2018 BMW X1 Technical Service Bulletins

98 technical service bulletins (TSBs) are on record for the 2018 BMW X1. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10176377May 1, 2020Electrical system. CCM DISPLAYED "INCREASED BATTERY DRAIN" CAUSED BY CONTROLLER: A yellow CCM (Check Control Message) ID 415 is displayed- "Increased battery drain! // Battery. Electrostatic discharge at standstill / start engine. Energy management" The results of the Energy Diagnosis test plan identifies the Controller as the root cause of the CCM. The Controller delays the vehicle going to sleep by up to 6 minutes. In some cases…
• 10176363May 1, 2020Engine cooling. TANK VENTILATION AND MIXTURE CONTROL FAULTS STORED IN THE DME: The Engine Malfunction Warning is illuminated and one or more of the following faults are stored in the DME.
• 10176362May 1, 2020Electrical system, Exterior lighting. ROUGH RUNNING IMMEDIATELY AFTER A COLD START: Immediately after a cold start the engine may run roughly during the catalyst heating period.
• 10174320Apr 1, 2020Electrical system, Equipment. CONNECTEDDRIVE/BMW ASSIST SYSTEM DIAGNOSIS INFORMATION: This Service Information Bulletin (Revision 7) replaces SI B84 02 14 dated May 2019. ConnectedDrive/BMW Assist features are partially or completely inoperative. This Service Information Bulletin: Is being published because vehicles are down for an extended period of time when researching system failures with ConnectedDrive or BMW Assist. Will assist you both…
• 10174032Apr 1, 2020Equipment. AUTOMATED ACTIVATION OF NAVIGATION SYSTEM DURING PDI/QC1: This Service Information Bulletin (Revision 2) replaces SI B65 22 14 dated October 2015. The INITIAL NAV enabling code no longer needs to be pre-ordered through the Parts department!
• 10174023Apr 1, 2020Electrical system, Steering, Electronic stability control, Suspension. CHECK CONTROL MESSAGES FOR BRAKE SUSPENSION AND AIR BAG SYSTEM MALFUNCTION: Multiple check control messages (CCM) can display for brake suspension and air bag system malfunction.
• 10174020Apr 1, 2020Vehicle speed control. TAILGATE MALFUNCTION WHEN OPENING OR CLOSING: This Service Information Bulletin (Revision 1) replaces SI B61 06 20 dated February 2020.
• 10174019Apr 1, 2020Engine. CCM DISPLAYED "INCREASED BATTERY DRAIN" CAUSED BY CONTROLLER: This Service Information Bulletin (Revision 1) replaces SI B61 05 20 dated February 2020. Electrostatic discharge at standstill / start engine. Energy management" The results of the Energy Diagnosis test plan identifies the Controller as the root cause of the CCM. The Controller delays the vehicle going to sleep by up to 6 minutes. In some cases this…
• 10174015Apr 1, 2020Brakes, Air bags. TAILGATE UNINTENTIONALLY OPENS: This Service Information Bulletin (Revision 4) replaces SI B51 30 16 dated March 2018. Trunk/tailgate may open when vehicle is locked Trunk/tailgate may open while the vehicle is in motion usually after stopping such as a traffic light etc. Vehicle key trunk/tailgate button may be accidentally pressed thus opening the tailgate.
• 10172510Feb 1, 2020Seat belts. SAFETY BELT WARNING GONG SOUNDS AFTER UNBUCKLING WHILE VEHICLE IS STATIONARY. After a vehicle has been programmed to an I-level greater than 19-11-5xx and lower than I-level 20-03-530; the safety belt (aka seat belt) acoustic warning sounds when in Park (engine running) and the safety belt is unbuckled. The chime/gong lasts for up to 1 minute 40 seconds. The customer only expects the acoustic warning when the…
• 10172500Feb 1, 2020Engine cooling. Water Ingress In Footwell Area From A/C Condensate Drain: This Service Information Bulletin (Revision 1) replaces SI B64 04 16 dated March 2016. The condensate drain hose is blocked by the heat shield The condensate drain hose is not attached properly to the housing The condensate drain hose was damaged during installation
• 10172498Feb 1, 2020Electrical system, Latches, locks and linkages. TAILGATE MALFUNCTION WHEN OPENING OR CLOSING. Customer may complaint of any the following scenarios: When operating the tailgate by using any of the tailgate buttons the movement stops Tailgate opens when the remote control is within the proximity of the rear of the vehicle and a second person opens any of the doors using the outside door handle Tailgate opens again immediately after closing Erroneous ground signal…
• 10172497Feb 1, 2020Electrical system. CCM DISPLAYED "INCREASED BATTERY DRAIN" CAUSED BY CONTROLLER. A yellow CCM (Check Control Message) ID 415 is displayed- "Increased battery drain! // Battery. Electrostatic discharge at standstill / start engine. Energy management" The results of the Energy Diagnosis test plan identifies the Controller as the root cause of the CCM. The Controller delays the vehicle going to sleep by up to 6 minutes. In some cases…
• 10172489Feb 1, 2020Electrical system, Equipment. MIL LIGHT ILLUMINATED AT LOW AMBIENT TEMPERATURES. After engine start the malfunction indicator lamp (MIL) and Check Control message (ID 29) "Engine fault! Power loss" are displayed in the instrument cluster. In addition The following fault codes are stored in the Digital Motor Electronics (DME) Engine runs in failsafe mode Engine cannot exceed 800 - 1200 RPMs.
• 10171488Jan 1, 2020Steering, Electrical system. Power-assisted Steering Intermittently Not Available at Engine Start-up: This Service Information Bulletin (Revision 1) replaces SI B32 02 14 dated November 2016. The power-assisted steering is unavailable at start up/drive readiness. No communication with the Electric Power Steering (EPS).
• 10171485Jan 1, 2020Engine cooling, Electrical system. DME FAULT CODE 1B8004 ENVIRONMENTAL AIR CATALYST(EAC) SENSOR: This Service Information Bulletin (Revision 1) replaces SI B13 02 18 dated April 2018. The Malfunction Indicator Lamp (MIL) light is on and the following fault code is stored in the DME: 1B8004 - EAC Sensor: Temperature - Engine coolant temperature radiator outlet comparison to each other implausible DME software calibration error for EAC sensor…
• 10171479Jan 1, 2020Engine cooling. MALFUNCTION INDICATOR LAMP IS ILLUMINATED WITH A CRANKSHAFT ADAPTION FAULT: When diagnosing an illuminated malfunction indicator lamp (MIL) and/or a different issue the following faults may also be stored in the Digital Motor Electronics (DME). Fault code Control module Fault code text 213A2B DME Increment wheel adaption faulty This situation is not associated with any drivability complaints and only affects…
• 10171414Jan 1, 2020Air bags. SIDE PANEL REAR LIGHT HOUSINGS: LTD WTY EXT TO 10 YEARS WITHOUT MILEAGE LIMIT: The rear light housing(s) can loosen/detach at the mounting tabs this can cause a clacking sound in the rear of the vehicle while driving. The plastic mounting tabs for the rear tail light assembly housing(s) may become too brittle and crack to the point where the hold down nut(s) can no longer keep the housing(s) in place.
• 10170580Dec 1, 2019Seats. NOISE DURING FORWARD / BACK SEAT ADJUSTMENT OVER THE ENTIRE LENGTH OF TRAVEL: A loud screeching noise can be heard from the front driver's or passenger's seat during forward/back seat adjustment.
• 10145338Jul 1, 2018Engine cooling. THE DISPLAY GOES BLACK, VEHICLE DOESNT START AGAIN AFTER SWITCHING THE ENGINE OFF.: On board computer and navigation system goes black or resets.
• 10145321Jul 1, 2018Equipment. PHONE CONTACTS: HEADUNIT BASIC 2 SORTING ORDER: Improper sorting of phone contacts, in the on-board computer or in the Central Information Display (CID), upon connecting to the vehicle:
• 10145320Jul 1, 2018Equipment. CONNECTEDDRIVE/BMW ASSIST SYSTEM DIAGNOSIS INFORMATION: ConnectedDrive/BMW Assist features are partially or completely inoperative.
• 10145317Jul 1, 2018Latches, locks and linkages. DEACTIVATION OF CONTACTLESS TAILGATE OPENING AND CLOSING: Customer desires to have contactless tailgate opening and closing (Smart Opener) deactivated.
• 10145283Jul 1, 2018Engine, Engine cooling. BUZZING NOISE FROM VALVETRONIC MOTOR BEFORE OR AFTER ENGINE OPERATION: Buzzing noise may be heard from the Valvetronic motor when the vehicle is unlocked, before the engine is started, or after the engine is turned off.
• 10145316Jun 1, 2018Equipment. COMPONENT PROTECTION ACTIVE. HEAD UNITS CANNOT BE SWAPPED BETWEEN VEHICLES FOR TESTING.: If either the head unit (NBT-EVO or ENTRY-NAV-EVO) or the Body Domain Controller (BDC) are swapped into a different vehicle they will cause the head unit to enter a locked mode once it recognizes a different VIN.
• 10145306Jun 1, 2018Equipment. NAVIGATION SYSTEM: REPORTING MISSING OR INCORRECT ROAD MAP DATA: The route guidance is inaccurate and therefore irritating to the customer; or it is not possible to locate certain addresses, for instance:
• 10145298Jun 1, 2018Seats. MEMORY SEAT ADJUSTMENT IS LIMITED: After programming the vehicle with ISTA 4.10.2x, the adjustment range of the memory seat may restricted.
• 10143569May 1, 2018Electrical system, Equipment. BMW ONLINE NON-FUNCTIONAL: CHECK ICC-ID IN ACCOUNT: BMW Online/BMW ConnectedDrive not functional.
• 10143565May 1, 2018Equipment. NAVIGATION PRO (NBT EVO) MAP UPDATE NOT POSSIBLE, NAVIGATION DOES NOT START: Navigation system will not start at all or the: ÒNavigation system startsÓ message is permanently displayed; or
• 10143564May 1, 2018Equipment. NAVIGATION SYSTEM: REPORTING MISSING OR INCORRECT ROAD MAP DATA: The route guidance is inaccurate and therefore irritating to the customer; or it is not possible to locate certain addresses, for instance:
• 10138410Apr 1, 2018Equipment. IPHONE: CALL LIST MISSING AFTER RESTART: The call list from iPhone 8 or iPhone X, that is displayed, is missing after cycling the ignition.
• 10138407Apr 1, 2018Equipment, Electrical system. CHECK CONTROL STATES REMOTE KEY IS MISSING WHEN THE KEY IS LOCATED IN THE VEHICLE: Only affects vehicles that have been programmed with ISTA 4.10.1x and I-level 18-03-511 or 18-03-576
• 10138402Apr 1, 2018Electrical system. INSTRUMENT CLUSTER OUTSIDE TEMPERATURE DISPLAY IMPLAUSIBLE: In the Instrument Cluster (Kombi) display you may observe an implausible outside temperature reading.
• 10138400Apr 1, 2018Electrical system. BASIC INSTRUMENT CLUSTER: DATE ERRONEOUSLY ADJUSTS BY ITSELF: The calendar date in the instrument cluster adjusts itself forward approximately one to two days.
• 10138398Apr 1, 2018Equipment, Electrical system. HORN VIBRATES WHEN BEING USED: When the horn is being used, it vibrates and causes a buzzing/droning noise
• 10138396Apr 1, 2018Body and structure, Engine. HUMMING NOISE DURING SMOOTH ACCELERATION: A humming, vibration noise is heard during smooth acceleration to 2000 rpm.
• 10136359Mar 1, 2018Equipment, Electrical system. VEHICLES WITH ENTRY NAVIGATION MAP 2017-2 ABORT PROGRAMMING: While installing the 2017-2 Europe and North America maps update with ISTA 4 software older than 4.08.3x, the installation aborts before finishing.
• 10136355Mar 1, 2018Exterior lighting. HEADLIGHT ASSEMBLIES HAVE VISIBLE INTERNAL MOISTURE/CONDENSATION: Water on the inside (A) or misting (B) of both headlight lenses that is visible from outside.
• 10136345Mar 1, 2018Equipment, Seats. EXPOSED FOAM IS VISIBLE UNDER THE FRONT SEAT: Exposed foam is visible under the optional front sport seat or in rear footwell as shown in the picture.
• 10136344Mar 1, 2018Latches, locks and linkages. TAILGATE UNINTENTIONALLY OPENS: Trunk/tailgate may open when vehicle is locked.
• 10136333Mar 1, 2018Electrical system. ROUGH RUNNING AND VARIOUS VANOS FAULTS STORED: The check engine light is illuminated and the vehicle may run rough at idle and while driving.
• 10136000Mar 1, 2018Equipment. CONNECTEDDRIVE-REMOTE SERVICES DO NOT FUNCTION: Remote Services (such as locking and unlocking the car, vehicle location by honking the horn, flashing the lights or on the map in the BMW Connected App) do not function after vehicle has been sitting for extended amount of time (In excess of 20 hours).
• 10135998Mar 1, 2018Equipment. BLUETOOTH AND USB AUDIO PLAYBACK FUNCTIONS MISSING - IPHONE: Playlists, song titles, etc. from iPhone do not display on Head Unit Basic 2.
• 10135995Mar 1, 2018Equipment. CONTACTLESS TAILGATE (SMART OPENER) IS TOO SENSITIVE: When the remote is located in the range of the Smart Opener operation may be the contactless tailgate (Smart Opener) opens / close unintentionally from objects in the vicinity of the rear of the vehicle; for example by a gas filling hose.
• 10142945Jan 1, 2018Equipment. Bluetooth Connection Failures: There are various connectivity failures with the following devices: Apple iPhones: Samsung S6 and the S6 Edge.
• 10142942Jan 1, 2018Electrical system. REMOTE KEY WILL NOT OPEN OR START VEHICLE: Remote key battery in service significantly less (under a year) than expected two-year life-span.
• 10142933Jan 1, 2018Body and structure. TAILGATE UNINTENTIONALLY OPENS: Trunk/tailgate may open when vehicle is locked.
• 10136739Nov 1, 2017Equipment. ENTRY EVO HEAD UNIT WILL NOT PLAY MP3 FORMATTED CD's: Data CDÕs (encoded as MP3Õs) can NOT be played.

← All problems reported for the 2018 BMW X1