2013 Volkswagen CC Technical Service Bulletins

1,026 technical service bulletins (TSBs) are on record for the 2013 Volkswagen CC. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10124342Apr 2, 2014Brakes. Technical Bulletin (Brake Disc Pulsation or Vibration): When applying brakes at highway speeds the following symptoms may occur: ? Brake pedal pulsation ? Vibration felt in vehicle body ? Steering wheel shakes A detailed brake disc inspection is needed to determine if the brake disc should be machined or replaced.
• 10239270Apr 1, 2014Equipment. Volkswagen Warranty Policies and Procedures ? April 2014
• 10239533Mar 27, 2014Visibility (wipers, defrost, mirrors). HVAC, Unpleasant Odor
• 10124289Mar 27, 2014Equipment. Technical Bulletin (HVAC, Unpleasant Odor): Unpleasant odor is coming from Heating and Ventilation system. Odor mainly occurs after vehicle has been sitting (unused) at least 5 hours and within 20 to 60 seconds after vehicle is first started. Condensation is a normal characteristic in all A/C systems. If odor is noticeable continue to follow this document. Contaminants are effectively neutralized using the…
• 10241311Mar 26, 2014Engine cooling. Gasoline Quality
• 10124302Mar 26, 2014Engine. Technical Bulletin The use of contaminated gasoline, seasonal fuel changes (summer/winter fuel) or gasoline with a low content of deposit control additives may result in one or more of the following conditions: -Excessive accumulation of deposits on intake valves, intake manifold, fuel injectors and combustion chambers. -Engine runs rough after cold start. -Excessive engine cranking time. -Stumbles while driving…
• 10241342Mar 25, 2014Electrical system, Engine cooling. Electric Coolant Fans Continue to Run after Ignition is OFF
• 10241329Mar 21, 2014Engine. Proper Removal of Engine Cover to Avoid Breakage
• 10124299Mar 21, 2014Engine. Technical Bulletin (Proper Removal of Engine Cover to Avoid Breakage): Pulling on the engine cover in some areas can cause damage. This document informs on the procedure to remove the engine cover.
• 10239818Mar 20, 2014Electrical system. MIL ON, No Start, or Rough Running with DTCs P0087, P0088 or P0191 Stored in ECM Fault Memory (TDI ONLY)
• 10241310Mar 18, 2014Electrical system, Other or unknown. Software Version Management
• 10124303Mar 18, 2014Electrical system. Technical Bulletin This Technical Bulletin details the general process for carrying out a Software Version Management (SVM) software update for any Technical Bulletin (TSB) / Required Vehicle Update (RVU).
• 10055439Mar 18, 2014Steering. Volkswagen: some consumers may complain that the steering is stiff. The yellow and red power steering warning light is illuminated. There may be insufficient steering assistance.
• 10124311Mar 14, 2014Equipment. Tech Tips (CV Boot Leaking Grease, Clamp Not Tight or Not Aligned Properly): The document informs on what to do if the vehicles CV Boot is having issues
• 10069138Mar 14, 2014Equipment. Summary to be provided on a future date.
• 10253214Mar 8, 2014Other or unknown, Exterior lighting. Exterior Lights, Moisture Accumulation
• 10239817Mar 7, 2014Electrical system. MIL ON, No Start, or Rough Running with DTCs P0087, P0088 or P0191 Stored in ECM Fault Memory (TDI ONLY)
• 10055769Mar 7, 2014Fuel system. When diagnosing the condition on rail diesel vehicles if no cause is found it may be necessary to check for particles in the pump.
• 10239591Mar 6, 2014Exterior lighting. Exterior Lights, Moisture Accumulation
• 10124287Mar 6, 2014Exterior lighting. Technical Bulletin (Exterior Lights, Moisture Accumulation): Exterior light assemblies (headlights, taillights, fog lights, turn signals) are vented and may collect moisture on their inner surfaces, depending on humidity and other climatic changes. This document discusses necessary to diagnosis, and potential remedy of the issue.
• 10238060Mar 4, 2014Body and structure. CV boot damage identified.
• 10124293Mar 4, 2014Equipment. Technical Bulletin (CV Boot Replacement): Recommended procedure for removing damaged CV boot. This document informs of the expected condition of a CV boot upon removal
• 10243008Mar 3, 2014Engine cooling, Electrical system. VW Elsa Newsletter
• 10253191Feb 25, 2014Electrical system, Other or unknown. RNS 315 Navigation Radio Software Update for Locking, Rebooting, Switches Off at Random
• 10241264Feb 25, 2014Engine cooling, Fuel system. Fuel Additive to Help Prevent Sporadic Misfire Faults
• 10239568Feb 25, 2014Electrical system, Equipment. RNS 315 Navigation Radio Software Update for Locking, Rebooting, Switches Off at Random
• 10239202Feb 25, 2014Other or unknown. Quick Reference Update Guide
• 10238034Feb 19, 2014Equipment, Steering. Insufficient Steering Assistance- Warning Light ON
• 10252937Feb 14, 2014Electrical system. Vehicles equipped with Immobilizer 4 (Download) ? Adapting Keys after Vehicle Lock Set Replacement
• 10237761Feb 14, 2014Electrical system, Equipment. When replacing the complete vehicle lock set (all vehicle keys and lock cylinders) for any reason, be aware that the ?Adapt keys? test plan will not allow the new keys to adapt to the vehicle. Instead, perform the test plan for ?New identity?. During this test plan, make the appropriate selection to indicate only the lock set has been replaced, as shown below in figures 1 and 2.
• 10238022Feb 7, 2014Brakes. Brake Disc Pulsation or Vibration
• 10239583Feb 4, 2014Visibility (wipers, defrost, mirrors). Wiper Motor Noisy or Inoperative
• 10238021Jan 29, 2014Brakes. Vibration or noise when braking may be due to brake disc corrosion protection which has not been completely removed by normal braking, or surface rust built up during transportation.
• 10122248Jan 29, 2014Brakes. Technical Bulletin (Vibration or Noise When Braking): Vibration or noise when braking may be due to brake disc corrosion protection which has not been completely removed by normal braking, or surface rust built up during transportation. This document informs that vehicles requiring front, rear, or both disc cleaning will exhibit vibration and/or noise. This document discusses the "Fault Codes" necessary to…
• 10243002Jan 27, 2014Visibility (wipers, defrost, mirrors), Tires, Exterior lighting. VW Elsa Newsletter
• 10242340Jan 27, 2014Equipment. VW Elsa Newsletter
• 10241265Jan 27, 2014Engine cooling, Fuel system. Fuel Additive to Help Prevent Sporadic Misfire Faults
• 10127719Jan 27, 2014Transmission and drivetrain. On-car analysis list of Customer Complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex)
• 10239789Jan 24, 2014Electrical system, Visibility (wipers, defrost, mirrors), Other or unknown. To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. The check must be performed with the engine running and heated rear window switched on. Switch OFF the ignition and visually locate the damage. Proceed with checking any other lines as necessary. Once the damaged line is identified, repair utilizing the Repair kit by Permatex® ITEM…
• 10238937Jan 24, 2014Transmission and drivetrain, Engine cooling. Install a vacuum gauge on the dipstick tube and check crankcase vacuum at idle. Compare to a known good vehicle. If the vacuum reading is lower than the comparison vehicle, visually inspect for oil leaks between the engine and the transmission. Smoke test the crankcase by connecting the EVAP smoke machine to the dipstick tube and inspect for leaks at the rear main seal (this will limit pressure to 2 PSI). DO NOT…
• 10122240Jan 24, 2014Visibility (wipers, defrost, mirrors). Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. This document informs of how to diagnose the issue and tips on servicing the issue
• 10122237Jan 24, 2014Equipment, Fuel system. Tech Tips (Lean Fuel Trim Readings): This document informs on the procedure to diagnose for issues with excess fuel trim, and what needs to be serviced
• 10121563Jan 24, 2014Transmission and drivetrain. Tech Tips (Lean Fuel Trim Readings): This document informs to recheck the crankcase vacuum at idle. If low, check for additional oil leaks and verify crankcase breather operation (repairing as necessary). Erase the faults and road test 10 miles to recheck operation.
• 10243001Jan 20, 2014Steering, Engine cooling. VW Elsa Newsletter
• 10242339Jan 20, 2014Equipment. VW Elsa Newsletter
• 10239788Jan 17, 2014Visibility (wipers, defrost, mirrors). If stains or marks are noted on the rear glass during PDI, they can be polished out. Utilize a quality glass polish, which contains cerium oxide (e.g. 3M Glass Polishing Compound, part number 60150) to clean the glass and remove stains. This will need to be obtained through a vendor, as it is not available through VW.
• 10238014Jan 17, 2014Tires. The tire pressure warning indicator illuminates indicating a fault in the Tire Pressure Monitoring System (TPMS) module.
• 10122247Jan 17, 2014Tires. Technical Bulletin (Tire Pressure Monitor Warning Indicator ON): The tire pressure warning indicator illuminates indicating a fault in the Tire Pressure Monitoring System (TPMS) module. The product solution for this issue is new sensors that are in production as of AN_DE510569. This document discusses the "Fault Codes" necessary to diagnosis, and potential remedy of the issue. The fault codes for checking warranty…
• 10122239Jan 17, 2014Equipment. Tech Tips (Staining on rear glass found during PDI): If stains or marks are noted on the rear glass during PDI, they can be polished out. This document informs on what the kind of polish that can be used
• 10069686Jan 17, 2014Electrical system. Summary to be provided on a future date.

← All problems reported for the 2013 Volkswagen CC