2020 BMW X1 Fuel system Problems
- Complaints
- 3about this part
- Share
- 23%of 13 total for the year
- Median mileage
- 67,000miles
- Trend
- Not enough dataFewer than 15 complaints, too few for a reliable trend.
NHTSA recorded 3 complaints about the fuel system of the 2020 BMW X1, 23% of the 13 complaints for this model year. Where a mileage was given, the median is 67,000 miles.
Fewer than 15 complaints name this part, so treat the figures as a rough indication only.
Example complaints
Selected from NHTSA records; personal details are removed. They are consumer reports, not findings.
“Check Engine light checked at dealership revealed Fuel in the NVLD System! They had to replace the NVLD, Charcoal canister, and the Tank vent valve. They accused me of overfilling my fuel tank! I am 100% certain that I NEVER overfill fuel whatsoever. I am afraid this may cause other drivers to ignore the problem resulting in vehicle fires! Please investigate further or ask for repair frequency of this problem from BMW. I owned a BMW for almost 20 years and never experienced this problem! Thanks”
NHTSA complaint #11577034, filed 2024-03“The contact owns a 2020 BMW X1. The contact stated that while driving 75 MPH, the vehicle suddenly decelerated to 10 MPH. There was no warning light illuminated. During the failure, the messages, Chassis Stabilization: Drive Moderately, Collision Warning System Malfunction, Pedestrian Warning Reduced, and Drivetrain: Continued Driving Possible were displayed. The vehicle was pulled over into a remote emergency lane and driven 10 miles to an exit. The vehicle was towed to the dealer, where it was diagnosed with a short circuit to ground at the throttle body. …”
NHTSA complaint #11753485, filed 2026-07, 67,000 miles“The fuel tank got punctured on the freeway causing the car to lose power. The problem seems that BMW plastic fuel tank is located on the right side at the bottom of the car so any stone or particle on the freeway can puncture the plastic tank from the bottom causing no fuel and the car losing power. Seems like that is problem with design and BMW is aware of it since the new models of the car starting 2023 have an extra underbody protection for the fuel tank which is missing on the previous year models.”
NHTSA complaint #11666751, filed 2025-06Related service bulletins
- 10247567Dec 20, 2023Engine will crank but not start. There is no communication with the integrated fuel module (TFE) whendiagnosing with ISTA. The following two fault codes will be stored in the…
- 10178993Jul 1, 2020NOISES FROM THE FUEL TANK AT IDLE: All vehicles except the F48 (X1): While driving slowly with low RPM or while idling a faint knocking or fluttering noise can be heard from…
- 10177614Jun 1, 2020F48 FUEL TANK VENT/PURGE VALVE LTD WARRANTY EXTENSION: This component-specific limited warranty extension applies to defects in materials or workmanship.
Fuel system: other model years
Other parts of the 2020 BMW X1
4 complaintsEngine
3 complaintsBrakes
2 complaintsElectrical system
2 complaintsOther or unknown
2 complaintsSeat belts
2 complaintsAir bags
1 complaintsBack-over prevention (rear camera)
1 complaintsVehicle speed control
1 complaints
← All problems reported for the 2020 BMW X1
About this data. Data from NHTSA (ODI) complaints, recalls, TSBs and investigations, updated Oct 30, 2026. Complaints are unverified consumer reports and may be duplicated or inaccurate.
To check a specific vehicle for open recalls, use its VIN at nhtsa.gov/recalls. Methodology