2007 Volkswagen Passat Technical Service Bulletins

541 technical service bulletins (TSBs) are on record for the 2007 Volkswagen Passat. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10239590Feb 14, 2011Exterior lighting. Exterior Lights, Moisture Accumulation
• 10037805Dec 3, 2010Transmission and drivetrain. Volkswagen: warranty information for th e transmission valve body.
• 10036493Sep 30, 2010Other or unknown. Volkswagen: child restraint latch guidance fixture; compliance with fmvss 225 (usa only). Update to existing technical bulletin. No production change required. All models.
• 10036970Aug 1, 2010Transmission and drivetrain. Volkswagen service campaign: see document search button for owner letter. In some vehicles it is possible that a bushing inside the mechatronic unit has the potential to wear out prematurely, causing the clutches inside the transmission to operate less smoothly than before. The driver will begin to notice changes in the way the vehicle feels as the transmission shifts (jerking). This change can become very…
• 10036496Aug 1, 2010Electrical system, Engine cooling. Volkswagen: gasoline engine vehicles inspect, and if necessary, replace ignition coils. Vehicles affected by this action may have ignition coils that could malfunction under certain conditions. Models passat and wagon; golf; gti; jetta and wagon; new beetle and convertible; phaeton; eos; rabbit, etc.
• 10033216Jul 1, 2010Electrical system, Engine cooling. Volkswagen: (revised) vehicles may have ignition coils that could malfunction under certain conditions. If this happens, the malfunction indicator lamp (mil) will illuminated to let you know that vehicle may experience some deterioration in performance. In some cases, a malfunctioning ignition coil may cause a vehicle to exceed federal and/or california emissions standards. 2001-2007 passa/passat wagon. *pe updated…
• 10034824Jun 7, 2010Fuel system. Volkswagen: due to fuel intrusion into the low pressure side fuel pressure sensor g410, a false signal may be sent to the ecm resulting in a reading that is out of tolerance.
• 10034745May 10, 2010Engine cooling, Electrical system. Volkswagen: mil on or flashing, misfire dtcs p0300-0312 stored in ecm. The misfire condition may be caused by a malfunctioning ignition coil. Vehicles are out of production.
• 10033330Dec 18, 2009Transmission and drivetrain, Electrical system. Volkswagen: update programming, tcm, harsh downshift after extended highway driving. Internal transmission pressure decrease in c1 clutch due to accumulated air in the c1 oil circuit.
• 10237716Nov 13, 2009Equipment. The streaming music feature on vehicles equipped with factory or dealer installed Bluetooth will be available only in certain instances. The vehicle must be equipped with the RCD 310 or RCD 510 (Premium 8) radios or the RNS 510 or RNS 315 navigation systems. The Bluetooth system must be either the UHV low (9W2), UHV?NAR (9W7 or 9ZR) factory installed systems or the Volk ? L dealer installed system.
• 10033207Oct 28, 2009Engine cooling, Electrical system. Volkswagen: vehicles may have ignition coils that could malfunction under certain conditions. If this happens, the malfunction indicator lamp (mil) will illuminated to let you know that the vehicle may experience some deterioration in performance. In some cases, a malfunctioning ignition coil may cause a vehicle to exceed federal and/or california emissions standards. No models listed.
• 10052306Oct 23, 2009Brakes. Volkswagen: update information on models and model years regarding synchronization of electromechanical parking brake (epb) module and due to switch and module not being synchronized, fault codes found. Models 2006-2010 passat, 2009-2013 cc, tiguan.
• 10032414Jul 31, 2009Fuel system. Volkswagen: fuel pressure sensor replacement (saga code 24m5/05). Mil on and dtc p310b and/or p129f stored in the ecm fault memory. A malfuction of fuel pressure sensor-g410 (low pressure side) may cause an incorrect fuel pressure reading from the ecm. This condition may result in mil illumination and dtc's stored in fault memory.
• 10028104May 12, 2009Transmission and drivetrain, Engine cooling. Volkswagen: the intake flap motor or intake manifold runner position sensor g336 may be inoperative (both are included in one single unit). Models golf, gti, a5 jetta, gli, eos, passat, passat wagon. *pe updated 9/25/09.
• 10030116Mar 6, 2009Electrical system. Volkswagen: the positive battery cable on passat vehicles with v6 engine may corrode and in individual cases break. As a result, the power supply may be disrupted and e.g. The vehicle cannot be started.
• 10029033Mar 6, 2009Electrical system. Volkswagen: the positive battery cable on vehicles may corrode and in individual cases break. As a result, the power supply may be disrupted and e.g. The vehicle cannot be started.
• 10030449Mar 1, 2009Electrical system. Volkswagen: this is to inform you of the release of a new required vehicle update. Check and, if necessary, replace positive battery cable. Models passat, passat wagon, passat cc.
• 10238964Feb 6, 2009Electrical system, Air bags, Steering, Brakes. If, after replacement of the steering rack, fault code 01309 008 is set in the ABS/ESP module only, follow the test plan in GFF for Driver Steering Recommendation (DSR) or channel 3 activation. If the test plan fails to clear the fault, follow the direction below using Vehicle Self Diagnosis in Address Word 44 - Steering Assistance
• 10026848Aug 28, 2008Engine cooling, Body and structure. Volkswagen: exhaust heat shield, replacement guidelines. Heat shields are to be inspected after completion o any type of repair to the underbody (exhaust system transmission, etc.), and if damaged, replaced.
• 10026865Aug 19, 2008Fuel system. Vw: rvu-fuel pressure sensor replacement (saga code 24m5/05. A malfunction of fuel pressure sensor-g410-(low pressure side) may cause an incorrect fuel pressure reading from the ecm. May result in mil illumination and dtc's stored in fault memory.
• 10024404Feb 11, 2008Air bags. Igniter, side airbag, diagnostic trouble code(s) stored in dtc memory.
• 10024403Jan 29, 2008Air bags. Airbag monitoring light on, passenger occupant detection system, dtc 02511 014 stored in memory.
• 10032806Dec 18, 2007Engine cooling. Volkswagen: mil on, dtc p0299 stored in ecm fault memory. Charge pressure control, negative deviation. The condition may be the result of an abnormal turbocharger recirculationg valve.
• 10024449Dec 18, 2007Engine cooling. Mil on, dtc p0299 stored in ecm fault memory.
• 10032799Dec 13, 2007Fuel system. Volkswagen: mil on, dtc p129f and/or p310b stored in ecm fault memory. Due to fuel intrusion into the low pressure side fuel pressure sensor-g410, a false signal may be sent to the ecm resulting in a reading that is out of tolerance.
• 10024448Dec 13, 2007Fuel system. Mil on, dtc p129f and/or p310b stored in ecm fault memory.
• 10023950Nov 14, 2007Fuel system. Mil on, dtc p0087, p1093 or p2293 stored in ecm fault memory.
• 10032254Nov 2, 2007Seats. Volkswagen: seat, heating inoperative. Seat heater will not operate properly or becomes inoperative.
• 10023952Nov 2, 2007Seats. Seat, heating inoperative - seat heater will not operate properly or becomes inoperative.
• 10032256Nov 1, 2007Exterior lighting. Volkswagen: some vehicles with xenon headlamps, condensation can occur inside the xenon headlamps. Vehicles will be inspected and if necessary the xenon headlamp caps will be replaced and spring clips installed. The front and rear park assist sensors (park distance control sensors) on some vehicles may not always function properly.
• 10023691Nov 1, 2007Other or unknown, Exterior lighting. Volkswagen service campaign: see document search button for owner letter. 2006-2007 model year passat & passat wagon with xenon headlamps - replace headlamp caps and install spring clips and check/replace front & rear park distance control sensors (if equipped).
• 10023941Oct 26, 2007Electrical system. Epc warning light on and/or throttle body dtc p0121/p0221 stored in ecm fault memory.
• 10032252Oct 14, 2007Fuel system. Volkswagen: fuel pump replacement clarification. Excessive wear of intake camshaft lobe that drives the high pressure fuel pump. The wear limits maximum pump piston lift, causing fuel rail pressure fluctuations. The wear on the camshaft lobe can also lead to wear on the base of the high pressure fuel pump cam follower.
• 10032272Oct 1, 2007Engine cooling. Volkswagen: due to fuel intrusion into the low pressure side fuel pressure sensor g410, a false signal may be sent to the ecm resulting in a reading that is out of tolerance. A false signal may result in illumination of the malfunction indicator lamp and dtc p129f or dtc p310b being stored in fault memory. Improved fuel pressure sensor g410 to air against fuel intrusion.
• 10022463Jun 29, 2007Engine cooling. Mil on, dtc's p0442, p0445, p0456 or p2404 stored in ecm fault memory, no leaks present.
• 10022462Jun 29, 2007Engine cooling. Mil on, dtc p0087, p1093 or p2293 stored in ecm fault memory.
• 10021957May 10, 2007Exterior lighting. Headlamp inoperative, adaptivehid xenon system.
• 10021967May 3, 2007Transmission and drivetrain. Tcm, harsh up/down shift from transmission when cold.
• 10021430Mar 23, 2007Air bags. Igniter, side airbag, diagnostic trouble code stored in dtc memory.
• 10021680Sep 7, 2006Exterior lighting. Headlamp inoperative, adaptive hid xenon system.
• 10212724Jan 1, 2006Fuel system. Pressure Fuel Pump Replacement.

← All problems reported for the 2007 Volkswagen Passat