2000 Volvo VN Technical Service Bulletins

96 technical service bulletins (TSBs) are on record for the 2000 Volvo VN. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10126644May 28, 2015Engine. High Soot Output
• 10126643May 26, 2015Equipment. Timing Plate Flange Screw
• 10126642May 21, 2015Electrical system. Hill Start Assist Solenoid, Replacement
• 10126641May 13, 2015Equipment. Timing Plate Leak Repair
• 10126664Mar 20, 2015Equipment. DEF Sensor Assembly Routing
• 10126663Mar 10, 2015Fuel system. Aftertreatment DEF Tank Vent Filter
• 10126635Jan 30, 2015Equipment. Range Synchronizer, Repair
• 10126634Jan 29, 2015Engine cooling. EGR Mass Flow Rate Low, diagnostic trouble code
• 10126633Jan 13, 2015Transmission and drivetrain. Twin Mass Flywheel Conversion, Transmission Removed
• 10126632Jan 12, 2015Electrical system. Hill Start Assist Solenoid, Replacement
• 10126627Oct 23, 2014Electrical system. Fuel Management Module, Replacement, incorrect calibration
• 10126623Oct 10, 2014Electrical system. Battery Cable, Routing
• 10126620Oct 3, 2014Transmission and drivetrain. Transmission ECU Compatibility
• 10126659Jul 21, 2014Engine cooling. Exhaust Gas Recirculation (EGR) Differential Pressure Sensor
• 10126658Jun 23, 2014Engine cooling. Coolant Hose, EGR Cooler, Replacement
• 10126657Jun 2, 2014Fuel system. Dual Fuel Tanks Ventilation Filter Kit
• 10126656Jun 2, 2014Fuel system. Single Fuel Tank Ventilation Filter Kit
• 10126655Jun 2, 2014Equipment. Hill Start Assist Solenoid, Replacement
• 10126654May 19, 2014Body and structure. Service Door Rust Prevention
• 10126653May 12, 2014Equipment. AMT High Range Cone Replacement
• 10126630Mar 20, 2014Seats. Seat Harness Routing (Swivel) wires pulling away from clipping points
• 10126629Mar 20, 2014Seats. Seat Harness Routing (Non-Swivel) wires pulling away from clipping points
• 10126619Jan 27, 2014Electrical system. Engine Control Module (ECM) Software Update
• 10054072Nov 1, 2013Brakes. Volvo: on some trucks, air disc brake may experience a condition of thermal overload. Thermal overload reduces running clearance between pad and rotor below desired level which is an over adjustment of normal pad wear compensation. Model vah, vhd, vn. No years listed.
• 10054065Nov 1, 2013Brakes. Volvo: the air disc brake, on some trucks, may experience thermal overload due to an over adjustment of normal pad wear compensation that maintains clearance running between brake pad and rotor. Models vah, vhd, vn. No years listed.
• 10054064Nov 1, 2013Engine. Volvo: low oil pressure, on certain vehicles, during long hard pull conditions, diagnostic trouble codes (dtcs) pid 100 fm1, spn 100 fmi 1 or p252400, can log on, with or without engine shut down lamp. Model vn, vt. No years listed.
• 10126615Oct 31, 2013Electrical system. Oil Level Sensor Harness Wire Splice
• 10127345Apr 26, 2013Electrical system. Transmission ECU Programming
• 10127344Apr 1, 2013Electrical system. Software Update, revise document
• 10126609Nov 27, 2012Engine cooling. Exhaust Gas Recirculation (EGR) Valve Oil Supply Line, updated part
• 10126639Oct 17, 2012Electrical system. Engine Coolant Thermostat Software Update
• 10126638Oct 11, 2012Equipment. Floor Cracks Repair (Rear Panel)
• 10126637Oct 11, 2012Equipment. Floor Cracks Repair (Front Panel)
• 10045759Aug 1, 2012Electrical system, Seats. Volvo trucks: during operation of driver side swivel seat and I shift transmission, the harness rubbing or wires, are pulled out of connectors. This causes seat harness dropping or pulling away from clipping points.
• 10044253Jun 1, 2012Brakes. Volvo trucks: on the steering axle of the volvo trucks, the zerk fitting on the meritor slack adjuster comes into contact with the bolt head of the steering arm causing the fitting to break. *js updated 8/17/12.
• 10044250Apr 1, 2012Interior lighting. Volvo: light control module (lcm), reprogramming. On some volvo units equipped with clear led clearance lights in the sun visor, the may exhibit an active fault code mid 216 psid 49 fmi 5. This fault indicates a trailer marker open issue which is incorrect for the issue present on the vehicle.
• 10044249Apr 1, 2012Engine cooling. Volvo trucks: oil seepage at flywheel housing. This problem has already been solved in production, but the production solution is not compatible with previous generation flywheel housings.
• 10044246Apr 1, 2012Engine cooling. Volvo trucks: connector pin, replacement. Severe fretting damage of the engine variable geometry turbocharger actuator (engine vgt actuator) harness and turbine shaft speed sensor (tss) connector may cause an unreliable signal to the engine vgt actuator.
• 10043827Feb 1, 2012Body and structure. Volvo: trucks built prior to 18/8/2011 were shipped without four (4) spring nuts pre-installed from the factory.
• 10040053Feb 1, 2011Electrical system. Volvo trucks: some engines leak oil through the grommet. Information on the wiring harness, unit injector replacement. *rm updated 9/9/11.
• 10040054Jan 1, 2011Body and structure. Volvo trucks: vehicles with partial chassis fairings may experience damage to the fairing¿s lower support rail. It can be caused by vibration of the fairing against the fiberglass rail. A procedure has been developed to improve the situation.
• 10032747Nov 1, 2009Body and structure. Volvo truck: to reduce the potential for cab water intrusion, a cab cowl seal has been released by engineering. The seal part number 8083305 is positioned above the top edge of the cowl panel to divert water flow onto the cowl panel rather than between the cowl panel and cab. No model years listed.
• 10027064Jul 1, 2009Engine cooling. Volvo trucks: engine update campaign for certain d13f engines (vn-2, vhd-2) consists of inspecting the camshaft and replacing the intake rocker arms, exhaust rocker arms, injector rocker arms, injector hold downs, and the injector sealing washers. *pe updated 12/17/09.
• 10030389Jun 1, 2009Fuel system, Engine cooling. Volvo truck: on some vehicles, coolant overflow out of the overflow tube occurs during the diesel particulate filter regeneration cycle. Excessive coolant flow from the radiator top tank and thermostat vent lines prevents flow into the de-aeration process. Vn-2, vhd-2 vt models only. No model years listed.
• 10030388Jun 1, 2009Transmission and drivetrain. Volvo truck; clutch switch clip; it has been found that vn, vhd and vt vehicles use a spring clip to retain the clutch switch, may have an issue with the clutch switch moving or detaching from it's mount.
• 10028709Feb 1, 2009Equipment. Volvo truck: reports prompted the release of a replacement connector for the cab hvac motor resistor. Replacement connector is supplied as kit part, which contains the connector body and the necessary terminals. Model years unknown.

← All problems reported for the 2000 Volvo VN