2007 BMW F800 S Technical Service Bulletins

18 technical service bulletins (TSBs) are on record for the 2007 BMW F800 S. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10249027Jan 11, 2024Electrical system. The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. This document covers important information for the dealer on how to handle “discharged battery” complaints.
• 10205099Nov 30, 2021Electrical system. The use of a faulty tool in engine assembly has led to isolated cases of damage to the spark plugs.
• 10204667Sep 20, 2021Electrical system. One of the following situations can occur when connecting to BN2000 motorcycles: 1. The installed control units cannot be found when reading out with ISTA. 2. Control units initially communicate after connecting to the vehicle, but communication later stops.
• 10201169Jul 1, 2021Electrical system. Vehicle battery not charged despite the battery charger being connected to the on-board socket (manufactured before 2009)Headlights and rear lights light up intermittently despite the ignition being switched off and the battery charger being connected to the on-board socket.
• 10200257Jun 24, 2021Transmission and drivetrain. The clutch plates do not tolerate frequent and prolonged operation at the clutch friction zone, causing a shorter service life in motorcycles that see intensive use
• 10182619Oct 1, 2020Equipment, Electrical system. Discharged Battery Energy Diagnosis Must Be Performed: The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. This document covers important information for the dealer on how to handle "discharged battery" complaints.
• 10151350May 1, 2016Fuel system, Engine cooling. Coolant pump drain hose. Details The coolant pump is fitted with a radial shaft seal on the oil-side and on the coolant-side is a mechanical seal. Mechanical seals are reliable an durable, yet for technical reasons, they always exhibit minor seepage. The seepage amount is considered to be within permissible limits if the coolant does not need to be topped up between service intervals. The drain hole (arrow in the…
• 10147915Dec 1, 2015Transmission and drivetrain. Occasionally it's not possible to downshift the transmission; especially from 3rd to 2nd gear.
• 10147912Dec 1, 2015Equipment. Map data should be stored on a 64 GB SD card. In GARMIN Express the note appears that a maximum of 32 GB is possible.
• 10147911Dec 1, 2015Transmission and drivetrain, Engine. Transmission rattles when the engine is at operating temperature and idling.
• 10038217Mar 1, 2013Engine cooling. Bmw: crankcase pressure diagnosis and information for all vehicles. *rm updated on 4/24/2013.
• 10037025Aug 1, 2010Exterior lighting. Bmw: procedure for determining and replacing incandescent and halogen light bulbs under warranty.
• 10033130Dec 1, 2009Fuel system. Bmw vehicles: fuel level sensor repairs. Where it is necessary to replace the right or the left side fuel level sensor due to a failure, the entire pump and housing or delivery unit (suction jet assembly) do not need to be replaced as well. In some cases, epc does not show that the repair kit is available separately in the illustration, but it is available in the parts description. All models. No model years listed.
• 10029705Mar 2, 2009Engine cooling. Bmw motorcycle: when disengaged, e.g. When changing gear or rolling the vehicle to a stop, the engine may cut out; when idling, the engine runs on only one cyclinder. (e series (k71; k72). No model years listed.
• 10029706Feb 25, 2009Brakes. Bmw motorcycle: wheel speed dependent, clearly audible clanking noise occurs when braking to adjust speed. E series (k25; k25/02; k25/03; k25/11; k25/12; k25/hp; k26; k27; k28; k29; k29/hp; k40; k41; k43; k43/hv; k44; k589/03; k71). No model years listed.
• 10026303Mar 1, 2008Fuel system. Bmw motorcycle: change to routing of fuel tank breather. If fuel tank breather hose of the k7a is trapped b y neighboring components, pressure equalization inside the fuel tank is possible only to a limited extent.
• 10030825Nov 1, 2007Fuel system, Other or unknown. Bmw motorcycle: engine fuels containing ethanol. Bmw motorrad has no objection to the use of si engine fuels containing up to a maximum of 10% ethanol and imposes no warranty restrictions. Ethanol mixtures in proportions higher than 10% can have an adverse effect on performance and can result in damage to components that come into contract with fuel. No warranty claims whatsoever for damage caused in this way will…
• 10026041Aug 17, 2007Electrical system. Bmw: ews fault display in the instrument cluster. Motorcycle does not start. Ews intermittently or permanently displayed in the instrument cluster.

← All problems reported for the 2007 BMW F800 S