2007 Volkswagen Touareg Technical Service Bulletins

363 technical service bulletins (TSBs) are on record for the 2007 Volkswagen Touareg. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10239541Sep 24, 2014Visibility (wipers, defrost, mirrors). Air Conditioning, Cleaning of the Refrigerant Circuit (U.S.Only)
• 10120316Sep 24, 2014Equipment. Technical Bulletin (Air Conditioning, Cleaning of the Refrigerant Circuit): In cases where an air conditioning system component (such as a compressor or other system component) has failed and debris from the compressor or component is circulated throughout the refrigerant circuit, the refrigerant circuit must be cleaned of any and all debris or damage to the replacement components will result. Debris can be…
• 10120272Sep 19, 2014Electrical system. Tech Tips (Comfort Module (J393) or BCM (J519) Replacement): This document informs if a comfort or body control module is replaced during normal diagnosis, make sure the factory mode has been switched OFF. This can be accomplished by selecting guided function of either the J393 or J519 or control module OBD of J393 or J519 then selecting adaptation channel 99.
• 10243023Sep 15, 2014Latches, locks and linkages, Electrical system, Steering. VW Elsa Newsletter
• 10242361Sep 15, 2014Other or unknown. VW Elsa Newsletter
• 10241323Sep 10, 2014Engine cooling. Update Programming, MIL ON, DTCs P0420, P0430 Stored in ECM Fault Memory
• 10120301Sep 10, 2014Engine cooling. Technical Bulletin (Update Programming for Catalyst System Bank Efficiency Below Threshold): This document informs of diagnostic fault codes which state that the Catalyst System Bank Efficiency is Below Threshold this is because the Diagnostic strategy was too sensitive. The production solution for this issue was to stop making the Engine Control Module, and thus it is out of production. This document discusses the…
• 10069630Sep 10, 2014Electrical system. Summary to be provided on a future date.
• 10252942Sep 5, 2014Equipment. Damage to Data Link Connector (DLC) from Aftermarket Devices (Cannot Communicate with Vehicle OBD System)
• 10237766Sep 5, 2014Electrical system. The DLC is intended for use with diagnostic scan tools and by emissions testing stations. However, aftermarket devices (i.e., drive data recorders) that connect to the DLC have now become available.
• 10241340Sep 2, 2014Engine. Engine Oils Which Meet Volkswagen Oil Quality Standard VW 502 00/505 00/505 01 and VW 504 00/507 00
• 10120329Sep 2, 2014Engine. Technical Bulletin (Engine Oils Which Meet Volkswagen Oil Quality Standard): This document informs of a sample list of products generally available in the North American market that meet the Volkswagen Oil Quality Standard
• 10238565Aug 29, 2014Engine. When diagnosis on the above engine leads to the testing of the N75, please refer to the picture below. The diagram shows which vacuum ports on the N75 valve should hold vacuum and which ones should not.
• 10120284Aug 29, 2014Electrical system. Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle
• 10241339Aug 22, 2014Engine cooling, Engine. Oil Consumption Measurement
• 10124479Aug 22, 2014Electrical system. Tech Tips (Comfort Module (J393) or BCM (J519) Replacement): This document informs If a comfort or body control module is replaced during normal diagnosis, make sure the factory mode has been switched OFF. This can be accomplished by selecting the test plan through GFF or through Vehicle Self Diagnosis in adaptation channel 99. Failure to deactivate factory mode will create a concern where the door locks will not…
• 10124471Aug 22, 2014Engine. Technical Bulletin (Oil Consumption Measurement): Customer states oil consumption is higher than the Volkswagen oil consumption standard of up to 0.5 quarts per 600 miles, or 0.5 liters per 1000 km. In order to provide effective lubrication and cooling of internal engine components, all internal combustion engines consume a certain amount of engine oil. Oil consumption varies from engine to engine and may change…
• 10242682Aug 4, 2014Electrical system. ODIS Service Update
• 10238600Jul 4, 2014Transmission and drivetrain. Incorrect torque converter or flywheel/flexplate installation can result in transmission damage. When installing an engine, flywheel or transmission, please follow the installation procedures outlined in ELSA. For the flywheel/flexplate, please be certain the correct shim is installed between it and the crankshaft (reference VWIQ120). When installing a torque converter, press the torque converter hub through the…
• 10120207Jul 4, 2014Transmission and drivetrain. Tech Tips (Torque Converter/Flywheel/Flexplate installation): Incorrect torque converter or flywheel/flexplate installation can result in transmission damage. When installing an engine, flywheel or transmission, please follow the installation procedures outlined in ELSA. This document also contains advice on the installation of these devices
• 10238972Jun 6, 2014Tires, Wheels. The use of tire dressing gives your tires that shiny finish that completes the image of a clean (new) vehicle. There are many different tire dressing products available. When choosing a product please pay close attention to its contents. Always use a water based product.
• 10120155Jun 6, 2014Wheels, Tires. Tech Tips (All vehicles-Tire dressing for vehicle detailing): The use of tire dressing gives your tires that shiny finish that completes the image of a clean (new) vehicle. This document informs that The use of non-water based products will increase the risk of causing damage to painted surfaces. The document also gives graphical examples of the dame that can occur if non-water based products are used.
• 10253215Jun 4, 2014Exterior lighting, Other or unknown. Exterior Lights, Moisture Accumulation
• 10239592Jun 4, 2014Exterior lighting. Exterior Lights, Moisture Accumulation
• 10120169Jun 4, 2014Exterior lighting, Equipment. Technical Bulletin (Exterior Lights, Moisture Accumulation): This document informs of the Condensation and or water droplets visible on inside of exterior light lenses. The document also informs how to service the issue.
• 10238951May 30, 2014Brakes. If you have a complaint of DTCs for the low side fuel pressure being out of specification (e.g. P310B), check the fuel pressure with BOTH a mechanical gauge and by the display in Measured Value Block 103. The readings should be 1 bar higher in the MVB due to reading atmospheric pressure + fuel pressure. If the mechanical gauge reading is within specification BUT the MVB 103 reading is not 1 bar higher, check for a…
• 10124367Apr 29, 2014Electrical system. Quick Reference Update Guide: This document informs of the corresponding software/hardware and disc availability to the customer concerns about a vehicle
• 10239534Apr 18, 2014Visibility (wipers, defrost, mirrors). HVAC, Unpleasant Odor
• 10124340Apr 18, 2014Equipment. Technical Bulletin (HVAC, Unpleasant Odor): Condensation, which is a normal condition in all A/C systems, can cause a musty odor. If the odor is noticeable in the vehicle when the engine is not turned on, the cause may be mold and mildew in the passenger compartment, and not be related to the A/C system. All other possible sources of the odor must be investigated before this document can be performed. This document…
• 10241266Apr 10, 2014Equipment. Squeaks, Rattles, Noise, Repair Materials
• 10124348Apr 10, 2014Equipment. Technical Bulletin (Squeaks, Rattles, Noise, Repair Materials): This doucment contains a list of components and applications developed to repair concerns of squeaks, rattles, noise and trim fit conditions.
• 10239270Apr 1, 2014Equipment. Volkswagen Warranty Policies and Procedures ? April 2014
• 10239533Mar 27, 2014Visibility (wipers, defrost, mirrors). HVAC, Unpleasant Odor
• 10124289Mar 27, 2014Equipment. Technical Bulletin (HVAC, Unpleasant Odor): Unpleasant odor is coming from Heating and Ventilation system. Odor mainly occurs after vehicle has been sitting (unused) at least 5 hours and within 20 to 60 seconds after vehicle is first started. Condensation is a normal characteristic in all A/C systems. If odor is noticeable continue to follow this document. Contaminants are effectively neutralized using the…
• 10241311Mar 26, 2014Engine cooling. Gasoline Quality
• 10124302Mar 26, 2014Engine. Technical Bulletin The use of contaminated gasoline, seasonal fuel changes (summer/winter fuel) or gasoline with a low content of deposit control additives may result in one or more of the following conditions: -Excessive accumulation of deposits on intake valves, intake manifold, fuel injectors and combustion chambers. -Engine runs rough after cold start. -Excessive engine cranking time. -Stumbles while driving…
• 10241342Mar 25, 2014Electrical system, Engine cooling. Electric Coolant Fans Continue to Run after Ignition is OFF
• 10241310Mar 18, 2014Electrical system, Other or unknown. Software Version Management
• 10124303Mar 18, 2014Electrical system. Technical Bulletin This Technical Bulletin details the general process for carrying out a Software Version Management (SVM) software update for any Technical Bulletin (TSB) / Required Vehicle Update (RVU).
• 10253214Mar 8, 2014Other or unknown, Exterior lighting. Exterior Lights, Moisture Accumulation
• 10239591Mar 6, 2014Exterior lighting. Exterior Lights, Moisture Accumulation
• 10124287Mar 6, 2014Exterior lighting. Technical Bulletin (Exterior Lights, Moisture Accumulation): Exterior light assemblies (headlights, taillights, fog lights, turn signals) are vented and may collect moisture on their inner surfaces, depending on humidity and other climatic changes. This document discusses necessary to diagnosis, and potential remedy of the issue.
• 10243008Mar 3, 2014Engine cooling, Electrical system. VW Elsa Newsletter
• 10242346Mar 3, 2014Equipment. VW Elsa Newsletter
• 10241264Feb 25, 2014Engine cooling, Fuel system. Fuel Additive to Help Prevent Sporadic Misfire Faults
• 10241308Feb 21, 2014Engine, Other or unknown. MIL ON, DTCs P0325 or P0327 Stored in ECM Fault Memory
• 10069616Feb 21, 2014Electrical system. Summary to be provided on a future date.
• 10241265Jan 27, 2014Engine cooling, Fuel system. Fuel Additive to Help Prevent Sporadic Misfire Faults
• 10239789Jan 24, 2014Electrical system, Visibility (wipers, defrost, mirrors), Other or unknown. To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. The check must be performed with the engine running and heated rear window switched on. Switch OFF the ignition and visually locate the damage. Proceed with checking any other lines as necessary. Once the damaged line is identified, repair utilizing the Repair kit by Permatex® ITEM…
• 10122240Jan 24, 2014Visibility (wipers, defrost, mirrors). Tech Tips (Heated Rear Window, One or More Lines Inoperative): To detect which line(s) is inoperative, utilize a volt meter to check for 0 V, which will be present after the open in the grid line. This document informs of how to diagnose the issue and tips on servicing the issue

← All problems reported for the 2007 Volkswagen Touareg