2012 Volkswagen CC Technical Service Bulletins

991 technical service bulletins (TSBs) are on record for the 2012 Volkswagen CC. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10240678Jun 28, 2013Fuel system. Install Misfueling Guard
• 10125837Jun 28, 2013Engine cooling. Tech Tips (Equipped with Turbocharged Engine Turbocharger Replacement Tip): If mechanical damage is found to the turbocharger (e.g. damaged compression wheel, loose or broken shaft), it is not enough to just replace the turbocharger. This document informs the procedure of checks for damage.
• 10242398Jun 24, 2013Fuel system, Equipment, Electrical system, Suspension. VW Elsa Newsletter
• 10125832Jun 21, 2013Transmission and drivetrain. Tech Tips (Measure Value Block Request): If a request has been made for several MVBs from a DSG transmission, the test plan "Read measured values for obligation to report" can be selected. This function will retrieve all of the MVBs from the transmission which can be attached to a VTA ticket. This selection is available under Guided Functions or GFF when using VAS-PC, an example is shown below.
• 10239411Jun 18, 2013Engine cooling. Activated Charcoal Filter System, Solenoid Valve 1 -N80- (Canister Purge Valve) Diagnosis
• 10238566Jun 18, 2013Brakes. If mechanical damage is found to the turbocharger (e.g. damaged compression wheel, loose or broken shaft), it is not enough to just replace the turbocharger.
• 10125822Jun 14, 2013Fuel system. Technical Bulletin (High Pressure Fuel Pump Diagnosis): Completing the GFF high pressure pump function test is essential to diagnose proper pump operation and to avoid unnecessary replacements. This document informs how to perform the diagnostic. This document discusses the "Fault Codes" necessary to diagnosis, and potential remedy of the issue. The fault codes for checking warranty coverage for servicing the…
• 10052670Jun 14, 2013Fuel system. Volkswagen: on some vehicles, low fuel stored in ecm pressure, engine would crank but not start long periods without driving, may run rough and/or mil on. All models 2008-2013.
• 10241700Jun 13, 2013Equipment. Perfect Delivery Inspection (PDI) - Technician and Detailer Inspections
• 10240866Jun 13, 2013Equipment. Please contact VW Helpline before attempting repair
• 10144740Jun 13, 2013Transmission and drivetrain. On-car analysis list of Customer Complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex)
• 10125852Jun 13, 2013Equipment. CC Perfect Delivery Inspection (PDI) - Technician and Detailer Inspections: A checklist to insure a customer receives a wonderful delivery of a vehicle that looks, feels, and meets the expectations of a new vehicle that he/she has purchased
• 10125821Jun 13, 2013Electrical system, Engine cooling. Technical Bulletin (Generator Replacement): This document informs of Charging System inoperative/malfunctions, noise from engine compartment, accessory drive belt damaged or missing.
• 10052654Jun 13, 2013Engine, Electrical system. Volkswagen: due to accessory drive belt being damaged or missing, the charging system is inoperative or malfunction, and noise is coming from engine compartment. Model 2012-2014 all vehicles except routan, touareg hybrid, jetta hybrid.
• 10243058Jun 10, 2013Equipment. VW Elsa Newsletter
• 10242396Jun 10, 2013Body and structure, Electrical system, Equipment, Visibility (wipers, defrost…. VW Elsa Newsletter
• 10237994Jun 10, 2013Transmission and drivetrain. Automatic Transmission Fluid Requirements
• 10125819Jun 10, 2013Transmission and drivetrain. Technical Bulletin (Automatic Transmission Fluid Requirements): At this time, Volkswagen Group of America, Volkswagen Canada do not support or warranty any use of aftermarket universal automatic transmission fluids or the machines used to flush the transmissions. This applies to all standard automatic and DSG transmissions.
• 10253205Jun 7, 2013Other or unknown, Visibility (wipers, defrost, mirrors). Wiper Blade Inspection for Proper Warranty Coding
• 10239582Jun 7, 2013Visibility (wipers, defrost, mirrors). Wiper Blade Inspection for Proper Warranty Coding
• 10125813Jun 7, 2013Visibility (wipers, defrost, mirrors). Technical Bulletin (Wiper Blade Inspection for Proper Warranty Coding): Wiper blade inspection guidelines for wear and tear, outside influence or a factory issue. This document informs what is under coverage for wiper blade issues.
• 10240650Jun 5, 2013Equipment. We would like to inform you that the FAQ for Service Action 20T8 has been revised to include additional information for dealers to share with customers about the misfueling guard.
• 10239556May 30, 2013Equipment. RNS 315 Hardware Failure
• 10243068May 28, 2013Equipment. VW Elsa Newsletter
• 10242406May 28, 2013Other or unknown. VW Elsa Newsletter
• 10252932May 24, 2013Steering, Electrical system. Cruise Control Inoperative, Fault B115411 ?Cruise Control Switch Short Circuit to Ground? after J527 Steering Column Control Module Replacement
• 10067115May 24, 2013Vehicle speed control. Summary to be provided on a future date.
• 10238019May 22, 2013Brakes. Brake Disc, Pulsation, All Vehicles except Routan (U.S. Only)
• 10241350May 16, 2013Brakes, Fuel system. High Pressure Fuel Pump Diagnosis
• 10052337May 16, 2013Fuel system. Volkswagen: some vehicles may run rough, experience engine crank, or no start. Also included model beetle convertible model years 2008-2013
• 10240677May 15, 2013Engine cooling. Install Misfueling Guard
• 10243066May 13, 2013Equipment. VW Elsa Newsletter
• 10242404May 13, 2013Other or unknown. VW Elsa Newsletter
• 10238961May 10, 2013Equipment, Fuel system. Be aware that fuel lines are color coded on vehicles with return fuel pressure lines. The black line is for fuel pressure supply and the blue line is for fuel pressure return. To verify correct line installation, remove the metal cover exposing the fuel pump flange assembly (generally under the rear seat). Refer to the ELSA Repair Manual for specific location. Check for raised arrows on the flange housing.
• 10238594May 10, 2013Electrical system. When diagnosing a generator charging concern, it is recommended to verify operation of the one way clutch located in the generator pulley (if equipped) before replacing generator assembly. To check the one way clutch, remove the belt from the generator pulley and use a trim removal tool to hold fan blades inside generator, as shown below. When attempting to turn pulley by hand with fan blades held, pulley should…
• 10241286May 9, 2013Engine cooling. Engine, Misfire Diagnostic Aid
• 10240868May 9, 2013Equipment. Please contact VW Helpline before attempting repair
• 10152548May 9, 2013Transmission and drivetrain. On-car analysis list of Customer Complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex)
• 10144728May 9, 2013Transmission and drivetrain. On-car analysis list of Customer Complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex)
• 10052336May 9, 2013Engine. Volkswagen: some vehicles may experience a misfire and/or reduced engine performance.
• 10243065May 6, 2013Equipment. VW Elsa Newsletter
• 10242403May 6, 2013Other or unknown. VW Elsa Newsletter
• 10239213May 6, 2013Equipment. RNS 315 Retrofit
• 10238607May 3, 2013Transmission and drivetrain. If a CV boot is found to be leaking grease on PDI and a clamp is found to be loose or not aligned properly, only the clamp should be replaced. If concern is found after the vehicle is sold, replace the complete CV joint.
• 10052354May 3, 2013Steering. Volkswagen: steering rack. After replacing the steering rack the fault code 01309 008 is set in abs/esp module. Also included model gti my 2013, model tiguan my 2005-2007, model rabbit my 2005/2011-2013, model eos my 2005/2013, model cc my 2005-2008
• 10243051Apr 29, 2013Equipment. VW Elsa Newsletter
• 10242389Apr 29, 2013Equipment. VW Elsa Newsletter
• 10152545Apr 29, 2013Engine cooling, Body and structure, Electrical system. On-car analysis list of Customer Complaints: Transmission
• 10252904Apr 26, 2013Equipment. Equipped With RNS-510 Radio?Unit Start-Up and Boot-Up Operation
• 10238949Apr 26, 2013Engine cooling. After a cold start, the engine coolant temperature gauge will slowly rise to approximately 190° F. When the F265 mapped thermostat opens, the gauge may drop by approximately 60° F before again rising to 190° F. No repairs should be attempted for this normal concern. F265 is pictured below.

← All problems reported for the 2012 Volkswagen CC