2011 Volkswagen CC Technical Service Bulletins

835 technical service bulletins (TSBs) are on record for the 2011 Volkswagen CC. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10238566Jun 18, 2013Brakes. If mechanical damage is found to the turbocharger (e.g. damaged compression wheel, loose or broken shaft), it is not enough to just replace the turbocharger.
• 10125822Jun 14, 2013Fuel system. Technical Bulletin (High Pressure Fuel Pump Diagnosis): Completing the GFF high pressure pump function test is essential to diagnose proper pump operation and to avoid unnecessary replacements. This document informs how to perform the diagnostic. This document discusses the "Fault Codes" necessary to diagnosis, and potential remedy of the issue. The fault codes for checking warranty coverage for servicing the…
• 10052670Jun 14, 2013Fuel system. Volkswagen: on some vehicles, low fuel stored in ecm pressure, engine would crank but not start long periods without driving, may run rough and/or mil on. All models 2008-2013.
• 10241700Jun 13, 2013Equipment. Perfect Delivery Inspection (PDI) - Technician and Detailer Inspections
• 10125852Jun 13, 2013Equipment. CC Perfect Delivery Inspection (PDI) - Technician and Detailer Inspections: A checklist to insure a customer receives a wonderful delivery of a vehicle that looks, feels, and meets the expectations of a new vehicle that he/she has purchased
• 10237994Jun 10, 2013Transmission and drivetrain. Automatic Transmission Fluid Requirements
• 10125819Jun 10, 2013Transmission and drivetrain. Technical Bulletin (Automatic Transmission Fluid Requirements): At this time, Volkswagen Group of America, Volkswagen Canada do not support or warranty any use of aftermarket universal automatic transmission fluids or the machines used to flush the transmissions. This applies to all standard automatic and DSG transmissions.
• 10253205Jun 7, 2013Other or unknown, Visibility (wipers, defrost, mirrors). Wiper Blade Inspection for Proper Warranty Coding
• 10239582Jun 7, 2013Visibility (wipers, defrost, mirrors). Wiper Blade Inspection for Proper Warranty Coding
• 10125813Jun 7, 2013Visibility (wipers, defrost, mirrors). Technical Bulletin (Wiper Blade Inspection for Proper Warranty Coding): Wiper blade inspection guidelines for wear and tear, outside influence or a factory issue. This document informs what is under coverage for wiper blade issues.
• 10240650Jun 5, 2013Equipment. We would like to inform you that the FAQ for Service Action 20T8 has been revised to include additional information for dealers to share with customers about the misfueling guard.
• 10239556May 30, 2013Equipment. RNS 315 Hardware Failure
• 10243068May 28, 2013Equipment. VW Elsa Newsletter
• 10242406May 28, 2013Other or unknown. VW Elsa Newsletter
• 10252932May 24, 2013Steering, Electrical system. Cruise Control Inoperative, Fault B115411 ?Cruise Control Switch Short Circuit to Ground? after J527 Steering Column Control Module Replacement
• 10067115May 24, 2013Vehicle speed control. Summary to be provided on a future date.
• 10238019May 22, 2013Brakes. Brake Disc, Pulsation, All Vehicles except Routan (U.S. Only)
• 10241350May 16, 2013Brakes, Fuel system. High Pressure Fuel Pump Diagnosis
• 10052337May 16, 2013Fuel system. Volkswagen: some vehicles may run rough, experience engine crank, or no start. Also included model beetle convertible model years 2008-2013
• 10240677May 15, 2013Engine cooling. Install Misfueling Guard
• 10243066May 13, 2013Equipment. VW Elsa Newsletter
• 10242404May 13, 2013Other or unknown. VW Elsa Newsletter
• 10238961May 10, 2013Equipment, Fuel system. Be aware that fuel lines are color coded on vehicles with return fuel pressure lines. The black line is for fuel pressure supply and the blue line is for fuel pressure return. To verify correct line installation, remove the metal cover exposing the fuel pump flange assembly (generally under the rear seat). Refer to the ELSA Repair Manual for specific location. Check for raised arrows on the flange housing.
• 10238594May 10, 2013Electrical system. When diagnosing a generator charging concern, it is recommended to verify operation of the one way clutch located in the generator pulley (if equipped) before replacing generator assembly. To check the one way clutch, remove the belt from the generator pulley and use a trim removal tool to hold fan blades inside generator, as shown below. When attempting to turn pulley by hand with fan blades held, pulley should…
• 10241286May 9, 2013Engine cooling. Engine, Misfire Diagnostic Aid
• 10052336May 9, 2013Engine. Volkswagen: some vehicles may experience a misfire and/or reduced engine performance.
• 10243065May 6, 2013Equipment. VW Elsa Newsletter
• 10242403May 6, 2013Other or unknown. VW Elsa Newsletter
• 10239213May 6, 2013Equipment. RNS 315 Retrofit
• 10052354May 3, 2013Steering. Volkswagen: steering rack. After replacing the steering rack the fault code 01309 008 is set in abs/esp module. Also included model gti my 2013, model tiguan my 2005-2007, model rabbit my 2005/2011-2013, model eos my 2005/2013, model cc my 2005-2008
• 10238949Apr 26, 2013Engine cooling. After a cold start, the engine coolant temperature gauge will slowly rise to approximately 190° F. When the F265 mapped thermostat opens, the gauge may drop by approximately 60° F before again rising to 190° F. No repairs should be attempted for this normal concern. F265 is pictured below.
• 10243050Apr 22, 2013Equipment. VW Elsa Newsletter
• 10242388Apr 22, 2013Equipment. VW Elsa Newsletter
• 10238018Apr 19, 2013Brakes. Brake Disc, Pulsation, All Vehicles except Routan (U.S. Only)
• 10241349Apr 15, 2013Fuel system, Brakes. High Pressure Fuel Pump Diagnosis
• 10051639Apr 15, 2013Fuel system. Volkswagen: high pressure fuel pump diagnosis. Engine crank, no start after long periods without driving. Engine may run rough, and or mil-on with dtc p0087-low fuel pressure stored in ecm fault memory. Also included model eos year 2013, model git year 2013, model beetle covertible year 2009-2013. *js updated 7/10/13.
• 10212721Apr 13, 2013Equipment. Bluetooth Compatibility.
• 10252907Apr 12, 2013Equipment. Radio Navigation Unit Security Label
• 10238968Apr 12, 2013Electrical system, Brakes. If fault code 03200 or 16352 is present in the Electromechanical Parking Brake (EPB) module, it may be due to the switch and module not being synchronized.
• 10237731Apr 12, 2013Equipment. When replacing a radio navigation unit, inspect the security labels on both the new and replacement units for damage. If damage is found to a label on either unit, be sure to note this on the repair order along with the reason the radio is being replaced.
• 10239555Apr 11, 2013Equipment. RNS 315 Hardware Failure
• 10238960Apr 8, 2013Other or unknown, Fuel system, Engine cooling. To clear static ECM fault P1250 ?Fuel Level Too Low?, add fuel to vehicle and complete a road test of at least 10 miles. Simply adding fuel without completing a road test may not allow fault to clear.
• 10238959Apr 8, 2013Other or unknown, Fuel system, Engine cooling. To clear static ECM fault P1250 ?Fuel Level Too Low?, add fuel to vehicle and complete a road test of at least 10 miles. Simply adding fuel without completing a road test may not allow fault to clear.
• 10252906Apr 5, 2013Equipment. RNS 510 ? Radio Preset Display
• 10237730Apr 5, 2013Equipment. Be aware that the 24 RNS-510 radio presets are not band dependent, and can be programmed to any mix of AM, FM, or satellite stations. The presets shown on the display will not change when switching between bands.
• 10252900Mar 29, 2013Equipment. GPS Antenna Concerns
• 10252225Mar 29, 2013Equipment. Vehicles Equipped with Bluetooth Hands-Free Phone ? Pairing of Android Phones
• 10237721Mar 29, 2013Equipment. When pairing an Android phone to the Bluetooth system, a few extra steps may be necessary. Follow the instructions below to pair the phone:
• 10253177Mar 27, 2013Other or unknown. Satellite Radio Overview
• 10239554Mar 27, 2013Equipment. Satellite Radio Overview

← All problems reported for the 2011 Volkswagen CC