2024 BMW I5 Technical Service Bulletins

55 technical service bulletins (TSBs) are on record for the 2024 BMW I5. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 11036380Aug 20, 2026Electrical system. After replacement of the Integrated Braking system (IB)/Power Brake the total distance covered might belower than when handed over to the workshop for the repair.
• 11036379Aug 20, 2026Steering. “Cracking” noise might be heard when turning the steering wheel from lock to lock. See attached video V3202 26 EPS noise.
• 11036383Aug 12, 2026Electrical system. A faulty electric auxiliary heater may have been installed in the certain vehicles. This could result in thefailure of the electric auxiliary heater, utilized for the vehicle interior.
• 11031568Apr 22, 2026Electrical system. Charging sessions cannot be started or they are interrupted while using a Level 2 AC high-power charging station, or with a Level 3 DC charging station. Charging may start normally but can interrupt after some time. Level 2 (240 V) Flex Charger and Wall box may also be affected. The red or white LED is displayed on the high-voltage charging socket; however, no associated fault codes are stored.
• 11030059Mar 6, 2026Transmission and drivetrain. The customer states there is a Drivetrain Malfunction message displayed in the instrument cluster. In addition, the following fault memory entries are saved in the CCU (Combined Charging Unit) 0317F2 - High-voltage system, insulation fault detected: when switch contactors are closed. 0317F1 - High-voltage system, insulation resistance below warning threshold: when switch contactors are closed.
• 11029046Feb 25, 2026Engine. There is coolant leaking from under the car Low heater output Possible Check Control message “Drive, you can continue driving” (ID49) Possible fault codes stored in these BEV vehicles: 224163 – Electric auxiliary heater for the high-voltage battery unit: Undervoltage or internal communication fault 8049AA - Coolant level sensor, expansion tank: Coolant level low or short circuit to ground or line disconnection…
• 11029015Feb 4, 2026Electrical system. High Voltage Connection Return
• 11027770Jan 3, 2026Body and structure. Through quality checks, it has been detected that the front left water drain hose for the slide/tilt sunroof isnot connected.
• 11026956Dec 22, 2025Electrical system. A faulty electric auxiliary heater may have been installed in the certain vehicles. This could result in thefailure of the electric auxiliary heater, utilized for the vehicle interior.
• 11026953Dec 3, 2025Body and structure. Delivery stop: sunroof water drain hose
• 11025685Nov 10, 2025Exterior lighting. RSU availability. The ambient lighting color cannot be saved permanently. The personalized color of the ambient lighting resets after the vehicle has gone to sleep.
• 11022362Aug 26, 2025Electrical system. A faulty electric auxiliary heater may have been installed in the certain vehicles. This could result in thefailure of the electric auxiliary heater, utilized for the vehicle interior.
• 11020066Jun 27, 2025Body and structure, Electrical system. While attempting to fuel/charge the vehicle,the fuel/charge door will not open.
• 11019570Jun 6, 2025Engine. A faulty electric auxiliary heater may have been installed in the certain vehicles. This could result in the failure of the electric auxiliary heater.
• 11018736May 16, 2025Other or unknown. Delivery Stop Electric Auxiliary Heater
• 11018513May 2, 2025Steering. Parts of the steering shaft universal joint may have been joined together without having beengreased. As a result, there can be audible squeaking and cracking noises. In some cases, moresteering force is required.
• 11016419Mar 31, 2025Engine. There is coolant leaking from under the car Low heater output Possible Check Control message “Drive, you can continue driving” (ID49) Possible fault codes stored in these BEV vehicles: 224163 – Electric auxiliary heater for the high-voltage battery unit: Undervoltage or internal communication fault 8049AA - Coolant level sensor, expansion tank: Coolant level low or short circuit to ground or line disconnection…
• 11014422Feb 11, 2025Engine. There is coolant leaking from under the car Low heater output Possible Check Control message “Drive, you can continue driving” (ID49) Possible fault codes stored in these BEV vehicles: 224163 – Electric auxiliary heater for the high-voltage battery unit: Undervoltage or internal communication fault 8049AA - Coolant level sensor, expansion tank: Coolant level low or short circuit to ground or line disconnection…
• 11014035Feb 3, 2025Engine. There is coolant leaking from under the car Low heater output Possible Check Control message “Drive, you can continue driving” (ID49) Possible fault codes stored in these BEV vehicles: 224163 – Electric auxiliary heater for the high-voltage battery unit: Undervoltage or internalcommunication fault 8049AA - Coolant level sensor, expansion tank: Coolant level low or short circuit to ground or linedisconnection 80124F…
• 11013040Jan 13, 2025Brakes. After replacement of the Integrated Braking system (IB)/Power Brake the total distance covered might be lower than when handed over to the workshop for the repair.
• 11013049Jan 6, 2025Other or unknown. When driving over rough surfaces, a low-frequency rattling noise can be heard inside the vehicle's cabin. The noise typically sounds as though it is coming from the front right footwell area.
• 11012080Dec 10, 2024Electrical system. The customer states there is a Drivetrain Malfunction message displayed in the instrument cluster. In addition, the following fault memory entries are saved in the CCU (Combined Charging Unit) 0317F2 - High-voltage system, insulation fault detected: when switch contactors are closed. 0317F1 - High-voltage system, insulation resistance below warning threshold: when switch contactors are closed.
• 11012093Dec 9, 2024Electrical system. Quality checks have determined that the coolant changeover valve may develop a coolant leak undervery low outside temperatures (significantly lower than 32º F (0 C)).
• 11008992Oct 11, 2024Brakes. Improved diagnostic software for the brake system.
• 11008114Sep 24, 2024Electrical system. A manufacturing defect in high-voltage cells of the high-voltage battery can result in electrolyte leakage which might result in a conductive connection with surrounding components. Depending on the contact resistance, a yellow or red Check Control message will then be displayed; it is permitted for you to continue driving, but this will result in a charging interruption during charging.
• 11006742Aug 10, 2024Electrical system. Replace Cell Modules
• 11006734Aug 7, 2024Electrical system. Customer states they started to receive Check Control messages for the driver’s seat at the end of eachdriving cycle: One or more of the following check control messages (CCM) were present at that time: CCM 434 Seat calibration required. CCM 108 Driver restraint system. Eventually multiple restarts after they first noticed the CCM the seat stopped functioning, the air bag warninglamp illuminated in the instrument…
• 11005450Jul 31, 2024Electrical system. The seat initialization and memory has been lost; Or Repeat failure of seat initialization after completing the test module via ISTA. One or both of the following check control messages (CCM) may be present: CCM 108 “Driver restraint system” CCM 109 “Passenger restraint system”
• 11005226Jul 13, 2024Transmission and drivetrain. While driving at low speeds (15-40 mph) on flat road surfaces, a knocking noise from the front axle may beheard during steering wheel movements.
• 11005236Jul 12, 2024Engine. Quality checks have determined that the coolant changeover valve may develop a coolant leak under very low outside temperatures (significantly lower than 32º F (0 C)).
• 11005233Jul 10, 2024Body and structure. When driving over rough surfaces, a low-frequency rattling noise can be heard inside the vehicle's cabin.The noise typically sounds as though it is coming from the front right footwell area.
• 11002669Jun 17, 2024Other or unknown. A drumming noise is heard when the air conditioning system is operating.
• 11000512May 24, 2024Engine. Quality checks have determined that the coolant changeover valve may develop a coolant leak under very low outside temperatures (significantly lower than 32º F (0 C)).
• 11000510May 23, 2024Engine. Delivery stop: coolant changeover valve
• 10253344Apr 26, 2024Engine cooling. There is coolant leaking from under the car Low heater output Possible Check Control message “Drive, you can continue driving” (ID49) Possible fault codes stored in these BEV vehicles: 224163 – Electric auxiliary heater for the high-voltage battery unit: Undervoltage or internal communication fault 8049AA - Coolant level sensor, expansion tank: Coolant level low or short circuit to…
• 10252133Mar 27, 2024Electrical system. When the interior temperature of the vehicle is between 5 F (-15 C) and 23 F (-5 ), the defroster function is limited; and the interior doesn’t heat up quickly enough.
• 10252015Mar 22, 2024Seats, Seat belts, Air bags. The seat initialization and memory has been lost; Or Repeat failure of seat initialization after completing the test module via ISTA. One or both of the following check control messages (CCM) may be present: CCM 108 “Driver restraint system” CCM 109 “Passenger restraint system”
• 10252029Mar 15, 2024Electrical system. This Informational Bulletin is intended as a guided work-through process to address customer charging complaints. The step-by-step guide will help walk you through the “basic” procedure to test the charger/infrastructure when the vehicle does not charge, either at a: Home charger AC Level 1/Level 2 - Flexible Fast Charger/hard wired Wallbox, or a Public AC Level 2, or DC Level 3 - Fast Charging Station…
• 10252032Mar 12, 2024Equipment, Visibility (wipers, defrost, mirrors). A squeaking sound is heard when folding either of the exterior mirrors assemblies in or out.
• 10252041Mar 8, 2024Equipment. 1. The center air vent on the left (a) is closed. All other air vents on the left side then only blow cold air intothe passenger area. OR 2. Both center (b) air vents are closed. All other air vents then only blow cold air into the passenger area. OR 3. The center air vent on the right (c) is closed. All other air vents on the right side then only blow cold airinto the passenger area.
• 10252039Mar 4, 2024Electrical system. This Informational Bulletin is intended as a guided work through process to address BEV/PHEV charging issues. The step-by-step guide will help walk you through the correct “basic” steps that should be followed when addressing and diagnosing battery electric vehicles (BEV) and plug in hybrid vehicles (PHEV) charging issues.
• 10250894Feb 26, 2024Equipment. When driving over rough surfaces, a low-frequency rattling noise can be heard inside the vehicle's cabin. The noise typically sounds as though it is coming from the front right footwell area.
• 10250603Feb 20, 2024Other or unknown, Visibility (wipers, defrost, mirrors). A drumming noise is heard when the air conditioning system is operating.
• 10250361Feb 6, 2024Transmission and drivetrain. The customer states there is a Drivetrain Malfunction message displayed in the instrument cluster. In addition, the following fault memory entries are saved in the CCU (Combined Charging Unit) 0317F2 - High-voltage system, insulation fault detected: when switch contactors are closed. 0317F1 - High-voltage system, insulation resistance below warning threshold: when switch contactors are closed.
• 10250367Feb 5, 2024Engine cooling, Electrical system. The coolant changeover valve may develop a coolant leak when the outside temperatures go below 19°F (-7°C). The vehicles operating systems would also need to be at that same low temperature (example: being parked outside, overnight in low temperatures).
• 10250365Feb 1, 2024Electrical system. Gen 5 BEV/PHEV vehicles may set the Combined Charging Unit (CCU) in programming abort due to nocommunication to the HV charge socket electronics.
• 10249421Jan 26, 2024Engine cooling. The coolant changeover valve may develop a coolant leak when the outside temperatures go below 19°F (-7°C). The vehicles operating systems would also need to be at that same low temperature (example: being parked outside, overnight in low temperatures).
• 10249027Jan 11, 2024Electrical system. The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. This document covers important information for the dealer on how to handle “discharged battery” complaints.
• 10249030Jan 9, 2024Equipment. A drumming noise is heard when the air conditioning system is operating. Service parts are not yet available for this repair. This bulletin will be updated once the service repair is ready.
• 10249026Jan 4, 2024Equipment. The washer fluid reservoir mounting hook has too much play, which allows the reservoir to vibrate and cause a noise.

← All problems reported for the 2024 BMW I5