2008 BMW X5 Technical Service Bulletins

245 technical service bulletins (TSBs) are on record for the 2008 BMW X5. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10150068Jun 1, 2013Engine, Transmission and drivetrain. A customer may complain of a delay in engine response after decelerating at low road speeds and then reaccelerating. This can occur when the transmission remains in a high gear due to a delay in the transmission downshifting. This situation can be more noticeable while driving on roads with slight turns or with an increasing gradient. Unfavorable EGS and DME software
• 10149603May 1, 2013Visibility (wipers, defrost, mirrors). "Panoramic Sunroof Repair Instructions. INFORMATION Sunroof Repair Instructions: The panoramic sunroof contains several ""mechanism sets"" which can be repaired and/or replaced independently in the event of a mechanical failure. When performing such a repair to any of these sets, the TIS/ISTA Repair Instructions (REP) should always be consulted. Due to the complex nature of these repairs, a set of complementary…
• 10149601May 1, 2013Seats. Rattle Noise from Rear Seat Backrest. A rattle noise can be heard from the rear seat area when the vehicle is driven. CAUSE The left and right rear seat backrest locks have insufficient lubrication.
• 10149597May 1, 2013Air bags. DSC Warning Light is On. The warning lamps for DSC, ABS and brake warning are illuminated. There may also be a warning in the control display for 'Chassis Control System failure' One or more of the following fault codes are stored: F25, F30 DSC * D36D44 - Signal error longitudinal torque distribution (LMV) * 48097D - Transfer Case clutch position open F01, F02, F07, F10, F12 and F13 LMV: * 440108 - Control Unit…
• 10149593May 1, 2013Transmission and drivetrain, Electrical system. "The warning lamps for DSC, ABS and brake warning are illuminated. There may also be a warning in the control display for ""Chassis Control System failure."" One or more of the following fault codes are stored: DSC: * D36D44 - Signal error longitudinal torque distribution (LMV) * 48097D - Transfer Case clutch position open F01, F02, F07, F10, F12 and F13 LMV: * 440108 - Control Unit internal error * 44010F…
• 10149590May 1, 2013Engine, Fuel system. N63 and S63 Engine: High-pressure Fuel Injector Replacement Procedures. The customer complains that one of the following scenarios has been encountered while operating the vehicle: * During a cold start in the morning, the engine runs very roughly and the Service Engine Soon lamp is illuminated. * During a hot start, the engine runs very roughly and the Service Engine Soon lamp is illuminated. ??While driving or…
• 10052363May 1, 2013Brakes, Exterior lighting. Bmw: due to an error in software calibration, some vehicles are experiencing warning illumination of dsc, abs and brake and a possible warning in control display for chassis control system failure. Models 2009-2012 f30, 01, 02, 07, 10, 12, 13, 25, e70, 71, 84. No model years listed.
• 10149335Apr 1, 2013Engine cooling. MService Action: Replace the Coolant Pump. Coolant is leaking from the coolant pump. CAUSE The coolant pump may develop cracks in the plastic housing. These cracks may result in a coolant leak.
• 10150123Mar 1, 2013Exterior lighting, Electrical system. INFORMATION Note: Failures that result from the installation of non-approved accessories and/or non-original parts are not covered. Procedure A with Reprogramming and Encoding the Vehicle Covered under the terms of the BMW New Vehicle/SAV Limited Warranty or the BMW Certified Pre-Owned Program. Labor operation code 00 00 006 is a Main labor operation. If you are using a Main labor code for another repair, use the…
• 10150119Mar 1, 2013Visibility (wipers, defrost, mirrors). Front or Rear Windshield Wipers Fail to Operate. INFORMATION The following troubleshooting hints are based on known areas that can cause the situations described above to occur. 1. Front windshield wiper failure: perform the following checks only when the front windshield wiper fails to operate. If the rear wipers fail to operate, proceed to section 2. * Check Fuse F44 (30 A) and replace as necessary.
• 10150117Mar 1, 2013Electrical system. The vehicle does not start. CAUSE Software error in the CAS (Car Access System).
• 10150116Mar 1, 2013Electrical system. Battery Discharged Because of Unfavorable Driving Profile. In certain situations, the battery may become discharged when the vehicle is driven frequently on short trips (less than 3 miles per trip), or when the telephone or entertainment system is used for up to 30 minutes while the vehicle is stationary. CAUSE The vehicle charging system, in extreme conditions, is not able to properly compensate for the excessive…
• 10150107Mar 1, 2013Steering, Suspension. "Squeaking Noises from Steering Wheel While Turning. There is a squeaking noise from the steering column when the steering wheel is turned. The rubber boot on the steering column is not positioned correctly or lacks sufficient grease for the plastic bearing. INFORMATION The problem has been integrated into ISTA diagnostics. Follow the diagnosis test plan, using the latest ISTA version. In ""Information Search,""…
• 10150106Mar 1, 2013Transmission and drivetrain. Oil Leak from Transfer Case. Oil is leaking from the transmission area, or oil seepage is noticed from the transmission/transfer case area during a service. CAUSE The leak can be misdiagnosed as a transmission fluid leak from either the mechatronics sleeve or transmission oil pan. The leak is actually coming from the transfer case (input or output shaft seal).
• 10150101Mar 1, 2013Engine, Fuel system. N63 and S63 Engine: High-pressure Fuel Injector Replacement Procedures. The customer complains that one of the following scenarios has been encountered while operating the vehicle: * During a cold start in the morning, the engine runs very roughly and the Service Engine Soon lamp is illuminated. * During a hot start, the engine runs very roughly and the Service Engine Soon lamp is illuminated. ??While driving or…
• 10150096Mar 1, 2013Transmission and drivetrain, Engine. N55 Engine Failsafe - FC 120308 Boost Pressure Control, Plausibility: Pressure Too Low Stored in DME Fault Memory. INFORMATION The customer complains the SES is illuminated and the engine has reduced power (engine failsafe mode).
• 10150095Mar 1, 2013Engine. Intermittent Hydraulic Valve Adjuster (HVA) Noise. An occasional ticking or rattling noise from the camshaft hydraulic valve lifters (HVA) may occur during cold engine starts, due to frequent short-distance driving, or the noise may occur for an extended period of time even though the engine is at operating temperature. Improved parts were phased into production beginning on 10/1/2008 and fully implemented on…
• 10052012Mar 1, 2013Electrical system. Bmw: battery has an increased demand due to developemental process of the electrical system. This is causing the batter to need to undergo an energy diagnosis.
• 10051971Mar 1, 2013Electrical system. Bmw: batter discharged because of unfavorable driving profile. This is caused on short trips (less than 3 miles) or when the telephone or entertainment system is used for up to 30 minutes while vehicle is stationary. Models x5, x6 all model years affected.
• 10046861Mar 1, 2013Engine cooling. Bmw: see document search button for owner letter. The replacing and/or checking of emissions monitoring components to increase emissions stability, high pressure (hp) egr valve restriction of excessive soot and improved diesel exhaust fluid (def) mixture introduced in exhaust system from scr mixer. Model 2008-2009 e70, e90. *pe updated 5/10/13.
• 10041407Mar 1, 2013Engine cooling. Bmw: service engine soon light is on and the engine has reduced power with trouble codes stored. *rm updated on 4/24/2013.
• 10040177Mar 1, 2013Exterior lighting. Bmw: the brake light fails and the bulb holder is deformed due to high temperatures and the composition of the holder. *rm updated on 4/25/2013.
• 10038217Mar 1, 2013Engine cooling. Bmw: crankcase pressure diagnosis and information for all vehicles. *rm updated on 4/24/2013.
• 10149443Feb 1, 2013Electrical system. Various Faults Concerning the Automatic Tailgate Operation. Complaints of sporadic or permanent faults may exist with the automatic tailgate function. One or more of the following fault codes have been stored: A2AB, A2B1, A2B2, A2B3, A2B4, A2B5, A2B6, A2B7, A2B8, A2B9, A2BA, A2BC, A2BE, and A6E2. CAUSE The following four main faults are currently known: 1. The lower tailgate does not close completely. 2. The…
• 10149441Feb 1, 2013Visibility (wipers, defrost, mirrors). "Outside Door Mirror Moves when Locking or Unlocking the Vehicle. The door mirror tilts immediately after unlocking or locking. The mirror position does not correspond to the memory position preset by the customer. Pressing the seat memory button typically will return the mirror to the stored position. Poor electrical contacts of the mirror drive in the mirror housing INFORMATION The problem has been integrated…
• 10149300Jan 1, 2013Fuel system. N63 and S63 Engine: High-pressure Fuel Injector Replacement Procedures. The customer complains that one of the following scenarios has been encountered while operating the vehicle: * During a cold start in the morning, the engine runs very roughly and the Service Engine Soon lamp is illuminated. * During a hot start, the engine runs very roughly and the Service Engine Soon lamp is illuminated. * While driving or…
• 10149295Jan 1, 2013Engine, Electrical system. N55 - Delayed Throttle Response When Driving Off. Delayed throttle response when driving off with a high engine load This problem occurs mainly under the following conditions: * High ambient outside temperatures * The air conditioning is switched on * The steering wheel is turned slightly DME software calibration
• 10040044Jan 1, 2013Engine cooling, Electrical system. Bmw: there is a delayed throttle response when driving off with a high engine load. It occurs when it is hot outside, the a/c is switched on, and the wheel is turned slightly. There is a software problem. *rm updated on 4/18/2013.
• 10150389Dec 1, 2012Equipment. Service Action: CIC - Install Navigation Road Map Database 2013. The Car Information Computer (CIC) road map database 2013 must be installed onto the CIC internal Hard Disc Drive (HDD).
• 10150385Dec 1, 2012Equipment. "CCC - ""Please Insert Navigation DVD"" Appears on CID. The navigation map DVD cannot be read or detected. The message ""Please insert navigation DVD"" appears in the CID (Central Information Display). The navigation system is inoperative. This situation may also occur when upgrading to a new navigation map. The old map is recognized but the new one is not. CAUSE Faulty DVD drive; read error due to hardening of the…
• 10150368Dec 1, 2012Fuel system. Service Action: Replace the Left and Right Fuel Level Sensor. After refueling, the fuel gauge will display an incorrect fuel level. When this occurs, the fuel gauge shows the fuel level as 3/4 full. CAUSE Due to a high proportion of ethanol in the fuel, the internal mechanisms of the fuel level sensors may swell. This may inhibit the movement of one or both of the fuel level sensors.
• 10150364Dec 1, 2012Fuel system. ?BMW has become aware of a potential problem with the durability of the Tank Leak Diagnostic Module (DMTL) pump on MY 2007, 2008 and 2009 BMW X5 vehicles equipped with the N52K engine. A small percentage of these vehicles will actually develop this problem. Some of the affected vehicles will have the Service Engine Soon lamp illuminated, but the vehicle?s drivability and engine performance will not be reduced by…
• 10051419Dec 1, 2012Fuel system. Bmw: service action: replace the left and right fuel level sensor. Due to high proportion of ethanol in the fuel, the internal mechanisms of the fuel level sensors may swell. This may inhibit the movement of one or both of the fuel level sensors.
• 10051299Dec 1, 2012Engine. Bmw: see document search button for owner letter. N52k engine dmtl pump: emissions warranty extensions to 10 years/120,000 miles. Bmw has become aware of a potential problem with the durability of the tank leak diagnostic module (dmtl) pump on my 2007,2008, and 2009.
• 10045282Nov 1, 2012Engine. Bmw: while driving vehicle, at times would be rough running; white or blue smoke seen exiting exhaust system and the engine oil is consumed above specifications. *pe updated 1/11/13.
• 10032779Nov 1, 2012Engine cooling. Bmw vehicle: the service engine soon (mil) lamp is illuminated and a power reduction is clearly perceptible. This situation may occur after driving for some time with the engine already at full operating temperature. If the ignition is cycled, the engine then usually performs normally. *pe updated 2/7/11. *pe updated on 06/09/2011. *kb updated 8/10/11. *pe updated 1/11/13.
• 10150334Oct 1, 2012Equipment. "Service Action: CIC - Install Navigation Road Map Database 2013. Before delivering affected vehicles to the customer, the Car Information Computer (CIC) road map database 2013 must be installed onto the CIC internal Hard Disc Drive (HDD). Note: The INITIAL enabling code ""FSC CIC map, N. America 2013 INITIAL"" is necessary to start the installation process and to activate the road map database."
• 10150330Oct 1, 2012Electrical system. "Discharged Battery: Energy Diagnosis Must Be Performed. The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. This document covers important information for the dealer on how to handle ""discharged battery"" complaints. A discharged battery can have various causes, most of which do not concern…
• 10150323Oct 1, 2012Transmission and drivetrain. Clicking Noise from Front Axle. Clicking noises are heard from the front axle area while maneuvering at low speeds (e.g., parking lot maneuvers). CAUSE Movement between the contact surfaces of the wheel bearing and swivel bearing (knuckle)
• 10150321Oct 1, 2012Fuel system. Service Action: Replace the Left and Right Fuel Level Sensor. After refueling, the fuel gauge will display an incorrect fuel level. When this occurs, the fuel gauge shows the fuel level as 3/4 full. CAUSE Due to a high proportion of ethanol in the fuel, the internal mechanisms of the fuel level sensors may swell. This may inhibit the movement of one or both of the fuel level sensors.
• 10150318Oct 1, 2012Fuel system. "N63 and N74 Engine: ISTA/D 2.33 Diagnostic Error in the Low-pressure Fuel Supply Sensor Value. INFORMATION When diagnosing the low-pressure fuel supply sensor with one of the following test plans and ISTA/D 2.33, an error will be encountered in the display. The value of the low-pressure fuel supply sensor will read 0 bar at all times. * B1214_DI6KNDR * D18KHDR * AT1214_DIKNDR * AT1214_DIKHDR Do not replace the…
• 10046860Oct 1, 2012Fuel system, Engine. Bmw: fuel gauge shows 3/4 full after refueling due to internal mechanisms of fuel level sensors, with a high proportion of ethanol, swelling and inhibit, one or both, movement of fuel level sensors. Model 2007-2009 e70, e71. *pe updated 1/15/13.
• 10046859Aug 1, 2012Engine. Bmw: due to damaged seal ring, during assembly, engine oil is leaking from engine oil pump volume control valve gasket seal ring. Models e70, e71, f01, f02, f04, f07, f10, f12, f13. No model years listed.
• 10043713Feb 1, 2012Engine cooling, Fuel system. Bmw: a more robust sensor was developed due to selective catalyst reduction (scr) active tank failing, because of temperature sensor, and is integrated into active tank.
• 10039765Jan 1, 2012Fuel system, Electrical system. Bmw: the service engine soon light is on while driving. This is a programming issue. *rm updated 1/4/12. *pe updated 4/24/12.
• 10035009Jan 1, 2012Fuel system. Bmw vehicle: teileclearing for diagnostic module tank leakage (dmtl) system. Teileclearing process has been developed to help identify the root causes of customer complaints relating to the dmtl system (e.g., evaporative system leaks, check filler cap message, etc.). This process can help expedite the defect eradication process, once the root cause been determined. No model years listed. *pe updated 8/3/11. *pe…
• 10042704Sep 1, 2011Exterior lighting. Bmw: on certain vehicles, the xenon headlamp often have no trouble found when returned and tested thru warranty parts system. The root cause is not possible to be identify.
• 10042686Sep 1, 2011Electrical system. Bmw: on certain vehicles, the jbe (junction box electronics) module fails programming during a software update of the vehicle.
• 10039768Aug 1, 2011Fuel system. Bmw: after refueling the tank, the gauge will say 3/4 full inand not full. The guage reads full after driving a little while. The fuel level sensor arm is binding. *rm updated 9/30/11.
• 10033085Aug 1, 2011Engine cooling, Electrical system. Bmw: complaint of a delayed engagement and a harsh jolt when accelerating from a stop. The situation occurs only during the engine warm up phase (cold engine), and cannot be reproduced in the sport mode. Egs software-unfavorable nic calibration. *pe updated 9/28/11.

← All problems reported for the 2008 BMW X5