2011 Volkswagen Jetta Technical Service Bulletins

1,333 technical service bulletins (TSBs) are on record for the 2011 Volkswagen Jetta. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10241273Oct 15, 2014Body and structure. Removing Paint Contaminants from Exterior Paint
• 10121623Oct 15, 2014Body and structure, Equipment. Technical Bulletin (Removing Paint Contaminants from Exterior Paint): This document informs how to remove paint contaminants such as rail dust and industrial fallout from exterior paint.
• 10241330Oct 10, 2014Engine cooling. Camshaft Adjustment Valve 1 -N205- Diagnosis
• 10238621Oct 10, 2014Brakes, Wheels. Use the following procedure to diagnose active wheel speed sensor complaints:
• 10121621Oct 10, 2014Engine. Technical Bulletin (Camshaft Adjustment Valve 1 -N205- Diagnosis): Completing the GFF function test and performing basic settings on the camshaft adjustment valve are essential to diagnose proper operation and to avoid unnecessary replacements. The production solution to this issue was to optimized engine cleaning procedure in production.
• 10121536Oct 10, 2014Fuel system, Equipment. Tech Tips (ECM Fault P1250 "Fuel Level Too Low" Will Not Clear): This document informs to clear static ECM fault P1250 "Fuel Level Too Low", add fuel to vehicle and complete a road test of at least 10 miles. Simply adding fuel without completing a road test may not allow fault to clear.
• 10121291Oct 10, 2014Engine. Tech Tips (Common Rail TDI ? Fuel Filter Replacement and Prime/Bleed Procedure): This document informs when replacing fuel system components on the Common Rail TDI engine (including the fuel filter), the fuel system must be primed. The procedure should be available on most models through Guided Functions. If not shown, then access through Control Module OBD. Run ?Basic Settings block 35? three times in a row. This…
• 10121171Oct 10, 2014Wheels. Tech Tips (Active Wheel Speed Sensor Diagnosis): This document informs of a procedure to diagnose active wheel speed sensor complaints.
• 10121622Oct 6, 2014Electrical system, Engine. Technical Bulletin (Cylinder Contribution/Balance Faults): This document informs that the diagnostic strategy for zero fuel calibration too sensitive. The production solution for this issue was new Software implemented. This document discusses the "Fault Codes" necessary to diagnosis, and potential remedy of the issue. The fault codes for checking warranty coverage for servicing the vehicle are also available.
• 10238938Oct 3, 2014Engine cooling, Transmission and drivetrain. Install a vacuum gauge on the dipstick tube and check crankcase vacuum at idle. Compare to a known good vehicle. If the vacuum reading is lower than the comparison vehicle, visually inspect for oil leaks between the engine and the transmission. Smoke test the crankcase by connecting the EVAP smoke machine to the dipstick tube and inspect for leaks at the rear main seal (this will limit pressure to 2 PSI). DO NOT…
• 10121608Oct 3, 2014Visibility (wipers, defrost, mirrors), Electrical system. Tech Tips (Window Switch Replacement): Be advised that when replacing a window switch on the listed models, make certain that the switch is not damaged during the removal process. It is preferred to use a bone tool to remove the switch from the housing as opposed to a screwdriver. This document provides examples to prevent the risk of damage
• 10121607Oct 3, 2014Equipment. Tech Tips (RNS 510? Replacement Radio/Navigation Unit has no Sound): Replacement RNS 510 radio/navigation units may be shipped in transportation safeguard mode and therefore will have no sound output. This document informs how to deactivate the safeguard mode.
• 10069519Oct 3, 2014Equipment. Summary to be provided on a future date.
• 10243025Sep 29, 2014Equipment. VW Elsa Newsletter
• 10242363Sep 29, 2014Other or unknown. VW Elsa Newsletter
• 10238965Sep 26, 2014Steering, Electrical system, Transmission and drivetrain, Back-over prevention…. Some Golf, GTI, Jetta, and Passat vehicles equipped with electromechanical power steering have the G85 steering angle sensor located in the steering rack. These vehicles do not have a G85 in the steering column. To determine G85 location, check the J500 Power steering control module part number in the GFF printout. Do not use the part number on the steering rack for this check.
• 10120273Sep 26, 2014Transmission and drivetrain, Steering. Tech Tips (2009-2015 Jetta, Eos, Rabbit, Golf, GTI, Passat, CC, and Tiguan Equipped with Electromechanical Power Steering ? G85 Location Identification Tip): Ths document informs of the location of the G85 steering sensor. The sensors expected settings, and which vehicles do not have this sensor for electromechanical power steering.
• 10239807Sep 24, 2014Engine cooling. Engine will not start after standing in cold weather below 0°C (32°F), MIL may be illuminated with various induction and/or boost system faults stored in ECM.
• 10239541Sep 24, 2014Visibility (wipers, defrost, mirrors). Air Conditioning, Cleaning of the Refrigerant Circuit (U.S.Only)
• 10120324Sep 24, 2014Electrical system. Technical Bulletin (Glow Plug Pressure Sensor Faults): When diagnosing MIL ON with glow plug pressure sensor DTC?s it is important to perform a diagnosis prior to replacing the glow plug. This document contains the fault code interperatation after such a diagnosis. the production solution is that the codes were implementated into production. This document discusses the "Fault Codes" necessary to diagnosis, and…
• 10120316Sep 24, 2014Equipment. Technical Bulletin (Air Conditioning, Cleaning of the Refrigerant Circuit): In cases where an air conditioning system component (such as a compressor or other system component) has failed and debris from the compressor or component is circulated throughout the refrigerant circuit, the refrigerant circuit must be cleaned of any and all debris or damage to the replacement components will result. Debris can be…
• 10239593Sep 23, 2014Electrical system. Keyless Entry Inoperative after Access / Start (KESSY) Module Replacement
• 10243024Sep 22, 2014Equipment. VW Elsa Newsletter
• 10242362Sep 22, 2014Other or unknown. VW Elsa Newsletter
• 10239821Sep 22, 2014Electrical system. MIL ON, DTCs P2014 or P2015 Intake Manifold Faults Stored in ECM Fault Memory
• 10120326Sep 22, 2014Engine cooling. Technical Bulletin (Intake Manifold Faults Stored in ECM Fault Memory issues): This document informs of a failure of Intake manifold causing fault codes to be stored in the ECM. The production solution improved intake manifold design. This document discusses the "Fault Codes" necessary to diagnosis, and potential remedy of the issue. The fault codes for checking warranty coverage for servicing the vehicle are also…
• 10056164Sep 22, 2014Other or unknown, Equipment. Volkswagen: see document search button for owner letter. An extension warranty, with specific conditions, 10 yrs or 120,000 miles,whichever is first, has been issued for emissions control systems warranty for intake manifold and fuel injectors. Model 2008-2011.
• 10252208Sep 19, 2014Brakes. AC Compressor Replacement, Refrigerant Circuit Flushing Requirement
• 10239415Sep 19, 2014Latches, locks and linkages. Front Door Locks Hard to Release
• 10237705Sep 19, 2014Visibility (wipers, defrost, mirrors). When replacing the Air Conditioning compressor it is necessary to flush the entire system to remove all the PAG oil. Replacement AC compressors come with a full charge of oil. Any time another compressor is installed with a different vendor (Sanden to Denso) it is necessary to replace all the oil in the system to the new vendor type PAG oil.
• 10120317Sep 19, 2014Latches, locks and linkages. Technical Bulletin (Front Door Locks Hard to Release): The front door lock operation is affected by various climate or temperature conditions and as a result may require increased effort to release. Due to this the customer Customer may comment that the front door is hard to open with the exterior handle. This document discusses the "Fault Codes" necessary to diagnosis, and potential remedy of the issue. The fault…
• 10120272Sep 19, 2014Electrical system. Tech Tips (Comfort Module (J393) or BCM (J519) Replacement): This document informs if a comfort or body control module is replaced during normal diagnosis, make sure the factory mode has been switched OFF. This can be accomplished by selecting guided function of either the J393 or J519 or control module OBD of J393 or J519 then selecting adaptation channel 99.
• 10120271Sep 19, 2014Electrical system. Tech Tips (Window Switch Replacement): This document informs that Be advised that when replacing a window switch on the listed models, that the switch is not damaged during the removal process. It is preferred to use a bone tool to remove the switch from the housing as opposed to a screwdriver, to prevent the risk of the repair being debited. The document also contains visual examples which show the part in…
• 10120270Sep 19, 2014Equipment. Tech Tips (AC Compressor Replacement, Refrigerant Circuit Flushing Requirement): This document informs when replacing the Air Conditioning compressor it is necessary to flush the entire system to remove all the PAG oil. Replacement AC compressors come with a full charge of oil. Any time another compressor is installed with a different vendor (such as Sanden to Denso) it is necessary to replace all the oil in the…
• 10069518Sep 19, 2014Equipment. Summary to be provided on a future date.
• 10056454Sep 19, 2014Latches, locks and linkages. Volkswagen: the exterior handle on front door is very hard to open due to various climate or temperature conditions affecting the lock operation and may require more of an effort to release. Model 2011-2015 jetta (a6), golf/gti (a7), beetle, beetle convertible, passat nms.
• 10241324Sep 16, 2014Fuel system, Engine cooling. MIL ON, DTC P0401 Exhaust Gas Recirculation Flow Insufficient Stored in ECM Fault Memory, Could be accompanied with Fault P2463 DPF Soot Accumulation
• 10120330Sep 16, 2014Engine cooling. Technical Bulletin (Exhaust Gas Recirculation Flow Insufficient, and Soot Accumulation issues): This document informs of high soot loads prior to regeneration which can cause possible restrictions in the EGR filter. The production solution to this issue was new software being implemented in current production. This document discusses the "Fault Codes" necessary to diagnosis, and potential remedy of the issue.
• 10243023Sep 15, 2014Latches, locks and linkages, Electrical system, Steering. VW Elsa Newsletter
• 10242361Sep 15, 2014Other or unknown. VW Elsa Newsletter
• 10241322Sep 10, 2014Engine cooling. MIL ON, Cylinder Contribution/Balance Faults Stored in ECM Fault Memory P0263, P0266, P0269 and/or P0272
• 10239827Sep 10, 2014Electrical system. MIL ON, Secondary Air DTCs P2431, P2432, P2433 Stored in ECM Fault Memory
• 10239414Sep 10, 2014Latches, locks and linkages. Customer may comment that the front door is hard to open with exterior handle.
• 10120325Sep 10, 2014Brakes. Technical Bulletin (Secondary Air Injection System Air Flow/Pressure): This document informs the Secondary Air Pressure Sensor may be contaminated by foreign particles during secondary air injection. The production solution for this issue was a new sensor placed in production. This document discusses the "Fault Codes" necessary to diagnosis, and potential remedy of the issue. The fault codes for checking warranty…
• 10120318Sep 10, 2014Latches, locks and linkages. Technical Bulletin (Front Door Locks Hard to Release): This document informs the customer may comment that the front door is hard to open with exterior handle. This is due to the front door lock operation being affected by various climate or temperature conditions, and as a result may require increased effort to release. This document discusses the "Fault Codes" necessary to diagnosis, and potential remedy of the…
• 10120265Sep 10, 2014Electrical system. Technical Bulletin (Cylinder Contribution/Balance Faults): This document informs that the Diagnostic strategy for zero fuel calibration was too sensitive. The production solution for this issue was Software implemented into production. This document discusses the "Fault Codes" necessary to diagnosis, and potential remedy of the issue. The fault codes for checking warranty coverage for servicing the vehicle are also…
• 10239820Sep 8, 2014Electrical system. MIL ON, DTCs P2014 or P2015 Intake Manifold Faults Stored in ECM Fault Memory
• 10120327Sep 8, 2014Engine cooling. Technical Bulletin (Intake Manifold Fault issues): This document informs of Intake Manifold issues that are recognized in the ECM fault memory. The Production Solution to this issue was an improved intake manifold design. This document discusses the "Fault Codes" necessary to diagnosis, and potential remedy of the issue. The fault codes for checking warranty coverage for servicing the vehicle are also available.
• 10252942Sep 5, 2014Equipment. Damage to Data Link Connector (DLC) from Aftermarket Devices (Cannot Communicate with Vehicle OBD System)
• 10237766Sep 5, 2014Electrical system. The DLC is intended for use with diagnostic scan tools and by emissions testing stations. However, aftermarket devices (i.e., drive data recorders) that connect to the DLC have now become available.

← All problems reported for the 2011 Volkswagen Jetta