2005 Volkswagen Jetta Recalls

NHTSA lists 4 recall campaigns for the 2005 Volkswagen Jetta. A recall applies only to vehicles built within the affected range, so check your own VIN at nhtsa.gov/recalls. Repairs for recalls are free at a franchised dealer.

• 07V442000Sep 24, 2007340,000 vehicles potentially affected
  Exterior lighting › Headlights
  Covers: Volkswagen Jetta 2005–2008, GTI 2006–2008, Rabbit 2006–2008 +1 more

  Reported issue: Certain vehicles fail to comply with the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." some vehicles may not have had a required cap installed which disables the headlight horizontal aim and some vehicles may contain a cap that disables the vertical aiming screw.

  Possible consequence: Noncompliance can inhibit proper headlamp aim adjustment for roadway illumination, improperly aimed headlamps could cause reduced road visibility, increasing the risk of a crash.

  Remedy: Dealers will inspect for the presence of a cap in the socket of the low beam horizontal aiming screw and install one if missing, and inspect for the presence of a cap in the socket of the vertical aiming screw and if present, the cap will be removed. The recall will begin on october 31, 2007. Owners may contact vw at…

  Full campaign details →

• 07V063000Feb 20, 20071,002,000 vehicles potentially affected
  Exterior lighting › Brake lights › Switch
  Covers: Volkswagen Jetta 2001–2005, Golf 1999–2006, GTI 1999–2006 +3 more

  Reported issue: On certain passenger, wagon, and convertible vehicles equipped with or without cruise control, a brake light switch may malfunction if it was installed incorrectly.

  Possible consequence: The brake lights could become inoperative, or remain on. Failure to provide the proper signal when braking could lead to a crash without warning.

  Remedy: Dealers will install the newly designed brake light switch free of charge. The recall began on april 27, 2007, and will be conducted in several staggered mailings through september 21, 2007. Vehicles within the make, model, and model year of this population may be involved in either this recall or 06v-183, but not…

  Full campaign details →

• 05V305000Jul 5, 200539,583 vehicles potentially affected
  Fuel system, gasoline › Delivery › Hoses, lines/piping, and fittings
  Covers: Volkswagen Jetta 2005

  Reported issue: On certain passenger vehicles equipped with a 2.5l gasoline engine, a fuel supply line clamp located in the engine compartment may not be positioned properly and could cause a fuel leak.

  Possible consequence: Fuel leakage, in the presence of an ignition source, could result in a fire.

  Remedy: Dealers will inspect the position of the engine compartment fuel supply line clamp and, if necessary, replace the clamp. The recall began on july 11, 2005. Owners may contact vw at 1-800-822-8987.

  Full campaign details →

• 04V586000Dec 15, 200419,284 vehicles potentially affected
  Fuel system, diesel
  Covers: Volkswagen Jetta 2004–2005, Passat 2004–2005, Golf 2004–2005 +1 more

  Reported issue: On certain passenger vehicles, the high pressure diesel pumps were produced with an improper fastener, which could allow diesel fuel to escape from the pump.

  Possible consequence: Fuel leakage in the presence of an ignition source may lead to a fire.

  Remedy: Dealers will replace the diesel pump. The recall began on february 8, 2005. Owners should contact volkswagen at 1-800-822-8987.

  Full campaign details →

← All problems reported for the 2005 Volkswagen Jetta