2011 Volkswagen Passat Technical Service Bulletins

583 technical service bulletins (TSBs) are on record for the 2011 Volkswagen Passat. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10252907Apr 12, 2013Equipment. Radio Navigation Unit Security Label
• 10237731Apr 12, 2013Equipment. When replacing a radio navigation unit, inspect the security labels on both the new and replacement units for damage. If damage is found to a label on either unit, be sure to note this on the repair order along with the reason the radio is being replaced.
• 10253178Apr 11, 2013Equipment, Electrical system, Other or unknown. After switching ON the RNS 315 radio-navigation system, the message "Please insert software CD" appears and the unit will not operate.
• 10239555Apr 11, 2013Equipment. RNS 315 Hardware Failure
• 10238960Apr 8, 2013Other or unknown, Fuel system, Engine cooling. To clear static ECM fault P1250 ?Fuel Level Too Low?, add fuel to vehicle and complete a road test of at least 10 miles. Simply adding fuel without completing a road test may not allow fault to clear.
• 10238959Apr 8, 2013Other or unknown, Fuel system, Engine cooling. To clear static ECM fault P1250 ?Fuel Level Too Low?, add fuel to vehicle and complete a road test of at least 10 miles. Simply adding fuel without completing a road test may not allow fault to clear.
• 10252906Apr 5, 2013Equipment. RNS 510 ? Radio Preset Display
• 10237730Apr 5, 2013Equipment. Be aware that the 24 RNS-510 radio presets are not band dependent, and can be programmed to any mix of AM, FM, or satellite stations. The presets shown on the display will not change when switching between bands.
• 10240855Apr 2, 2013Equipment, Transmission and drivetrain, Engine cooling. Please contact VW Helpline before attempting repair
• 10144704Apr 2, 2013Transmission and drivetrain. On-car analysis list of customer complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex)
• 10252900Mar 29, 2013Equipment. GPS Antenna Concerns
• 10252225Mar 29, 2013Equipment. Vehicles Equipped with Bluetooth Hands-Free Phone ? Pairing of Android Phones
• 10237721Mar 29, 2013Equipment. When pairing an Android phone to the Bluetooth system, a few extra steps may be necessary. Follow the instructions below to pair the phone:
• 10252905Mar 22, 2013Equipment. MDI Control of Apple Devices with Lightning Connector (iPhone 5, iPad fourth generation, iPod Nano seventh generation)
• 10252227Mar 22, 2013Equipment. Replacement Radio/Navigation Unit has no Sound
• 10237729Mar 22, 2013Electrical system. The Apple iPhone 5, iPad fourth generation, and iPod nano seventh generation use a proprietary ?Lightning? connector that is different than the 30 pin dock connector found on previous iPhone and iPod models.
• 10237723Mar 22, 2013Electrical system, Brakes. Replacement RNS 510 radio/navigation units may be shipped in transportation safeguard mode and therefore will have no sound output. In order to switch the unit out of this mode, hold down the forward seek button, the back seek button, and the music button at the same time until the unit shuts down. Once the unit is powered back ?ON? the safeguard mode will be deactivated.
• 10144701Mar 21, 2013Transmission and drivetrain. On-car analysis list of Customer Complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex)
• 10238061Mar 20, 2013Body and structure. Recommended procedure for removing damaged CV boot.
• 10243063Mar 18, 2013Equipment. VW Elsa Newsletter
• 10242401Mar 18, 2013Fuel system, Electrical system, Engine cooling. VW Elsa Newsletter
• 10241282Mar 15, 2013Engine cooling. Engine, Misfire Diagnostic Aid
• 10240879Mar 14, 2013Equipment. Please contact VW Helpline before attempting repair
• 10144702Mar 14, 2013Transmission and drivetrain. On-car analysis list of Customer Complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex)
• 10144703Mar 12, 2013Transmission and drivetrain. On-car analysis list of Customer Complaints: Transmission Concerns (including clutch assembly, bevel box and Haldex)
• 10242400Mar 11, 2013Equipment, Visibility (wipers, defrost, mirrors), Electrical system, Engine…. VW Elsa Newsletter
• 10252220Mar 8, 2013Equipment. All Vehicles with Bluetooth Phone Kit Installed ? Streaming Audio from Phone to Radio
• 10052040Mar 8, 2013Engine cooling. Volkswagen: it is a normal occurrence for the electric coolant fans to continue to run after the ignition is switched off.
• 10242399Mar 4, 2013Electrical system, Equipment, Fuel system, Body and structure. VW Elsa Newsletter
• 10239403Mar 1, 2013Electrical system. If key blade is found to stick or bind when opening or closing, check position of roll pin that secures key blade to mechanism. If roll pin is sticking out on either side (as shown below), do not replace key. Instead, use appropriate sized punch and hammer to drive in the roll pin so that it is flush with edge of mechanism.
• 10125635Feb 22, 2013Equipment. Tech Tips (Technician Helpline Vehicle Check Sheets): When it becomes necessary to open a VW Technician Helpline VTA case while performing diagnosis for a diesel particulate filter, manual transmission repair, or turbocharger concern, it is recommended to complete the related worksheet/check sheet before calling. This document informs where Worksheets/Check Sheets are available on ServiceNet.
• 10125612Feb 22, 2013Electrical system. Technical Bulletin (Factory Installed Media-In (MDI), Updated Programming for Various iPod Concerns): The update programming procedure in this document addresses the following concerns: ? Music skips at beginning of track. This document discusses the "Fault Codes" necessary to diagnosis, and potential remedy of the issue. The fault codes for checking warranty coverage for servicing the vehicle are also available.
• 10125613Feb 15, 2013Electrical system. Technical Bulletin (Bluetooth System Identification): This document informs how to identify the various Bluetooth systems by: ? Visual Identification ? PR Code ? Part Number
• 10125626Feb 1, 2013Electrical system. Tech Tips (Instrument Cluster Production Mode): During PDI, or after installation of a replacement cluster, ?Pro? may be displayed in place of the odometer. The high beam indicator may be flashing in the instrument cluster as well. This indicates the cluster is in Production mode. Production mode is not the same as ?Transport? mode. This document infroms of the difference between Production, and Transport mode.
• 10238941Jan 18, 2013Transmission and drivetrain, Engine cooling. When servicing the timing chain sprocket or removing the vibration damper, be aware that one bolt holds both the vibration damper (harmonic balancer) and the crankshaft timing chain sprocket to the crankshaft. Once the damper is removed, the crankshaft should not be rotated unless special tool spacer T10368 has been installed. The crankshaft timing chain sprocket and spur gear drive on the crankshaft have a…
• 10238940Jan 18, 2013Engine cooling, Transmission and drivetrain. CBFA 2.0T TSI Engine
• 10241263Jan 15, 2013Engine cooling, Fuel system. Fuel Additive to Help Prevent Sporadic Misfire Faults
• 10122244Jan 15, 2013Engine cooling. Technical Bulletin (Fuel Additive to Help Prevent Sporadic Misfire Faults): Fuel quality impacts the operating performance, efficiency and service life of the engine. The use of poor quality fuels may result in deposit build up on the fuel injectors and intake valves. This may result in a rough running condition, sporadic misfires, or cold start misfire faults storing in the ECM fault memory.
• 10241351Jan 14, 2013Fuel system, Brakes. High Pressure Fuel Pump Diagnosis
• 10239839Jan 3, 2013Transmission and drivetrain. DTC P2711 Implausible Transmission Shift Sequence Stored in the Transmission Control Module
• 10144705Dec 12, 2012Transmission and drivetrain. On-car analysis list of Customer Complaints: Transmission Concerns
• 10050079Dec 3, 2012Engine cooling. Volkswagen:evaporative (evap) emission system, diagnostic trouble code diagnosis. Revised procedure developed to test evap system without fuel cap.
• 10157804Nov 13, 2012Equipment. Warranty Information (Regularly Scheduled Maintenance Interval Time or Mileage Guidelines): The Volkswagen Customer Experience Team has monitored the claims processed through the Carefree Maintenance (CFM) program from its inception. Their findings reveal that, in many cases, the first maintenance interval service (10K) has been claimed multiple times while subsequent maintenance interval services (20K and 30K)…
• 10156232Nov 13, 2012Equipment. Warranty Information (Regularly Scheduled Maintenance Interval Time or Mileage Guidelines): The Volkswagen Customer Experience Team has monitored the claims processed through the Carefree Maintenance (CFM) program from its inception. Their findings reveal that, in many cases, the first maintenance interval service (10K) has been claimed multiple times while subsequent maintenance interval services (20K and 30K)…
• 10236504Nov 12, 2012Equipment. ElsaWeb Newsletter
• 10240881Nov 6, 2012Equipment. Please contact VW Helpline before attempting repair
• 10157751Nov 6, 2012Fuel system. On-car analysis list of Customer Complaints: Fuel gauge doesn't read full when the fuel tank is
• 10156150Nov 6, 2012Fuel system. On-car analysis list of Customer Complaints: Fuel gauge doesn't read full when the fuel tank is
• 10241259Nov 2, 2012Equipment. PDI - Vehicle Inspection, Protection Removal and Detailing
• 10239580Nov 2, 2012Visibility (wipers, defrost, mirrors). Wiper Blade Inspection for Proper Warranty Coding

← All problems reported for the 2011 Volkswagen Passat