2009 Volkswagen Jetta Technical Service Bulletins

1,058 technical service bulletins (TSBs) are on record for the 2009 Volkswagen Jetta. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10157286Sep 1, 2017Engine cooling. 2.0L TDI Engine (GEN 1) Emissions Modification ? Customer Only (Retail Sold) USA ONLY - The Environmental Protection Agency and California Air Resources Board have determined that Volkswagen vehicles equipped with a 2.0L 4-cylinder TDI engine do not comply with applicable emissions regulations. The emissions control systems on the vehicles will not control emissions under off-cycle conditions as effectively as…
• 10144707Aug 25, 2017Engine cooling. This special notice is to inform dealers to return all part numbers listed in the document. Only superseded part numbers to be ordered going forward.
• 10125690Aug 24, 2017Engine cooling. 2.0L TDI Engine (GEN 1) Emissions Modification - Customer Only (Retail Sold) USA ONLY - The Environmental Protection Agency and California Air Resources Board have determined that Volkswagen vehicles equipped with a 2.0L 4-cylinder TDI engine do not comply with applicable emissions regulations. The emissions control systems on the vehicles will not control emissions under off-cycle conditions as effectively as…
• 10125654Aug 23, 2017Engine cooling. VSS 17-08 - TDI Monitoring Program - Campaigns 23Q3/23U4/23U3 2.0L Emissions Modification - Gen I, Gen II and Gen III.
• 10125691Aug 22, 2017Engine cooling. 2.0L TDI Engine (GEN 1) Emissions Modification - Customer Only (Retail Sold) USA ONLY - The Environmental Protection Agency and California Air Resources Board have determined that Volkswagen vehicles equipped with a 2.0L 4-cylinder TDI engine do not comply with applicable emissions regulations. The emissions control systems on the vehicles will not control emissions under off-cycle conditions as effectively as…
• 10126782Aug 21, 2017Equipment. e-mail TDI ODIS AEM Update.
• 10125662Aug 21, 2017Electrical system. Precautionary steps to Error Code ERP0203E when performing campaign 23U3.
• 10144706Aug 18, 2017Engine cooling. This special notice is to inform dealers to return all part numbers listed in the document. Only superseded part numbers to be ordered going forward.
• 10125664Aug 18, 2017Equipment. Tip to reinforce dealer scan tool update importance in regards to 24CV campaign.
• 10125663Aug 18, 2017Fuel system. Update to expand fuel testing for lean DTCS.
• 10125661Aug 18, 2017Equipment. Update to existing tip for fuel quality checking.
• 10125682Aug 16, 2017Electrical system. Download ODIS Service Diagnostic Version for 24CV recall.
• 10125685Aug 15, 2017Engine cooling. Inlet Air Box Housing Snow Flap Replacement & Oxygen Sensor Inspection/Replacement. The snow flap in the inlet air box housing may remain partially to fully open. Should this occur, excess warm air could enter the air intake through the snow flap inlet. The oxygen sensor will be checked during this service and, if measured degradation tolerances are met, the sensor will be replaced. Updated work procedure and…
• 10125657Aug 15, 2017Equipment. Updated to include an additional diagnostic trouble code (P04F0)
• 10125692Aug 14, 2017Engine cooling. 2.0L TDI Engine (GEN 1) Emissions Modification - Customer Only (Retail Sold) USA ONLY - The Environmental Protection Agency and California Air Resources Board have determined that Volkswagen vehicles equipped with a 2.0L 4-cylinder TDI engine do not comply with applicable emissions regulations. The emissions control systems on the vehicles will not control emissions under off-cycle conditions as effectively as…
• 10125686Aug 14, 2017Engine cooling. Inlet Air Box Housing Snow Flap Replacement & Oxygen Sensor Inspection/Replacement. The snow flap in the inlet air box housing may remain partially to fully open. Should this occur, excess warm air could enter the air intake through the snow flap inlet. The oxygen sensor will be checked during this service and, if measured degradation tolerances are met, the sensor will be replaced. Updated measuring value range…
• 10125693Aug 11, 2017Engine cooling. 2.0L TDI Engine (GEN 1) Emissions Modification - Customer Only (Retail Sold) USA ONLY - The Environmental Protection Agency and California Air Resources Board have determined that Volkswagen vehicles equipped with a 2.0L 4-cylinder TDI engine do not comply with applicable emissions regulations. The emissions control systems on the vehicles will not control emissions under off-cycle conditions as effectively as…
• 10125687Aug 11, 2017Engine cooling. Inlet Air Box Housing Snow Flap Replacement & Oxygen Sensor Inspection/Replacement. The snow flap in the inlet air box housing may remain partially to fully open. Should this occur, excess warm air could enter the air intake through the snow flap inlet. The oxygen sensor will be checked during this service and, if measured degradation tolerances are met, the sensor will be replaced.
• 10125684Aug 10, 2017Engine cooling. Inlet Air Box Housing Snow Flap Replacement & Oxygen Sensor Inspection/Replacement. The snow flap in the inlet air box housing may remain partially to fully open. Should this occur, excess warm air could enter the air intake through the snow flap inlet. The oxygen sensor will be checked during this service and, if measured degradation tolerances are met, the sensor will be replaced.
• 10125655Aug 10, 2017Suspension. Notification of the 2.0l Gen 1, TDI remediation fix monitoring via the VTA system, in alignment with campaigns 23U3.
• 10125667Aug 7, 2017Equipment. Update information regarding Top Tier brochure.
• 10157818Aug 4, 2017Equipment. The 2.0L Gen1 FAQ document is to assisty our VWGoA dealers with frequently asked questions and answers to allow them to assist the VW & Audi owners.
• 10157292Aug 4, 2017Equipment. The 2.0L Gen1 FAQ document is to assist our VWGoA dealers with frequently asked questions and answers to allow them to assist the VW & Audi owners.
• 10125659Aug 4, 2017Engine cooling. Tips to address specific DTCs that can result from an exhaust leak.
• 10127807Jul 18, 2017Engine cooling. Metadata adjustment. TB appeared with tech tips in Elsa.
• 10127899Jul 13, 2017Engine. Update TB to include model year 2017 and include additional engine applicability.
• 10133347Jul 7, 2017Engine cooling. Update Tiguan oil pan labor operation number in warranty table.
• 10133344Jul 5, 2017Engine cooling. 17 17 01 July 5, 2017 2012855 Supersedes Technical Bulletin 17-16-02 (V171602) dated April 29, 2016 due to updated oil standards lists to current specifications. Engine Oils Which Meet Volkswagen Oil Quality Standards
• 10158549Jun 29, 2017Engine cooling, Fuel system. Installation Instruction for fresh air line during CCTA Intake Manifold Replacement
• 10158548Jun 29, 2017Engine cooling. Supersedes Technical Bulletin 24-17 03 (V241703) dated March 6, 2017 for information regarding a new style solenoid valve for Intake Manifold Flap
• 10158542Jun 29, 2017Engine cooling. Ensure correct intake manifold is installed on engine, refer to ETKA.
• 10158499Jun 29, 2017Engine, Equipment. Information only. Replacement intake manifolds for CCTA engines have an improved intake manifold flap valve -N316.The new -N316- valve has 3 hose ports rather than 2 (See Figure 1), requiring a fresh air line be installed during intake manifold replacement. This fresh air line will prevent dirt and debris from contaminating the -N316- solenoid.
• 10157382Jun 29, 2017Brakes. To update required parts table and add additional note requiring Guided Fault Finding log upload.
• 10155800Jun 29, 2017Equipment. To update required parts table and add additional note requiring Guided Fault Finding log upload.
• 10155644Jun 28, 2017Equipment. This special notice is to inform dealers to return all part numbers listed in the document and order the superseded part numbers going forward.
• 10157383Jun 22, 2017Equipment. VAS 6154 Replacement Part Setup Guide
• 10157381Jun 19, 2017Electrical system. Update vehicle metadata for 2009 pull ahead.
• 10155799Jun 19, 2017Fuel system. Update vehicle metadata for 2009 pull ahead.
• 10158547Jun 15, 2017Fuel system. Update vehicle metadata for 2009 pull ahead.
• 10157380Jun 15, 2017Fuel system. Update vehicle metadata for 2009 pull ahead.
• 10157280Jun 15, 2017Electrical system, Equipment. Update vehicle metadata for 2009 pull ahead.
• 10125599May 26, 2017Equipment. Update to existing article that addressed additional diagnostics for lean running concerns.
• 10125585May 10, 2017Equipment. This special notice is to inform dealers to return all mechatronic 02E325025ADZD1 and order 02E325025ADZE0 going forward.
• 10120085Apr 21, 2017Body and structure, Engine cooling, Transmission and drivetrain. Directions to inspect the engine mount for debris, including stones, that may cause powertrain vibration when vehicle transmission is in reverse.
• 10120094Apr 20, 2017Equipment, Brakes. To update brake bleed labor operation time units.
• 10120090Apr 13, 2017Fuel system. Update fuel sampling requirement.
• 10123168Mar 30, 2017Equipment. Idler roller for ribbed bely now available as a parts kit.
• 10123169Mar 21, 2017Electrical system. To update software version management (SVM) reflasg code.
• 10130748Mar 13, 2017Electrical system. Quick Reference of vehicle concerns. Includes a list of Software versions and the technical bulletin numbers that referred to the concerns Updated
• 10123172Mar 9, 2017Equipment. Update parts table.

← All problems reported for the 2009 Volkswagen Jetta