2014 Volkswagen Passat Technical Service Bulletins

1,567 technical service bulletins (TSBs) are on record for the 2014 Volkswagen Passat. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10121609Oct 20, 2014Equipment, Electrical system. Technical Bulletin (Car-Net Operating Control Unit (OCU/J949) Service Guidelines & General Information): For informational purposes this document informs of Software related fault codes Software operating characteristics Swapping of OCU During PDI, LED does not illuminate issues Unsuccessful Over The Air Registration (OTAR) Does not include the "S" trim for Passat, Jetta, Beetle, and Tiguan.
• 10238948Oct 17, 2014Engine cooling. A change was made to the engine Oil Filter Adapter (OFA) for 2014 Model Year vehicles that resulted in a change in the oil filter element. It is important to note that the two different designs are Not interchangeable. Failure to install the correct oil filter WILL result in permanent engine damage.
• 10238616Oct 17, 2014Steering. This Tech Tip was established to explain the influence the adjustable steering column tilt position has on the steering wheel being off center and to provide information on checking for steering wheel off center. Please reference VWIQ video: http://tech.vw-iq.com/video.php?id=324
• 10121561Oct 17, 2014Engine cooling. Tech Tips (2.0L CCTA/CBFA Coolant Leak or Repeat Coolant Leak from the Water Pump Area): Inspect the water pump for signs of contact with engine oil. Engine oil may cause the water pump gasket to swell, which may lead to a coolant leak. This document informs of the precaustions necessary if a water pump replacement is necessary.
• 10121288Oct 17, 2014Steering, Wheels. Tech Tips (Steering Wheel Off Center): This Tech Tip was established to explain the influence the adjustable steering column tilt position has on the steering wheel being off center and to provide information on checking for steering wheel off center.
• 10069144Oct 17, 2014Equipment. Summary to be provided on a future date.
• 10240874Oct 16, 2014Equipment. Please contact VW Helpline before attempting repair
• 10121576Oct 16, 2014Equipment. On-car analysis list of Customer Complaints: Mil-on with fault code P046C, untouched vehicles
• 10241273Oct 15, 2014Body and structure. Removing Paint Contaminants from Exterior Paint
• 10121623Oct 15, 2014Body and structure, Equipment. Technical Bulletin (Removing Paint Contaminants from Exterior Paint): This document informs how to remove paint contaminants such as rail dust and industrial fallout from exterior paint.
• 10253199Oct 13, 2014Other or unknown. Car-Net Unresponsive - Verizon Telematics Service Interruptions and Outages (U.S. Only)
• 10239576Oct 13, 2014Other or unknown. Car-Net Unresponsive - Verizon Telematics Service Interruptions and Outages (U.S. Only)
• 10238037Oct 13, 2014Steering. Update Programming Electromechanical Steering Gear
• 10121615Oct 13, 2014Steering, Electrical system. Technical Bulletin (Update Programming Electromechanical Steering Gear): This document informs A new software map for the power steering control module was developed to reduce the retention force necessary to keep the vehicle driving straight ahead. Therefore a pulling sensation may be perceived in the steering wheel while driving on flat roads. Be aware that road crown can have a significant impact on the…
• 10121611Oct 13, 2014Equipment. Technical Bulletin (Car-Net Unresponsive - Verizon Telematics Service Interruptions and Outages): This document informs how to service potiential Interruptions and Outages. When beginning diagnosis for customer concerns related to functionality of the Car-Net system, it is important to understand that the symptom(s) may not be related to any problem with the vehicle itself.
• 10070364Oct 13, 2014Steering. Summary to be provided on a future date.
• 10241330Oct 10, 2014Engine cooling. Camshaft Adjustment Valve 1 -N205- Diagnosis
• 10240839Oct 10, 2014Equipment. please contact VW Helpline before attempting repair
• 10239267Oct 10, 2014Equipment. Volkswagen Warranty Policies and Procedures Manual ? US Edition, November 2014
• 10238621Oct 10, 2014Brakes, Wheels. Use the following procedure to diagnose active wheel speed sensor complaints:
• 10121621Oct 10, 2014Engine. Technical Bulletin (Camshaft Adjustment Valve 1 -N205- Diagnosis): Completing the GFF function test and performing basic settings on the camshaft adjustment valve are essential to diagnose proper operation and to avoid unnecessary replacements. The production solution to this issue was to optimized engine cleaning procedure in production.
• 10121536Oct 10, 2014Fuel system, Equipment. Tech Tips (ECM Fault P1250 "Fuel Level Too Low" Will Not Clear): This document informs to clear static ECM fault P1250 "Fuel Level Too Low", add fuel to vehicle and complete a road test of at least 10 miles. Simply adding fuel without completing a road test may not allow fault to clear.
• 10121291Oct 10, 2014Engine. Tech Tips (Common Rail TDI ? Fuel Filter Replacement and Prime/Bleed Procedure): This document informs when replacing fuel system components on the Common Rail TDI engine (including the fuel filter), the fuel system must be primed. The procedure should be available on most models through Guided Functions. If not shown, then access through Control Module OBD. Run ?Basic Settings block 35? three times in a row. This…
• 10121171Oct 10, 2014Wheels. Tech Tips (Active Wheel Speed Sensor Diagnosis): This document informs of a procedure to diagnose active wheel speed sensor complaints.
• 10238015Oct 8, 2014Tires. This Technical Bulletin provides information on improving vehicle drift/pull using selective tire placement. The information provided is based on the Hunter GSP9700 with StraightTrak® (VAS 6230x ) and John Bean RFV2000 with OptiLine® (VAS 6311A) diagnostic balancer. The diagnostic procedures for selective tire placement, to improve vehicle drift/pull, will require the use of one of the diagnostic balancers…
• 10121618Oct 8, 2014Equipment. Technical Bulletin (Vehicle Drift-Pull): The information provided in this bulletin is intended to assist technicians maximize the use of the approved diagnostic tire balancers to improve vehicle drift/pull. This document discusses the "Fault Codes" necessary to diagnosis, and potential remedy of the issue. The fault codes for checking warranty coverage for servicing the vehicle are also available.
• 10121577Oct 8, 2014Equipment. On-car analysis list of Customer Complaints: Mil-on with fault code P046C, untouched vehicles
• 10069687Oct 8, 2014Equipment. Summary to be provided on a future date.
• 10243017Oct 6, 2014Visibility (wipers, defrost, mirrors), Equipment, Electrical system, Fuel…. VW Elsa Newsletter
• 10242355Oct 6, 2014Visibility (wipers, defrost, mirrors), Equipment, Engine cooling, Fuel system…. VW Elsa Newsletter
• 10238938Oct 3, 2014Engine cooling, Transmission and drivetrain. Install a vacuum gauge on the dipstick tube and check crankcase vacuum at idle. Compare to a known good vehicle. If the vacuum reading is lower than the comparison vehicle, visually inspect for oil leaks between the engine and the transmission. Smoke test the crankcase by connecting the EVAP smoke machine to the dipstick tube and inspect for leaks at the rear main seal (this will limit pressure to 2 PSI). DO NOT…
• 10121607Oct 3, 2014Equipment. Tech Tips (RNS 510? Replacement Radio/Navigation Unit has no Sound): Replacement RNS 510 radio/navigation units may be shipped in transportation safeguard mode and therefore will have no sound output. This document informs how to deactivate the safeguard mode.
• 10121624Oct 1, 2014Equipment. Technical Bulletin (By-Pack At Delivery): Components may be missing from the by-pack at delivery. Components missing from the by-pack should be claimed in one of two ways. (Warranty or Transportation) Understanding when to claim one versus the other is very important. This document informs how to tell the difference.
• 10243025Sep 29, 2014Equipment. VW Elsa Newsletter
• 10242363Sep 29, 2014Other or unknown. VW Elsa Newsletter
• 10240853Sep 26, 2014Transmission and drivetrain, Equipment, Engine cooling. Please contact VW Helpline before attempting repair
• 10238965Sep 26, 2014Steering, Electrical system, Transmission and drivetrain, Back-over prevention…. Some Golf, GTI, Jetta, and Passat vehicles equipped with electromechanical power steering have the G85 steering angle sensor located in the steering rack. These vehicles do not have a G85 in the steering column. To determine G85 location, check the J500 Power steering control module part number in the GFF printout. Do not use the part number on the steering rack for this check.
• 10238942Sep 26, 2014Engine cooling. There are no bolts installed at the 9 and 3 o?clock positions from the factory. No bolts need to be installed in these locations while performing repairs. See photos for reference.
• 10120273Sep 26, 2014Transmission and drivetrain, Steering. Tech Tips (2009-2015 Jetta, Eos, Rabbit, Golf, GTI, Passat, CC, and Tiguan Equipped with Electromechanical Power Steering ? G85 Location Identification Tip): Ths document informs of the location of the G85 steering sensor. The sensors expected settings, and which vehicles do not have this sensor for electromechanical power steering.
• 10120264Sep 26, 2014Electrical system. On-car analysis list of customer complaints: Mil?on with fault code P046C, untouched vehicles
• 10069102Sep 26, 2014Wheels. Summary to be provided on a future date.
• 10239838Sep 24, 2014Engine cooling. MIL ON - Glow Plug Pressure Sensor Faults Stored in ECM Fault Memory
• 10239541Sep 24, 2014Visibility (wipers, defrost, mirrors). Air Conditioning, Cleaning of the Refrigerant Circuit (U.S.Only)
• 10120324Sep 24, 2014Electrical system. Technical Bulletin (Glow Plug Pressure Sensor Faults): When diagnosing MIL ON with glow plug pressure sensor DTC?s it is important to perform a diagnosis prior to replacing the glow plug. This document contains the fault code interperatation after such a diagnosis. the production solution is that the codes were implementated into production. This document discusses the "Fault Codes" necessary to diagnosis, and…
• 10120316Sep 24, 2014Equipment. Technical Bulletin (Air Conditioning, Cleaning of the Refrigerant Circuit): In cases where an air conditioning system component (such as a compressor or other system component) has failed and debris from the compressor or component is circulated throughout the refrigerant circuit, the refrigerant circuit must be cleaned of any and all debris or damage to the replacement components will result. Debris can be…
• 10239593Sep 23, 2014Electrical system. Keyless Entry Inoperative after Access / Start (KESSY) Module Replacement
• 10252208Sep 19, 2014Brakes. AC Compressor Replacement, Refrigerant Circuit Flushing Requirement
• 10239415Sep 19, 2014Latches, locks and linkages. Front Door Locks Hard to Release
• 10238004Sep 19, 2014Suspension. Front suspension creaking noise during suspension cycles (going over speed bumps or entering on an inclined surface).
• 10237705Sep 19, 2014Visibility (wipers, defrost, mirrors). When replacing the Air Conditioning compressor it is necessary to flush the entire system to remove all the PAG oil. Replacement AC compressors come with a full charge of oil. Any time another compressor is installed with a different vendor (Sanden to Denso) it is necessary to replace all the oil in the system to the new vendor type PAG oil.

← All problems reported for the 2014 Volkswagen Passat