 10240677May 15, 2013Engine cooling. Install Misfueling Guard
• 10243066May 13, 2013Equipment. VW Elsa Newsletter
• 10242404May 13, 2013Other or unknown. VW Elsa Newsletter
• 10238961May 10, 2013Equipment, Fuel system. Be aware that fuel lines are color coded on vehicles with return fuel pressure lines. The black line is for fuel pressure supply and the blue line is for fuel pressure return. To verify correct line installation, remove the metal cover exposing the fuel pump flange assembly (generally under the rear seat). Refer to the ELSA Repair Manual for specific location. Check for raised arrows on the flange housing.
• 10238594May 10, 2013Electrical system. When diagnosing a generator charging concern, it is recommended to verify operation of the one way clutch located in the generator pulley (if equipped) before replacing generator assembly. To check the one way clutch, remove the belt from the generator pulley and use a trim removal tool to hold fan blades inside generator, as shown below. When attempting to turn pulley by hand with fan blades held, pulley should…
• 10241286May 9, 2013Engine cooling. Engine, Misfire Diagnostic Aid
• 10052336May 9, 2013Engine. Volkswagen: some vehicles may experience a misfire and/or reduced engine performance.
• 10243065May 6, 2013Equipment. VW Elsa Newsletter
• 10238573Apr 25, 2013Engine cooling. For concerns of Fault Code P117A ?Bank 1, correction Lambda middle reached adjustment limit? stored in the ECM, check that the O2 sensors have not been installed or connected improperly.
• 10243050Apr 22, 2013Equipment. VW Elsa Newsletter
• 10242388Apr 22, 2013Equipment. VW Elsa Newsletter
• 10243049Apr 15, 2013Equipment. VW Elsa Newsletter
• 10242387Apr 15, 2013Engine cooling, Brakes, Seats. VW Elsa Newsletter
• 10241349Apr 15, 2013Fuel system, Brakes. High Pressure Fuel Pump Diagnosis
• 10051639Apr 15, 2013Fuel system. Volkswagen: high pressure fuel pump diagnosis. Engine crank, no start after long periods without driving. Engine may run rough, and or mil-on with dtc p0087-low fuel pressure stored in ecm fault memory. Also included model eos year 2013, model git year 2013, model beetle covertible year 2009-2013. *js updated 7/10/13.
• 10238960Apr 8, 2013Other or unknown, Fuel system, Engine cooling. To clear static ECM fault P1250 ?Fuel Level Too Low?, add fuel to vehicle and complete a road test of at least 10 miles. Simply adding fuel without completing a road test may not allow fault to clear.
• 10238959Apr 8, 2013Other or unknown, Fuel system, Engine cooling. To clear static ECM fault P1250 ?Fuel Level Too Low?, add fuel to vehicle and complete a road test of at least 10 miles. Simply adding fuel without completing a road test may not allow fault to clear.
• 10252900Mar 29, 2013Equipment. GPS Antenna Concerns
• 10252225Mar 29, 2013Equipment. Vehicles Equipped with Bluetooth Hands-Free Phone ? Pairing of Android Phones
• 10237721Mar 29, 2013Equipment. When pairing an Android phone to the Bluetooth system, a few extra steps may be necessary. Follow the instructions below to pair the phone:
• 10253177Mar 27, 2013Other or unknown. Satellite Radio Overview
• 10239554Mar 27, 2013Equipment. Satellite Radio Overview
• 10243064Mar 25, 2013Equipment. VW Elsa Newsletter
• 10242402Mar 25, 2013Other or unknown. VW Elsa Newsletter
• 10241282Mar 15, 2013Engine cooling. Engine, Misfire Diagnostic Aid
• 10253483Mar 12, 2013Engine cooling. Engine Exhaust Flap Limited Warranty Extension
• 10242400Mar 11, 2013Equipment, Visibility (wipers, defrost, mirrors), Electrical system, Engine…. VW Elsa Newsletter
• 10252220Mar 8, 2013Equipment. All Vehicles with Bluetooth Phone Kit Installed ? Streaming Audio from Phone to Radio
• 10052040Mar 8, 2013Engine cooling. Volkswagen: it is a normal occurrence for the electric coolant fans to continue to run after the ignition is switched off.
• 10242399Mar 4, 2013Electrical system, Equipment, Fuel system, Body and structure. VW Elsa Newsletter
• 10239403Mar 1, 2013Electrical system. If key blade is found to stick or bind when opening or closing, check position of roll pin that secures key blade to mechanism. If roll pin is sticking out on either side (as shown below), do not replace key. Instead, use appropriate sized punch and hammer to drive in the roll pin so that it is flush with edge of mechanism.
• 10125635Feb 22, 2013Equipment. Tech Tips (Technician Helpline Vehicle Check Sheets): When it becomes necessary to open a VW Technician Helpline VTA case while performing diagnosis for a diesel particulate filter, manual transmission repair, or turbocharger concern, it is recommended to complete the related worksheet/check sheet before calling. This document informs where Worksheets/Check Sheets are available on ServiceNet.
• 10125613Feb 15, 2013Electrical system. Technical Bulletin (Bluetooth System Identification): This document informs how to identify the various Bluetooth systems by: ? Visual Identification ? PR Code ? Part Number
• 10125626Feb 1, 2013Electrical system. Tech Tips (Instrument Cluster Production Mode): During PDI, or after installation of a replacement cluster, ?Pro? may be displayed in place of the odometer. The high beam indicator may be flashing in the instrument cluster as well. This indicates the cluster is in Production mode. Production mode is not the same as ?Transport? mode. This document infroms of the difference between Production, and Transport mode.
• 10236501Jan 21, 2013Equipment. ElsaWeb Newsletter
• 10238941Jan 18, 2013Transmission and drivetrain, Engine cooling. When servicing the timing chain sprocket or removing the vibration damper, be aware that one bolt holds both the vibration damper (harmonic balancer) and the crankshaft timing chain sprocket to the crankshaft. Once the damper is removed, the crankshaft should not be rotated unless special tool spacer T10368 has been installed. The crankshaft timing chain sprocket and spur gear drive on the crankshaft have a…
• 10238940Jan 18, 2013Engine cooling, Transmission and drivetrain. CBFA 2.0T TSI Engine
• 10241348Jan 16, 2013Brakes, Fuel system. High Pressure Fuel Pump Diagnosis
• 10241347Jan 15, 2013Fuel system, Brakes. High Pressure Fuel Pump Diagnosis
• 10241263Jan 15, 2013Engine cooling, Fuel system. Fuel Additive to Help Prevent Sporadic Misfire Faults
• 10122244Jan 15, 2013Engine cooling. Technical Bulletin (Fuel Additive to Help Prevent Sporadic Misfire Faults): Fuel quality impacts the operating performance, efficiency and service life of the engine. The use of poor quality fuels may result in deposit build up on the fuel injectors and intake valves. This may result in a rough running condition, sporadic misfires, or cold start misfire faults storing in the ECM fault memory.
• 10051755Jan 15, 2013Fuel system. Volkswagen: would experience no start after long periods of not driving and engine run rough. To avoid unnecessary replacements, high pressure fuel pump diagnosis test is essential to proper pump operation. Models 2009-2013 tiguan, eos cc, gti, beetle, convertible, jetta.
• 10241351Jan 14, 2013Fuel system, Brakes. High Pressure Fuel Pump Diagnosis
• 10050079Dec 3, 2012Engine cooling. Volkswagen:evaporative (evap) emission system, diagnostic trouble code diagnosis. Revised procedure developed to test evap system without fuel cap.
• 10071285Dec 1, 2012Equipment. Summary to be provided on a future date.
• 10241346Nov 21, 2012Brakes, Engine. Engine Crank, No Start after Long Periods without Driving. Engine may run rough, and or MIL-ON with DTC P0087-low fuel pressure stored in ECM Fault Memory.

← All problems reported for the 2009 Volkswagen Beetle