2001 BMW F650GS Technical Service Bulletins

13 technical service bulletins (TSBs) are on record for the 2001 BMW F650GS. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10211897Mar 18, 2022Electrical system. The motorcycle will not start. The vehicle battery is empty even though the battery charger was permanently connected to the 12V power socket.
• 10205109Nov 3, 2021Body and structure, Equipment. Stress corrosion cracks may occur on the studs of certain milled footrests from the BMW Motorrad special accessories catalog for the GS models.
• 10201169Jul 1, 2021Electrical system. Vehicle battery not charged despite the battery charger being connected to the on-board socket (manufactured before 2009)Headlights and rear lights light up intermittently despite the ignition being switched off and the battery charger being connected to the on-board socket.
• 10200257Jun 24, 2021Transmission and drivetrain. The clutch plates do not tolerate frequent and prolonged operation at the clutch friction zone, causing a shorter service life in motorcycles that see intensive use
• 10200262Jun 14, 2021Electrical system. The wiring harness of the F 650 GS and F 650 GS Dakar (R13) models is routed along the right-hand top rail of the frame. Weld spatter on the frame and/or adverse routing in the vicinity of the banjo bolt of the hydraulic spring base adjuster can result in the chafing of the wiring harness.
• 10193504Sep 9, 2013Equipment. Leaks have been reported in fork legs. The cause is reported be from oil lubricating film with accompanying dirt/grease ring is incorrectly interpreted to be a leaking fork leg. Investigations have shown that the part is not defective.
• 10037025Aug 1, 2010Exterior lighting. Bmw: procedure for determining and replacing incandescent and halogen light bulbs under warranty.
• 10033130Dec 1, 2009Fuel system. Bmw vehicles: fuel level sensor repairs. Where it is necessary to replace the right or the left side fuel level sensor due to a failure, the entire pump and housing or delivery unit (suction jet assembly) do not need to be replaced as well. In some cases, epc does not show that the repair kit is available separately in the illustration, but it is available in the parts description. All models. No model years listed.
• 10029624Mar 1, 2009Engine cooling. Bmw motorcycle: the coolant inlet hose is not compliant with the applicable bmw specifications. Engine operation can cause the inlet hose to widen and become correspondingly shorter; overtime this contraction in length can cause the hose to work back off the water pump nozzle for enough to allow coolant to escape. No model years listed.
• 10028386Oct 1, 2008Brakes, Vehicle speed control. Bmw vehicles: routing abs front wheel speed sensor cable. The wiring harness front wheel speed sensor periphery plug connection is mounted on the fork cover at the bottom.
• 10029188Sep 1, 2008Electrical system. Bmw mc: wiring harness of motorcycles is routed along right hand top rail of frame. Weld spatter on frame and/or adverse routing in vicinity of banjo bolt of hydraulic spring base adjuster can result in chafing of the wiring harness. Model years unknown.
• 10026845Jun 1, 2008Fuel system, Steering. Bmw motorcycle: replacement of fuel-pressure sensor. Check of position of protective film (f-800 gs only).
• 10030825Nov 1, 2007Fuel system, Other or unknown. Bmw motorcycle: engine fuels containing ethanol. Bmw motorrad has no objection to the use of si engine fuels containing up to a maximum of 10% ethanol and imposes no warranty restrictions. Ethanol mixtures in proportions higher than 10% can have an adverse effect on performance and can result in damage to components that come into contract with fuel. No warranty claims whatsoever for damage caused in this way will…

← All problems reported for the 2001 BMW F650GS