2000 Volkswagen Passat Technical Service Bulletins

179 technical service bulletins (TSBs) are on record for the 2000 Volkswagen Passat. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10238959Apr 8, 2013Other or unknown, Engine cooling, Fuel system. To clear static ECM fault P1250 ?Fuel Level Too Low?, add fuel to vehicle and complete a road test of at least 10 miles. Simply adding fuel without completing a road test may not allow fault to clear.
• 10242399Mar 4, 2013Equipment, Fuel system, Body and structure, Electrical system. VW Elsa Newsletter
• 10239403Mar 1, 2013Electrical system. If key blade is found to stick or bind when opening or closing, check position of roll pin that secures key blade to mechanism. If roll pin is sticking out on either side (as shown below), do not replace key. Instead, use appropriate sized punch and hammer to drive in the roll pin so that it is flush with edge of mechanism.
• 10125635Feb 22, 2013Equipment. Tech Tips (Technician Helpline Vehicle Check Sheets): When it becomes necessary to open a VW Technician Helpline VTA case while performing diagnosis for a diesel particulate filter, manual transmission repair, or turbocharger concern, it is recommended to complete the related worksheet/check sheet before calling. This document informs where Worksheets/Check Sheets are available on ServiceNet.
• 10238620Dec 16, 2012Brakes. To code a Bosch 5.3 ABS control module, use Vehicle Self-diagnosis to enter the correct coding value from the tables below. Note that the first table is only applicable to 2.8L V6 equipped vehicles WITHOUT a CAN-Bus. All 1.8L Turbo vehicles and those 2.8L V6 vehicles that are equipped with a CAN-Bus should use the second table.
• 10157760Nov 16, 2012Brakes. Tech Tips (Bosch 5.3 ABS Control Module ? ABS Coding Tables): This document informs To code a Bosch 5.3 ABS control module, use Vehicle Self-diagnosis to enter the correct coding value from the tables in this document.
• 10156161Nov 16, 2012Brakes, Electrical system. Tech Tips (Bosch 5.3 ABS Control Module ? ABS Coding Tables): This document informs To code a Bosch 5.3 ABS control module, use Vehicle Self-diagnosis to enter the correct coding value from the tables in this document.
• 10070773Nov 16, 2012Brakes. Summary to be provided on a future date.
• 10051242Nov 16, 2012Brakes. Volkswagen: update to information. Providing correct coding values for abs control modules on certain vehicles without can-bus. Models 1998-2002 passat.
• 10157655Oct 25, 2012Body and structure, Equipment. Technical Bulletin (Paint Finish, Reducing Swirl Marks and Fine Scratches): New vehicles (prior to Retail Delivery) with swirl marks and or fine scratches from polishing or cleaning. This document informs of how the Finish can be significantly improved without the use of harsh polishing compounds and high speed buffing.
• 10156059Oct 25, 2012Equipment. Technical Bulletin (Paint Finish, Reducing Swirl Marks and Fine Scratches): New vehicles (prior to Retail Delivery) with swirl marks and or fine scratches from polishing or cleaning. This document informs of how the Finish can be significantly improved without the use of harsh polishing compounds and high speed buffing.
• 10157623Oct 5, 2012Electrical system, Fuel system. Tech Tips (Fuel Gauge Inoperative after Instrument Cluster Replacement with Fault 00771 ?Fuel level sensor -G-?): An inoperative fuel gauge after instrument cluster replacement with fault 00771 ?Fuel level sensor -G-? may be caused by gateway (address word 19) coding. This document informs of the procedure to resolve this concern
• 10156050Oct 5, 2012Fuel system. Tech Tips (Fuel Gauge Inoperative after Instrument Cluster Replacement with Fault 00771 ?Fuel level sensor -G-?): An inoperative fuel gauge after instrument cluster replacement with fault 00771 ?Fuel level sensor -G-? may be caused by gateway (address word 19) coding. This document informs of the procedure to resolve this concern
• 10073867Oct 5, 2012Fuel system. Summary to be provided on a future date.
• 10253213Feb 14, 2011Exterior lighting, Other or unknown. Exterior Lights, Moisture Accumulation
• 10239590Feb 14, 2011Exterior lighting. Exterior Lights, Moisture Accumulation
• 10252204Jul 23, 2010Visibility (wipers, defrost, mirrors), Engine cooling. Air Conditioning Does not Operate
• 10237700Jul 23, 2010Electrical system, Brakes. For concerns of no or intermittent A/C operation where pressure diagnosis does not lead to a cause, be sure to check the N25 A/C clutch coil. The fan control module may send a brief voltage signal to the clutch and then shut it off due to an open or high resistance in the coil circuit. The coil resistance should be between 3.5 and 4.5 ohms. If the reading is high or low when checked at the fan module, be sure to…
• 10124477Jul 23, 2010Equipment. Tech Tips (Air Conditioning Does not Operate): This document informs of concerns of no or intermittent A/C operation where pressure diagnosis does not lead to a cause, be sure to check the N25 A/C clutch coil. The fan control module may send a brief voltage signal to the clutch and then shut it off due to an open or high resistance in the coil circuit. The coil resistance should be between 3.5 and 4.5 ohms.
• 10030369May 18, 2009Engine cooling. Volkswagen: engine oil pressure too low, light is on, engine flush. The low engine oil pressure condition may be caused by a restriction of the oil pump suction line strainer.
• 10026848Aug 28, 2008Engine cooling, Body and structure. Volkswagen: exhaust heat shield, replacement guidelines. Heat shields are to be inspected after completion o any type of repair to the underbody (exhaust system transmission, etc.), and if damaged, replaced.
• 10021958May 24, 2007Visibility (wipers, defrost, mirrors). Intermittent windshield wiper, wipes across windshield once then stops.
• 10021437Mar 30, 2007Engine cooling. Engine oil pressure too low, light is on, engine flush.
• 10021315Jan 11, 2007Engine cooling. Dtc's p1297 (17705) or p1557 (17965) stored in dtc memory. This may be caused by intake hoses leaking (during boost conditions) due to incorrect torque on clamps or improper placement, worn or torn intake hoses.
• 10016097Jul 28, 2005Engine cooling. Update programming for catalytic converter system.
• 10016037Jul 14, 2005Brakes. Anti-lock brake system (abs) control module warranty repair process.
• 10012457Jan 14, 2005Electrical system. Diagnostic trouble code (dtc) p1603 (18011) stored in dtc memory.
• 10011593Dec 1, 2004Suspension. Check/replace front suspension lower control arms. *tc this supercedes the vm service action dated november 2004.
• 10011567Nov 9, 2004Engine cooling. Engine coolant temperature (ect) sensor.

← All problems reported for the 2000 Volkswagen Passat