2006 Volkswagen Jetta Recalls
NHTSA lists 4 recall campaigns for the 2006 Volkswagen Jetta. A recall applies only to vehicles built within the affected range, so check your own VIN at nhtsa.gov/recalls. Repairs for recalls are free at a franchised dealer.
- Fuel system, gasoline › Delivery › Hoses, lines/piping, and fittingsCovers: Volkswagen Jetta 2006–2010, Beetle 2006–2010, Rabbit 2007–2009
Reported issue: Volkswagen is recalling certain model year 2006-2010 jetta, new beetle, new beetle convertible, model year 2009 jetta sportwagen and model year 2007-2009 rabbit vehicles equipped with 2.5l engines. The jetta, jetta sportwagen, and rabbit vehicles may have a small plastic tab located on the windshield washer fluid reservoir that may chafe against an underhood fuel supply line. The new beetle and the new beetle…
Possible consequence: If chafing occurs, there is the potential for a fuel leak to develop. Fuel leakage, in the presence of an ignition source, could result in a fire.
Remedy: Dealers will inspect and if necessary replace the underhood fuel line. Additionally, depending on the vehicle model, dealers will either remove the plastic tab from the windshield washer fluid reservoir, or inspect the position of the fastening clamp and adjust the related fastening clamp into the correct position…
- Power train › Driveline › DriveshaftCovers: Volkswagen Jetta 2006–2009
Reported issue: Volkswagen is recalling 25,594 my 2006-2009 jetta 5th generation equipped with 2.01 engine. The fastening screw contact surfaces on the driveshaft cover plate may not have been manufactured to factory specifications. Some screws may not have been torqued properly during assembly and could loosen over time, causing a knocking sound when the vehicle is in motion. The driveshaft screws could loosen to the point where…
Possible consequence: If the vehicle is moving when this happens, the detached driveshaft could cause damage the gearbox housing. A damage gearbox housing could leak gearbox oil onto the street and create a risk of a vehicle crash for both the driver and other motorists.
Remedy: Dealers will inspect the driveshaft screws and replace the screws free of charge. The recall began on june 24, 2009. Owners may contact volkswagen at 1-800-822-8987.
- Exterior lighting › HeadlightsCovers: Volkswagen Jetta 2005–2008, GTI 2006–2008, Rabbit 2006–2008 +1 more
Reported issue: Certain vehicles fail to comply with the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." some vehicles may not have had a required cap installed which disables the headlight horizontal aim and some vehicles may contain a cap that disables the vertical aiming screw.
Possible consequence: Noncompliance can inhibit proper headlamp aim adjustment for roadway illumination, improperly aimed headlamps could cause reduced road visibility, increasing the risk of a crash.
Remedy: Dealers will inspect for the presence of a cap in the socket of the low beam horizontal aiming screw and install one if missing, and inspect for the presence of a cap in the socket of the vertical aiming screw and if present, the cap will be removed. The recall will begin on october 31, 2007. Owners may contact vw at…
- Visibility › Windshield wiper/washerCovers: Volkswagen Jetta 2006
Reported issue: Certain vehicles equipped with 2.5l gasoline engines may have a small plastic tab located on the windshield washer fluid reservoir that may chafe against the underhood fuel supply line.
Possible consequence: If this happens, the chafing has the potential to cause a fuel leak over time. Fuel leakage in the presence of an ignition source could result in a fire.
Remedy: Dealers will remove the plastic tab from the windshield washer fluid reservoir and will also inspect and, if necessary, replace the underhood fuel supply line. The recall began on august 24, 2007. Owners may contact vw at 1-800-893-5298.
← All problems reported for the 2006 Volkswagen Jetta
About this data. Data from NHTSA (ODI) complaints, recalls, TSBs and investigations, updated Oct 31, 2026. Complaints are unverified consumer reports and may be duplicated or inaccurate.