2019 BMW X4 Technical Service Bulletins

273 technical service bulletins (TSBs) are on record for the 2019 BMW X4. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10174032Apr 1, 2020Equipment. AUTOMATED ACTIVATION OF NAVIGATION SYSTEM DURING PDI/QC1: This Service Information Bulletin (Revision 2) replaces SI B65 22 14 dated October 2015. The INITIAL NAV enabling code no longer needs to be pre-ordered through the Parts department!
• 10174031Apr 1, 2020Equipment, Electrical system. DISPLAYS SPORADICALLY REACT VERY SLOWLY WHEN SCROLLING IN THE AUDIO MENU: Sporadically the reaction time of the display in the instrument cluster the head-up display or in the CID (Central Information Display) is very long. This can occur when browsing/scrolling through lists in the audio menu switching radio stations or albums. Software in the Head Unit High (HU-H3).
• 10174027Apr 1, 2020Air bags, Electrical system, Exterior lighting. DAYTIME RUNNING LIGHT IS DIM OR DISCOLORED: This Service Information Bulletin (Revision 2) replaces SI B63 04 18 dated January 2019. One or more of the LED daytime running lights are dim or discolored. The connection between the LED module and light tube inside the headlight is damaged.
• 10174019Apr 1, 2020Engine. CCM DISPLAYED "INCREASED BATTERY DRAIN" CAUSED BY CONTROLLER: This Service Information Bulletin (Revision 1) replaces SI B61 05 20 dated February 2020. Electrostatic discharge at standstill / start engine. Energy management" The results of the Energy Diagnosis test plan identifies the Controller as the root cause of the CCM. The Controller delays the vehicle going to sleep by up to 6 minutes. In some cases this…
• 10174017Apr 1, 2020Visibility (wipers, defrost, mirrors), Back-over prevention (rear camera). KNOCKING NOISE FROM WASHER FLUID RESERVOIR: When driving over uneven pavement or cobblestones a knocking noise is present from the passenger side front area (A pillar). Once the vehicle is driven on a flat even surface; the noise is no longer present. CAUSE Washer fluid reservoir movement caused by mounting bracket clearance.
• 10174015Apr 1, 2020Brakes, Air bags. TAILGATE UNINTENTIONALLY OPENS: This Service Information Bulletin (Revision 4) replaces SI B51 30 16 dated March 2018. Trunk/tailgate may open when vehicle is locked Trunk/tailgate may open while the vehicle is in motion usually after stopping such as a traffic light etc. Vehicle key trunk/tailgate button may be accidentally pressed thus opening the tailgate.
• 10174011Apr 1, 2020Equipment. UNINTENDED HATCH ACTIVATION AFTER CONVERSION: The hatch may unintentionally open.
• 10174009Apr 1, 2020Transmission and drivetrain, Brakes, Wheels, Back-over prevention (rear camera). TICKING NOISE WHILE CORNERING WITHOUT THE BRAKES APPLIED: This Service Information Bulletin (Revision 3) replaces SI B34 05 17 dated September 2017. Ticking noise coming from front wheel while cornering without brakes applied noticeable at low speeds. The vehicle must be moving. See attached video V34 01 20 Note: For a similar noise heard when parking with the brakes applied refer to SIB 31 01 12.
• 10172497Feb 1, 2020Electrical system. CCM DISPLAYED "INCREASED BATTERY DRAIN" CAUSED BY CONTROLLER. A yellow CCM (Check Control Message) ID 415 is displayed- "Increased battery drain! // Battery. Electrostatic discharge at standstill / start engine. Energy management" The results of the Energy Diagnosis test plan identifies the Controller as the root cause of the CCM. The Controller delays the vehicle going to sleep by up to 6 minutes. In some cases…
• 10172487Feb 1, 2020Engine cooling. ENGINE OIL FILTER INSERT IS DIFFICULT TO REMOVE - REMOVAL: This Service Information Bulletin (Revision 1) replaces SI B11 01 20 dated February 2020. On rare occasions during an engine oil service the BMW Original (Genuine) engine oil filter insert is either difficult to remove or breaks apart in the oil filter housing. The engine oil filter is broken. The paper is torn and the lower plastic section is stuck in the…
• 10171503Jan 1, 2020Electrical system. REMOTE 3D VIEW NOT AVAILABLE: Remote 3D View cannot be launched In the BMW ConnectedDrive App. Software error in the Advanced Telematics Module 2 (ATM2).
• 10171502Jan 1, 2020Electrical system. BMW CONNECTEDDRIVE SERVICES ARE NOT AVAILABLE: The BMW ConnectedDrive services are not available for an extended period. This may include: Calls in the BMW Assistance app (Concierge Service) Vehicle data and status in the BMW ConnectedDrive app Remote services Remote 3D View Real Time Traffic Information (RTTI) Weather News Software error in Advanced Telematics Module 2 (ATM2).
• 10171500Jan 1, 2020Electrical system, Steering. LDW (LANE DEPARTURE WARNING): STEERING WHEEL VIBRATION NOT STRONG This Service Information Bulletin (Revision 2) replaces SI B66 21 19 dated December 2019. Lane Departure Warning (LDW) steering wheel vibration is perceived as being not strong enough even with the strongest setting selected via the iDrive menu. Software in the vibration actuator and /or steering wheel component.
• 10171498Jan 1, 2020Back-over prevention (rear camera), Electrical system. REAR VIEW CAMERA FAILS TO DISPLAY IMAGE: This Service Information Bulletin (Revision 5) replaces SI B66 08 17 dated March 2018. Sporadically when the rear view camera is activated no image appears in the display. The rear view camera can be activated by either: 1. Selecting reverse with the shift selector 2. Camera activation via the button on the center console Camera function returns after a terminal change…
• 10171479Jan 1, 2020Engine cooling. MALFUNCTION INDICATOR LAMP IS ILLUMINATED WITH A CRANKSHAFT ADAPTION FAULT: When diagnosing an illuminated malfunction indicator lamp (MIL) and/or a different issue the following faults may also be stored in the Digital Motor Electronics (DME). Fault code Control module Fault code text 213A2B DME Increment wheel adaption faulty This situation is not associated with any drivability complaints and only affects…
• 10170591Dec 1, 2019Back-over prevention (rear camera), Lane departure. TOP VIEW CAMERA: IMAGE IS MISALIGNED. The top view image of the vehicle is misaligned when observed in the Control Information Display (CID). When the vehicle is parked in a parking spot with line markings it is clearly noticed in the CID that the lines are not parallel to the side of the vehicle. This may be noticed on either the driver side passenger side or both. The arrow identifies the line which is shown as…
• 10170590Dec 1, 2019Lane departure, Steering. LDW (LANE DEPARTURE WARNING) STEERING WHEEL VIBRATION NOT STRONG: Lane Departure Warning (LDW) steering wheel vibration is perceived as being not strong enough even with the strongest setting selected via the iDrive menu. Software in the vibration actuator and /or steering wheel component.
• 10170589Dec 1, 2019Brakes. INCORRECT CONDITION BASED SERVICE DATA FOR BRAKE FLUID SERVICE. "Brake fluid service due since 12/2001" is displayed in the instrument cluster although the vehicle is only a maximum of 1 year old. Software error in the KOMBI (Instrument Cluster).
• 10170588Dec 1, 2019Electrical system. INSTRUMENT CLUSTER REMAINS DARK AFTER STARTING THE VEHICLE: Instrument cluster remains dark after starting the vehicle. After a restart normal functionality is restored. Software error in the KOMBI (Instrument Cluster).
• 10170587Dec 1, 2019Electrical system. COMPASS NO LONGER VISIBLE IN THE KOMBI AFTER PROGRAMMING: Integration level updated. Customer noticed that their compass display was deleted from the Instrument Cluster (KOMBI) after recent programming. It still appears in the CID widget display. Software error in the KOMBI.
• 10170572Dec 1, 2019Electrical system. ENGINE DOES NOT START BELOW FREEZING TEMPERATURES: Engine designation correction Parts availability Warranty. The engine will not start at temperatures below freezing. The starter does not turn and engage.
• 10170569Dec 1, 2019Exterior lighting, Engine cooling. MALFUNCTION INDICATOR LAMP IS ILLUMINATED WITH A CRANKSHAFT ADAPTION FAULT: When diagnosing an illuminated malfunction indicator lamp (MIL) and/or a different issue the following faults may also be stored in the Digital Motor Electronics (DME).
• 10169474Nov 1, 2019Equipment. NO AUDIO IS AVAILABLE FOR APPROXIMATELY 30 SECONDS AFTER HEAD UNIT START UP: After programming vehicle no audio is available for approximately 30 seconds after head unit start-up. Fault code B7F490 "Control unit reset" is present in the RAM (Receiver Audio Module).
• 10169472Nov 1, 2019Equipment, Electrical system. ENGINE SPEED DEPENDENT NOISE DURING AUDIO PLAYBACK: Integration level updated. There is an engine speed-dependent noise heard through the speakers during audio playback. Software error in the Receiver Audio Module (RAM) control unit.
• 10169469Nov 1, 2019Equipment, Electrical system. INSTRUMENT CLUSTER AND ONBOARD COMPUTER INTERMITTENTLY INOPERATIVE: Instrument Cluster (KOMBSP18) functions are intermittently inoperative including: On-board Computer (BC) button on turn signal stalk (BC button shown at left) Radio displays Menu button Turn signal displays Arrows on multifunction steering wheel MFL thumbwheel control.
• 10169468Nov 1, 2019Equipment, Visibility (wipers, defrost, mirrors). Low Washer Fluid Warning Light is illuminated when the Washer Fluid Tank is Full : The low washer fluid warning is illuminated even though the washer fluid reservoir is full. There are no faults stored in the system for the washer fluid level switch. A non-approved washer fluid was used that is silicone-based. Silicone-based fluids are not compatible with the contactless capacitive level sensor. Fluids that contain…
• 10168013Oct 1, 2019Steering. LDW (LANE DEPARTURE WARNING): STEERING WHEEL VIBRATION NOT STRONG. LDW steering wheel vibration is perceived as being not strong enough, even with the strongest setting selected via the iDrive menu. Software in the vibration actuator and /or steering wheel component.
• 10168011Oct 1, 2019Brakes. ACTIVE PARK DISTANCE CONTROL (PDC): UNDESIRED BRAKING. This Service Information Bulletin (Revision 1) replaces SI B66 17 19 dated August 2019. What's New: Procedure - changed ISTA version. The vehicle applies the brakes on its own when reversing onto an inclined roadway or driveway. This applies only to the situation where the Active PDC option is activated via the iDrive.
• 10168006Oct 1, 2019Transmission and drivetrain. SERVICE ACTION: REPLACE THE GEAR SELECTOR SWITCH (GWS). The functional lighting and/or locator lighting on the shifter selector lever (aka gear selector switch GWS) may flicker over time, or intermittently not illuminate. The GWS may not have been produced to specifications.
• 10166390Sep 1, 2019Electrical system. HEAD UNIT NBT EVO (HU-H2) PROGRAMMING ABORT: The CID screen may light up blue. When this occurs A battery reset is not successful in restoring head unit operation Software error in the Bootloader file (BTLD) of the head unit.
• 10166388Sep 1, 2019Electrical system. JUNCTION BOX REAR FAULT STORED IN BODY DOMAIN CONTROLLER: Fault code 804075 "JBR_LIN: relay 30F1-status contradiction" is stored in the Body Domain Controller (BDC). The fault entry has no effect is not noticeable in the customer perception nor in function impairments. Software error in the Junction Box Rear (JBR_LIN).
• 10166385Sep 1, 2019Electrical system. DELIVERY STOP: REPLACE THE GEAR SELECTOR SWITCH: The functional lighting and/or locator lighting on the Shifter selector lever (GWS) may flicker over time or intermittently not illuminate. The GEAR SELECTOR SWITCH may not have been produced to specifications.
• 10166383Sep 1, 2019Equipment, Visibility (wipers, defrost, mirrors), Body and structure. SUNROOF WATER LEAK DIAGNOSIS: This bulletin outlines multiple known areas of possible water entry for the vehicles listed above. It serves only as a diagnostic resource in troubleshooting water leak complaints from the roof area.
• 10166373Sep 1, 2019Seat belts. FALSE WARNINGS THAT THE FRONT PASSENGER SEAT IS OCCUPIED WITHOUT THE SEAT BELT BUCKLED: Acoustic and visual warnings indicate that the front passenger seat is occupied and the safety belt is not fastened when the seat is actually unoccupied.
• 10166371Sep 1, 2019Electrical system. DRIVERS ASSISTANCE SYSTEM: CHECK CONTROL MESSAGE IS DISPLAYED. The Driver Assistance System limited warning message is displayed.
• 10166231Sep 1, 2019Equipment. ACTIVE AIR FLAP FAULT DIAGNOSIS AND REPAIR: This correction is to be used for all situations where the following fault codes are stored: 138402 279B00 138220 13820D 13820E.
• 10166229Sep 1, 2019Suspension. Front Suspension Ride Height Has Dropped: The front suspension ride height has dropped on one or both sides due to overload. This is caused by driving over obstacles (e.g. potholes) or an impact severe enough for the front spring strut damper to slip through the clamp of the steering knuckle.
• 10165284Aug 1, 2019Equipment. ACTIVE AIR FLAP FAULT DIAGNOSIS AND REPAIR. This Service Information Bulletin (Revision 2) replaces SI B51 21 19 dated August 2019. A check control message or MIL (Malfunction Indicator Lamp) may be illuminated with faults stored related to the upper and/or lower active air flap(s).
• 10165268Aug 1, 2019Back-over prevention (rear camera), Brakes. ACTIVE PARK DISTANCE CONTROL (PDC): UNDESIRED BRAKING. The vehicle applies the brakes on its own when reversing onto an inclined roadway or driveway. This applies only to the situation where the Active PDC option is activated via the iDrive. Software of the ultrasonic sensors and PDC control unit.
• 10165266Aug 1, 2019Equipment. SECURITY IMPROVEMENTS FOR CONNECTEDDRIVE. Security patches for non-safety critical vulnerabilities in BMW head units Entry Nav Entry Media NBT and NBT EVO.
• 10165261Aug 1, 2019Equipment. Delivery stop: gear selector switch.
• 10165245Aug 1, 2019Brakes. ACTIVE PARK DISTANCE CONTROL (PDC): UNDESIRED BRAKING. The vehicle applies the brakes on its own when reversing onto an inclined roadway or driveway. This applies only to the situation where the Active PDC option is activated via the iDrive. Software of the ultrasonic sensors and PDC control unit.
• 10163057Jun 1, 2019Electrical system. COMFORT ACCESS AND COMFORT GO NOT POSSIBLE. Vehicle cannot be opened/locked or started via Comfort Access. Electrostatic charge puts the remote control key into a deep sleep.
• 10163056Jun 1, 2019Electrical system. HEAD UNIT NBT EVO (HU-H2) PROGRAMMING ABORT. During programming several aborts can occur in the head unit NBT EVO (HU-H2).
• 10163051Jun 1, 2019Electrical system. DIGITAL SPEEDOMETER MISSING FROM THE INSTRUMENT CLUSTER AFTER PROGRAMMING. The digital speed display from the left side of the gauges is missing in the Instrument Cluster (KOMBI) after ISTA 4.14.1x programming.
• 10163037Jun 1, 2019Electrical system. Various check control messages for driver assistance systems.
• 10163027Jun 1, 2019Engine cooling, Engine. ENGINE VIBRATIONS OR NOISE This Service Information bulletin replaces SI B11 01 19 dated February 2019.
• 10161581May 1, 2019Electrical system, Equipment. BLUETOOTH CONNECTION IS LOST DURING A PHONE CALL. During an active call the call audio autonomously switches from the vehicle hands-free system to the phone.
• 10161579May 1, 2019Equipment. Telematics control unit activation via dcsnet for bmw assist.
• 10161578May 1, 2019Equipment. INFORMATION New information provided by this revision is preceded by this symbol. This Service Information bulletin replaces SI B84 02 14 dated September 2018.

← All problems reported for the 2019 BMW X4