2015 Volkswagen CC Technical Service Bulletins

709 technical service bulletins (TSBs) are on record for the 2015 Volkswagen CC. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10152543Aug 25, 2015Brakes, Equipment, Interior lighting, Back-over prevention (rear camera). On-car analysis list from August 25th, 2015
• 10144694Aug 14, 2015Equipment. On-car analysis list of Customer Complaints: Customer states the oil light is on
• 10123098Aug 14, 2015Equipment. Technical Bulletin (CV Boot Replacement): The Recommended procedure for removing damaged CV boot.
• 10144695Aug 10, 2015Equipment. On-car analysis list of Customer Complaints: Customer states the oil light is on
• 10123105Aug 7, 2015Equipment. Technical Bulletin: Listed in the table in this document are the time units used in the calculation of the Prepaid PDI (PPDI) payment through model year 2016.
• 10123097Aug 7, 2015Brakes. Technical Bulletin (Vibration or Noise When Braking): Vibration or noise when braking may be due to brake disc corrosion protection which has not been completely removed by normal braking or surface rust built up during transportation. This document contains the method to diagnose, and to service this issue
• 10123096Aug 7, 2015Steering, Brakes. Technical Bulletin (Brake Disc Pulsation or Vibration issues): When applying brakes at highway speeds the following symptoms may occur: - Brake pedal pulsation - Vibration felt in vehicle body - Steering wheel shakes For brake vibration or pulsation concerns, brake disc machining is allowed. This document contains the fault codes to diagnose and service this issue. It also contains fault codes to inquire if the…
• 10144696Aug 6, 2015Equipment. On-car analysis list of Customer Complaints: Customer states the oil light is on
• 10144697Aug 3, 2015Equipment. On-car analysis list of Customer Complaints: Customer states the oil light is on
• 10128133Jul 31, 2015Interior lighting, Engine, Transmission and drivetrain, Body and structure…. On-car analysis list of Customer Complaints: Customer states the oil light is on
• 10123029Jul 28, 2015Fuel system, Engine, Electrical system. Technical Bulletin: High Pressure Fuel Pump Diagnosis. Completing the GFF high pressure pump function test is essential to diagnose proper pump operation and to avoid unnecessary replacements. This document contains the procedure to update the programming on the diagnostic hardware. This document contains the fault codes necessary to check the warranty coverage for servicing this issue.
• 10144709Jul 27, 2015Equipment. On-car analysis list of Customer Complaints: Customer states the oil light is on
• 10123011Jul 22, 2015Visibility (wipers, defrost, mirrors). Technical Bulletin (Windshield Wipers Streak or Smear): Windshield or rear window is streaked, has a snakeskin appearance, or the surface feels rough. To avoid unnecessary replacement of wiper blades, the condition and cleanliness of the windshield, rear window and wiper blades, should be checked first. This document contains information on how to diagnose, and service this issue.
• 10144692Jul 17, 2015Equipment. On-car analysis of Customer Complaints: Customer states the oil light is on
• 10144691Jul 15, 2015Equipment. On-car analysis list Customer Complaint: Mil?on with fault code P046C, untouched vehicles
• 10123024Jul 14, 2015Steering. Technical Bulletin (Electro-mechanical Steering Noise): In connection with the toothed belt the motor of the APA steering makes noise during operation. In some situations the noise can be heard in the passenger compartment. This document contains information on how to diagnose, and service this issue.
• 10144708Jul 13, 2015Equipment. On-car analysis list of Customer Complaint: Mil-on with fault code P046C, untouched vehicles
• 10123038Jul 10, 2015Electrical system. Tech Tips (Instrument Cluster Production Mode): This document informs the procedure to remove the production mode setting when it is displayed in the instrument cluster.
• 10123015Jul 7, 2015Engine cooling, Equipment. Technical Bulletin (Air Conditioning, Cleaning of the Refrigerant Circuit (U.S.Only)): In cases where an air conditioning system component (such as a compressor or other system component) has failed and debris from the compressor or component is circulated throughout the refrigerant circuit, the refrigerant circuit must be cleaned of any and all debris or damage to the replacement components will result. This…
• 10123013Jul 7, 2015Engine cooling, Equipment. Technical Bulletin (HVAC, Unpleasant Odor): Unpleasant odor is coming from Heating and Ventilation system. Odor mainly occurs after vehicle has been sitting (unused) at least 5 hours and within 20 to 60 seconds after vehicle is first started. This document contains information on how to diagnose, and service this issue.
• 10128105Jun 29, 2015Equipment. This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, technical bulletins, pending service solutions, tech tips, campaigns, updates, and suggestions.
• 10128104Jun 22, 2015Equipment. This document contains the VW Elsa Newsletter that contains a general overview of wiring diagrams updates, ElsaPro infomedia icons grayed out, workshop equipment tool storage application, technical bulletins, pending service solutions, tech tips, campaigns, updates, and suggestions.
• 10122981Jun 19, 2015Transmission and drivetrain, Engine cooling. Tech Tips: The document discusses the conditions of when turbo can to be fixed or replaced
• 10122980Jun 19, 2015Engine cooling. Tech Tips (Coolant Leak or Repeat Coolant Leak from the Water Pump Area): The document informs to inspect for issues, and why issues may happen. It also notes how to fix the issue, and other issues that could happen while repairing the issue
• 10122985Jun 12, 2015Transmission and drivetrain, Engine. Tech Tips (No Crank, No Start After Cold Soak issues): Concern may be the result of a leaking vacuum check valve not holding residual pressure overnight. This results in a hard brake pedal that may require more pressure than usual to allow the vehicle to crank.
• 10122987Jun 5, 2015Body and structure, Equipment. Technical Bulletin (Paint Defect - Water Migration Under the RAPGARD): Water migration under the RAPGARD® can be mistaken as a paint defect when in fact it is only moisture trapped in the clear coat of the paint. This document discusses. - RAPGARD, removal and disposal - Inspecting for water migration in areas where RAPGARD was removed. - Examples of water migration after the RAPGARD is removed
• 10122943May 26, 2015Visibility (wipers, defrost, mirrors). Technical Bulletin (Sunroof or Power Sunshade, Does Not Open/Close or Automatic Operation Does Not Function). This document contains Warranty information for coverage, and informs of methods to to service the issue
• 10122953May 21, 2015Equipment, Body and structure. Technical Bulletin (PDI - Vehicle Inspection, Protection Removal and Detailing): This document refers to a pre check inspection on the quality of a vehicle such as - Inspecting vehicle for damage (to be completed within 48 hours of delivery to Dealership) - Shipping damage - Detailers responsibilities (to be completed prior to delivery to Customer) - Full Body Covers (FBC), removal and disposal - RAPGARD, removal…
• 10128093May 8, 2015Electrical system. Tech Tips: Car Net Equipped Vehicles False Outbound Call issues
• 10122956May 8, 2015Visibility (wipers, defrost, mirrors), Electrical system. Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. The check must be performed with the engine running and heated rear window switched on. Switch OFF the ignition and visually locate the damage.
• 10122947May 6, 2015Steering. Technical Bulletin (Squeaking Noises From Front Of Vehicle): Squeaking/creaking noise from front of vehicle while fully turning steering wheel. The document also gives information on servicing the issue
• 10128094May 1, 2015Electrical system. Tech Tips: Car Net Equipped Vehicles False Outbound Call issues
• 10122924Apr 24, 2015Equipment. Tech Tips: Car Net Equipped Vehicles-Vehicle Health Report Received by Customer Indicating a Concern, but Cannot Verify any Conditions or DTC?s to Facilitate Diagnosis
• 10122905Apr 14, 2015Equipment. Technical Bulletin: This document refers to the software update for RNS 510 Welcome Screen Image Distorted. This procedure corrects the concerns listed above by updating the RNS 510 to the latest software 5382
• 10122925Apr 10, 2015Equipment. Tech Tips: Vehicle Health Report Received by Customer Indicating a Concern, but Cannot Verify any Conditions or DTC?s to Facilitate Diagnosis
• 10122919Apr 10, 2015Fuel system, Electrical system, Engine. Technical Bulletin (High Pressure Fuel Pump Diagnosis): Completing the GFF high pressure pump function test is essential to diagnose proper pump operation and to avoid unnecessary replacements
• 10122929Apr 3, 2015Suspension, Wheels. Tech Tips: This Tech Tip provides an overview of vehicle four wheel alignment, and important steps that should be followed when performing four wheel alignments
• 10122928Apr 3, 2015Steering. Tech Tips: This Tech Tip was established to explain the influence the adjustable steering column tilt position has on the steering wheel being off center and to provide information on checking for steering wheel off center
• 10121257Mar 27, 2015Exterior lighting, Equipment. Technical Bulletin: Condensation and or water droplets becomming visible on inside of exterior light lenses issue is discussed in this document
• 10121274Mar 19, 2015Equipment. Technical Bulletin: A notification that Components may be missing from the by-pack at delivery. It also informs that Components missing from the by-pack should be claimed in one of two ways. (Warranty or Transportation)
• 10121264Mar 19, 2015Brakes. Technical Bulletin: Vibration or Noise When Braking issues are addressed
• 10121278Mar 13, 2015Equipment. Tech Tips (Test Plan to Calibrate Adaptive Cruise Control Sensors Will Not Begin notice): Notification that If the test plan to calibrate the Adaptive Cruise Control Sensors will not begin, turn off the overhead lights in the shop. The wavelengths of some shop lighting interfere with the sensors during calibration.
• 10121265Mar 12, 2015Electrical system. Technical Bulletin: Battery, Discharged, Diagnosis for Excessive Static Current Draw
• 10121262Mar 11, 2015Equipment. Technical Bulletin: Diagnosing with Damage on External Chrome or Aluminum Surfaces
• 10121266Mar 5, 2015Electrical system. Technical Bulletin: The document refers to diagnosing charging systems for issues
• 10121184Feb 23, 2015Equipment. Technical Bulletin: This document concerns the sensitivity of the washer solvent level sensor (G33) can be affected by the type, concentration, and the presence of additives in the washer solvent currently in the tank. The operation of the level sensor relies on the composition of the solvent to provide an accurate message on the solvent level. Incorrect concentration and the presence of additives can contaminate…
• 10121213Feb 20, 2015Equipment. Tech Tips: RNS-510 Radio?Unit Start-Up and Boot-Up Operation issues
• 10121192Feb 20, 2015Engine cooling. Tech Tips: Generator Charging Concern Diagnosis Tip - One Way Clutch Pulley Testing
• 10121196Feb 16, 2015Electrical system. Technical Bulletin: Battery, Testing and Charging Using Midtronics VAS6161, MCR340V, InCharge 940, or GRX3000VAS Charger
• 10121197Feb 13, 2015Equipment. Technical Bulletin: The document discusses proper engine oil level diagnosis and servicing issues

← All problems reported for the 2015 Volkswagen CC