2009 Volkswagen Passat Wagon Technical Service Bulletins

469 technical service bulletins (TSBs) are on record for the 2009 Volkswagen Passat Wagon. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10239403Mar 1, 2013Electrical system. If key blade is found to stick or bind when opening or closing, check position of roll pin that secures key blade to mechanism. If roll pin is sticking out on either side (as shown below), do not replace key. Instead, use appropriate sized punch and hammer to drive in the roll pin so that it is flush with edge of mechanism.
• 10125612Feb 22, 2013Electrical system. Technical Bulletin (Factory Installed Media-In (MDI), Updated Programming for Various iPod Concerns): The update programming procedure in this document addresses the following concerns: ? Music skips at beginning of track. This document discusses the "Fault Codes" necessary to diagnosis, and potential remedy of the issue. The fault codes for checking warranty coverage for servicing the vehicle are also available.
• 10125626Feb 1, 2013Electrical system. Tech Tips (Instrument Cluster Production Mode): During PDI, or after installation of a replacement cluster, ?Pro? may be displayed in place of the odometer. The high beam indicator may be flashing in the instrument cluster as well. This indicates the cluster is in Production mode. Production mode is not the same as ?Transport? mode. This document infroms of the difference between Production, and Transport mode.
• 10238941Jan 18, 2013Transmission and drivetrain, Engine cooling. When servicing the timing chain sprocket or removing the vibration damper, be aware that one bolt holds both the vibration damper (harmonic balancer) and the crankshaft timing chain sprocket to the crankshaft. Once the damper is removed, the crankshaft should not be rotated unless special tool spacer T10368 has been installed. The crankshaft timing chain sprocket and spur gear drive on the crankshaft have a…
• 10238940Jan 18, 2013Engine cooling, Transmission and drivetrain. CBFA 2.0T TSI Engine
• 10241263Jan 15, 2013Engine cooling, Fuel system. Fuel Additive to Help Prevent Sporadic Misfire Faults
• 10241351Jan 14, 2013Brakes, Fuel system. High Pressure Fuel Pump Diagnosis
• 10253203Nov 2, 2012Visibility (wipers, defrost, mirrors), Other or unknown. Wiper Blade Inspection for Proper Warranty Coding
• 10239580Nov 2, 2012Visibility (wipers, defrost, mirrors). Wiper Blade Inspection for Proper Warranty Coding
• 10253439Nov 1, 2012Equipment, Engine cooling. Volkswagen Carefree Maintenance Program ? Gasoline Engines (Except Routan) - REVISED
• 10157702Oct 12, 2012Latches, locks and linkages, Body and structure. Tech Tips (Rear Lid Will Not Power Close, No Faults Stored): This document informs when diagnosing a power rear lid that will power open but will not power close, check operation of luggage compartment lamp W3. Lamp should be on with rear lid open, and off with rear lid closed. If lamp is not on with rear lid open, disconnect lamp and attempt to power close rear lid. If rear lid closes with luggage compartment lamp…
• 10156118Oct 12, 2012Latches, locks and linkages, Body and structure. Tech Tips (Rear Lid Will Not Power Close, No Faults Stored): This document informs when diagnosing a power rear lid that will power open but will not power close, check operation of luggage compartment lamp W3. Lamp should be on with rear lid open, and off with rear lid closed. If lamp is not on with rear lid open, disconnect lamp and attempt to power close rear lid. If rear lid closes with luggage compartment lamp…
• 10157732Oct 1, 2012Electrical system. Body/Infotainment Module Software Updates: This document informs of various complaints that were addressed in software updates, and technical bulletins.
• 10156127Oct 1, 2012Equipment, Electrical system. Body/Infotainment Module Software Updates: This document informs of various complaints that were addressed in software updates, and technical bulletins.
• 10237724Oct 14, 2011Equipment. For concerns of navigation inaccuracy, with or without antenna fault codes, begin by checking the number of received satellites in the area of the concern. This can be accomplished by following the instruction in Technical Bulletin 2023490 Antenna Diagnosis Overview.
• 10253213Feb 14, 2011Exterior lighting, Other or unknown. Exterior Lights, Moisture Accumulation
• 10239590Feb 14, 2011Exterior lighting. Exterior Lights, Moisture Accumulation
• 10209347Mar 12, 2010Transmission and drivetrain. DTC P2711 Implausible transmission shift sequence.
• 10237716Nov 13, 2009Equipment. The streaming music feature on vehicles equipped with factory or dealer installed Bluetooth will be available only in certain instances. The vehicle must be equipped with the RCD 310 or RCD 510 (Premium 8) radios or the RNS 510 or RNS 315 navigation systems. The Bluetooth system must be either the UHV low (9W2), UHV?NAR (9W7 or 9ZR) factory installed systems or the Volk ? L dealer installed system.

← All problems reported for the 2009 Volkswagen Passat Wagon