2002 Volkswagen Passat Wagon Technical Service Bulletins

111 technical service bulletins (TSBs) are on record for the 2002 Volkswagen Passat Wagon. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10239262Jul 10, 2013Equipment, Engine. In SAGA, the time units for the Volkswagen DoubleCheck labor operation were reduced in error from 50 time units to 30 time units during the system update posted on July 4th.
• 10241333Jul 1, 2013Engine cooling. Oil Consumption Measurement
• 10238960Apr 8, 2013Other or unknown, Engine cooling, Fuel system. To clear static ECM fault P1250 ?Fuel Level Too Low?, add fuel to vehicle and complete a road test of at least 10 miles. Simply adding fuel without completing a road test may not allow fault to clear.
• 10238959Apr 8, 2013Other or unknown, Engine cooling, Fuel system. To clear static ECM fault P1250 ?Fuel Level Too Low?, add fuel to vehicle and complete a road test of at least 10 miles. Simply adding fuel without completing a road test may not allow fault to clear.
• 10242399Mar 4, 2013Equipment, Fuel system, Body and structure, Electrical system. VW Elsa Newsletter
• 10239403Mar 1, 2013Electrical system. If key blade is found to stick or bind when opening or closing, check position of roll pin that secures key blade to mechanism. If roll pin is sticking out on either side (as shown below), do not replace key. Instead, use appropriate sized punch and hammer to drive in the roll pin so that it is flush with edge of mechanism.
• 10043602Feb 10, 2012Engine cooling. Volkswagen: gasoline engines have rough idle, have significant loss of power or stalling with reduced performance.
• 10253213Feb 14, 2011Exterior lighting, Other or unknown. Exterior Lights, Moisture Accumulation
• 10239590Feb 14, 2011Exterior lighting. Exterior Lights, Moisture Accumulation
• 10252204Jul 23, 2010Visibility (wipers, defrost, mirrors), Engine cooling. Air Conditioning Does not Operate
• 10237700Jul 23, 2010Electrical system, Brakes. For concerns of no or intermittent A/C operation where pressure diagnosis does not lead to a cause, be sure to check the N25 A/C clutch coil. The fan control module may send a brief voltage signal to the clutch and then shut it off due to an open or high resistance in the coil circuit. The coil resistance should be between 3.5 and 4.5 ohms. If the reading is high or low when checked at the fan module, be sure to…

← All problems reported for the 2002 Volkswagen Passat Wagon