2000 Volvo S80 Recalls

NHTSA lists 4 recall campaigns for the 2000 Volvo S80. A recall applies only to vehicles built within the affected range, so check your own VIN at nhtsa.gov/recalls. Repairs for recalls are free at a franchised dealer.

• 10V566000Nov 8, 2010416 vehicles potentially affected
  Equipment › Electrical › Navigational system(global positioning system)
  Covers: Volvo S80 2000–2010, V70 2001–2010, XC70 2001–2010 +6 more

  Reported issue: Volvo is recalling certain vehicles equipped with garmin 760 portable global positioning system (gps) units because the batteries on those units may overheat.

  Possible consequence: An overheated battery could lead to a fire.

  Remedy: Volvo advises owners to please stop using the garmin portable gps device immediately, and visit the garmin website to determine if their unit is affected. The unit's battery will be replaced with a new battery and a spacer will be inserted on top of the battery next to the pcb. This service will be performed free of…

  Full campaign details →

• 06V441000Nov 15, 2006170,099 vehicles potentially affected
  Vehicle speed control
  Covers: Volvo S80 1999–2001, V70 1999–2002, C70 1999–2002 +5 more

  Reported issue: On certain passenger vehicles, a combination of throttle positioning sensor irregularities, a dirty throttle housing, and/or inefficient software calibration may cause a warning lamp to light and the subsequent onset of limp home modes.

  Possible consequence: This resulted in a high number of vehicles going into the limp home mode without need.

  Remedy: Dealers will install the current software upgrade onto the involved vehicles. The recall began on december 29, 2006. Owners may contact volvo at 1-800-458-1552.

  Full campaign details →

• 04V451000Sep 13, 2004149,799 vehicles potentially affected
  Engine and engine cooling › Cooling system › Fan
  Covers: Volvo S80 1999–2001, V70 2000–2001, S60 2001 +1 more

  Reported issue: On certain passenger and sport utility vehicles, under certain operating conditions, some electric cooling fans may overheat potentially causing heat damage and, in rare instances, a fire in the engine compartment.

  Possible consequence: A fire in the engine compartment could occur.

  Remedy: Dealers will replace the cooling fan. The recall began on november 29, 2004. Customers should contact volvo cars at 1-800-458-1552.

  Full campaign details →

• 00V238000Aug 24, 200049,488 vehicles potentially affected
  Suspension › Front › Control arm › Upper ball joint
  Covers: Volvo S80 1999–2000

  Reported issue: Vehicle description: passenger vehicles. Over time, the ball joint between the front wheel king pin and the suspension link arm, can experience increased looseness.

  Possible consequence: This condition could affect the ball joint's durability and performance.

  Remedy: Dealers will replace both front ball joints.

  Full campaign details →

← All problems reported for the 2000 Volvo S80