2010 BMW X5 Technical Service Bulletins

308 technical service bulletins (TSBs) are on record for the 2010 BMW X5. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10150223Aug 1, 2013Visibility (wipers, defrost, mirrors). Grating Noise from Side Window Defroster Vent. The customer may notice a grating or creaking noise coming from the instrument panel at the extreme left or right side. It is only heard when the vehicle is in motion. CAUSE The side window defroster vent fitment (in the instrument panel) causes a grating noise when driving, and torsional forces are applied. The driver's or passenger's side can both be affected.
• 10150219Aug 1, 2013Suspension. Clicking Noise from Front Axle. Clicking noises are heard from the front axle area while maneuvering at low speeds (e.g., parking lot maneuvers). CAUSE Movement between the contact surfaces of the wheel bearing and swivel bearing (knuckle)
• 10150218Aug 1, 2013Engine cooling. N51, N52K, N52T and N55 Engine: Various Faults Stored in DME Related to VANOS and Camshaft Position. A rattling noise can be heard from the engine compartment; the engine exhibits a loss of power; and the Service Engine Soon lamp is illuminated. One, or more of the following faults may be stored.
• 10150039Jul 1, 2013Equipment, Visibility (wipers, defrost, mirrors). "?Panoramic Sunroof Repair Instructions. INFORMATION Sunroof Repair Instructions: The panoramic sunroof contains several ""mechanism sets"" which can be repaired and/or replaced independently in the event of a mechanical failure. When performing such a repair to any of these sets, the TIS/ISTA Repair Instructions (REP) should always be consulted. Due to the complex nature of these repairs, a set of complementary…
• 10150033Jul 1, 2013Electrical system, Engine. N51, N52K, N52T and N55 Engine: Various Faults Stored in DME Related to VANOS and Camshaft Position. A rattling noise can be heard from the engine compartment; the engine exhibits a loss of power; and the Service Engine Soon lamp is illuminated. One, or more of the following faults may be stored.
• 10150068Jun 1, 2013Engine, Transmission and drivetrain. A customer may complain of a delay in engine response after decelerating at low road speeds and then reaccelerating. This can occur when the transmission remains in a high gear due to a delay in the transmission downshifting. This situation can be more noticeable while driving on roads with slight turns or with an increasing gradient. Unfavorable EGS and DME software
• 10149603May 1, 2013Visibility (wipers, defrost, mirrors). "Panoramic Sunroof Repair Instructions. INFORMATION Sunroof Repair Instructions: The panoramic sunroof contains several ""mechanism sets"" which can be repaired and/or replaced independently in the event of a mechanical failure. When performing such a repair to any of these sets, the TIS/ISTA Repair Instructions (REP) should always be consulted. Due to the complex nature of these repairs, a set of complementary…
• 10149601May 1, 2013Seats. Rattle Noise from Rear Seat Backrest. A rattle noise can be heard from the rear seat area when the vehicle is driven. CAUSE The left and right rear seat backrest locks have insufficient lubrication.
• 10149597May 1, 2013Air bags. DSC Warning Light is On. The warning lamps for DSC, ABS and brake warning are illuminated. There may also be a warning in the control display for 'Chassis Control System failure' One or more of the following fault codes are stored: F25, F30 DSC * D36D44 - Signal error longitudinal torque distribution (LMV) * 48097D - Transfer Case clutch position open F01, F02, F07, F10, F12 and F13 LMV: * 440108 - Control Unit…
• 10149593May 1, 2013Transmission and drivetrain, Electrical system. "The warning lamps for DSC, ABS and brake warning are illuminated. There may also be a warning in the control display for ""Chassis Control System failure."" One or more of the following fault codes are stored: DSC: * D36D44 - Signal error longitudinal torque distribution (LMV) * 48097D - Transfer Case clutch position open F01, F02, F07, F10, F12 and F13 LMV: * 440108 - Control Unit internal error * 44010F…
• 10149590May 1, 2013Engine, Fuel system. N63 and S63 Engine: High-pressure Fuel Injector Replacement Procedures. The customer complains that one of the following scenarios has been encountered while operating the vehicle: * During a cold start in the morning, the engine runs very roughly and the Service Engine Soon lamp is illuminated. * During a hot start, the engine runs very roughly and the Service Engine Soon lamp is illuminated. ??While driving or…
• 10052363May 1, 2013Brakes, Exterior lighting. Bmw: due to an error in software calibration, some vehicles are experiencing warning illumination of dsc, abs and brake and a possible warning in control display for chassis control system failure. Models 2009-2012 f30, 01, 02, 07, 10, 12, 13, 25, e70, 71, 84. No model years listed.
• 10052295May 1, 2013Electrical system, Engine. Bmw: while on hills, engine response may not be fulfilled, when accelerator pedal is depressed and if auto hold function is activated. Models 2010-2013 e70, e71.
• 10044019May 1, 2013Engine cooling. Bmw: the engine speed may drop significantly below normal idling speed if the steering wheel is turned at sharply lower road speeds. *js updated on 4/18/2013. *kb updated 7/9/13.
• 10149339Apr 1, 2013Engine cooling. ?SI B12 14 12 April 2013 Engine Electrical SystemsTechnical Service This Service Information bulletin supersedes SI B12 14 12 dated January 2013. designates changes to this revision SUBJECT N51, N52K, N52T and N55 Engine: Various Faults Stored in DME Related to VANOS and Camshaft Position. A rattling noise can be heard from the engine compartment; the engine has a loss of power; and the Service Engine Soon lamp is…
• 10149335Apr 1, 2013Engine cooling. MService Action: Replace the Coolant Pump. Coolant is leaking from the coolant pump. CAUSE The coolant pump may develop cracks in the plastic housing. These cracks may result in a coolant leak.
• 10150123Mar 1, 2013Exterior lighting, Electrical system. INFORMATION Note: Failures that result from the installation of non-approved accessories and/or non-original parts are not covered. Procedure A with Reprogramming and Encoding the Vehicle Covered under the terms of the BMW New Vehicle/SAV Limited Warranty or the BMW Certified Pre-Owned Program. Labor operation code 00 00 006 is a Main labor operation. If you are using a Main labor code for another repair, use the…
• 10150119Mar 1, 2013Visibility (wipers, defrost, mirrors). Front or Rear Windshield Wipers Fail to Operate. INFORMATION The following troubleshooting hints are based on known areas that can cause the situations described above to occur. 1. Front windshield wiper failure: perform the following checks only when the front windshield wiper fails to operate. If the rear wipers fail to operate, proceed to section 2. * Check Fuse F44 (30 A) and replace as necessary.
• 10150117Mar 1, 2013Electrical system. The vehicle does not start. CAUSE Software error in the CAS (Car Access System).
• 10150116Mar 1, 2013Electrical system. Battery Discharged Because of Unfavorable Driving Profile. In certain situations, the battery may become discharged when the vehicle is driven frequently on short trips (less than 3 miles per trip), or when the telephone or entertainment system is used for up to 30 minutes while the vehicle is stationary. CAUSE The vehicle charging system, in extreme conditions, is not able to properly compensate for the excessive…
• 10150107Mar 1, 2013Steering, Suspension. "Squeaking Noises from Steering Wheel While Turning. There is a squeaking noise from the steering column when the steering wheel is turned. The rubber boot on the steering column is not positioned correctly or lacks sufficient grease for the plastic bearing. INFORMATION The problem has been integrated into ISTA diagnostics. Follow the diagnosis test plan, using the latest ISTA version. In ""Information Search,""…
• 10150106Mar 1, 2013Transmission and drivetrain. Oil Leak from Transfer Case. Oil is leaking from the transmission area, or oil seepage is noticed from the transmission/transfer case area during a service. CAUSE The leak can be misdiagnosed as a transmission fluid leak from either the mechatronics sleeve or transmission oil pan. The leak is actually coming from the transfer case (input or output shaft seal).
• 10150105Mar 1, 2013Engine, Fuel system. "Voluntary Emissions Recall Campaign 11E-A03: Replace the SCR Mixer. The Selective Catalyst Reduction (SCR) mixer has also been improved to optimize the Diesel Exhaust Fluid (DEF) mixture when introduced into the exhaust system. AFFECTED VEHICLES This Emissions Recall Campaign involves X5d and 335d models that were produced from February 2010 to September 2010.
• 10150104Mar 1, 2013Fuel system, Engine. "Voluntary Emissions Recall Campaign 11E-A03: Check and/or Replace Emissions Monitoring Components. 1. Under certain driving conditions, the High-pressure (HP) EGR valve may become restricted with excessive soot. This restriction impedes the emissions performance of the HP EGR valve. This situation may lead to a Service Engine Soon lamp. An optimized EGR valve has been developed to limit this soot buildup. 2.
• 10150103Mar 1, 2013Engine. "?Voluntary Emissions Recall Campaign 11E-A03: Check and/or Replace Emissions Monitoring Components. 1. The Selective Catalyst Reduction (SCR) catalyst has been improved to increase emissions stability over the service life of the vehicle. 2. The SCR mixer has also been improved to optimize the Diesel Exhaust Fluid (DEF) mixture when introduced into the exhaust system. 3. Under certain driving conditions, the…
• 10150101Mar 1, 2013Engine, Fuel system. N63 and S63 Engine: High-pressure Fuel Injector Replacement Procedures. The customer complains that one of the following scenarios has been encountered while operating the vehicle: * During a cold start in the morning, the engine runs very roughly and the Service Engine Soon lamp is illuminated. * During a hot start, the engine runs very roughly and the Service Engine Soon lamp is illuminated. ??While driving or…
• 10150096Mar 1, 2013Transmission and drivetrain, Engine. N55 Engine Failsafe - FC 120308 Boost Pressure Control, Plausibility: Pressure Too Low Stored in DME Fault Memory. INFORMATION The customer complains the SES is illuminated and the engine has reduced power (engine failsafe mode).
• 10052012Mar 1, 2013Electrical system. Bmw: battery has an increased demand due to developemental process of the electrical system. This is causing the batter to need to undergo an energy diagnosis.
• 10051971Mar 1, 2013Electrical system. Bmw: batter discharged because of unfavorable driving profile. This is caused on short trips (less than 3 miles) or when the telephone or entertainment system is used for up to 30 minutes while vehicle is stationary. Models x5, x6 all model years affected.
• 10046959Mar 1, 2013Engine cooling. Bmw: see document search button for owner letter. When introduced into exhaust system, selective catalyst reduction (scr) mixer was improved to optimize diesel exhaust fluid (def) mixture. Model 2010 e70, e90. *pe updated on 4/25/2013.
• 10045284Mar 1, 2013Engine cooling. Bmw: see document search button for owner letter. Under voluntary emissions recall campaign 11e-a03:check/replace emissions monitoring components. Due to excessive soot build up, the high pressure (hp) egr valve may be restricted under certain driving conditions. *pe updated on 4/25/2013.
• 10041407Mar 1, 2013Engine cooling. Bmw: service engine soon light is on and the engine has reduced power with trouble codes stored. *rm updated on 4/24/2013.
• 10040177Mar 1, 2013Exterior lighting. Bmw: the brake light fails and the bulb holder is deformed due to high temperatures and the composition of the holder. *rm updated on 4/25/2013.
• 10038217Mar 1, 2013Engine cooling. Bmw: crankcase pressure diagnosis and information for all vehicles. *rm updated on 4/24/2013.
• 10149443Feb 1, 2013Electrical system. Various Faults Concerning the Automatic Tailgate Operation. Complaints of sporadic or permanent faults may exist with the automatic tailgate function. One or more of the following fault codes have been stored: A2AB, A2B1, A2B2, A2B3, A2B4, A2B5, A2B6, A2B7, A2B8, A2B9, A2BA, A2BC, A2BE, and A6E2. CAUSE The following four main faults are currently known: 1. The lower tailgate does not close completely. 2. The…
• 10149441Feb 1, 2013Visibility (wipers, defrost, mirrors). "Outside Door Mirror Moves when Locking or Unlocking the Vehicle. The door mirror tilts immediately after unlocking or locking. The mirror position does not correspond to the memory position preset by the customer. Pressing the seat memory button typically will return the mirror to the stored position. Poor electrical contacts of the mirror drive in the mirror housing INFORMATION The problem has been integrated…
• 10149300Jan 1, 2013Fuel system. N63 and S63 Engine: High-pressure Fuel Injector Replacement Procedures. The customer complains that one of the following scenarios has been encountered while operating the vehicle: * During a cold start in the morning, the engine runs very roughly and the Service Engine Soon lamp is illuminated. * During a hot start, the engine runs very roughly and the Service Engine Soon lamp is illuminated. * While driving or…
• 10149296Jan 1, 2013Engine. N51, N52K, N52T and N55 Engine: Various Faults Stored in DME Related to VANOS and Camshaft Position. A rattling noise can be heard from the engine compartment; the engine has a loss of power; and the Service Engine Soon lamp is illuminated. One or more of the following faults may be stored.
• 10149295Jan 1, 2013Engine, Electrical system. N55 - Delayed Throttle Response When Driving Off. Delayed throttle response when driving off with a high engine load This problem occurs mainly under the following conditions: * High ambient outside temperatures * The air conditioning is switched on * The steering wheel is turned slightly DME software calibration
• 10149294Jan 1, 2013Engine. ?SI B11 11 12 January 2013 EngineTechnical Service This Service Information bulletin supersedes SI B11 11 12 dated November 2012. PERFORM THE PROCEDURE OUTLINED IN THIS SERVICE INFORMATION ON ALL AFFECTED VEHICLES BEFORE CUSTOMER DELIVERY OR THE NEXT TIME THEY ARE IN THE SHOP FOR MAINTENANCE OR REPAIRS.
• 10040044Jan 1, 2013Engine cooling, Electrical system. Bmw: there is a delayed throttle response when driving off with a high engine load. It occurs when it is hot outside, the a/c is switched on, and the wheel is turned slightly. There is a software problem. *rm updated on 4/18/2013.
• 10150389Dec 1, 2012Equipment. Service Action: CIC - Install Navigation Road Map Database 2013. The Car Information Computer (CIC) road map database 2013 must be installed onto the CIC internal Hard Disc Drive (HDD).
• 10150385Dec 1, 2012Equipment. "CCC - ""Please Insert Navigation DVD"" Appears on CID. The navigation map DVD cannot be read or detected. The message ""Please insert navigation DVD"" appears in the CID (Central Information Display). The navigation system is inoperative. This situation may also occur when upgrading to a new navigation map. The old map is recognized but the new one is not. CAUSE Faulty DVD drive; read error due to hardening of the…
• 10150368Dec 1, 2012Fuel system. Service Action: Replace the Left and Right Fuel Level Sensor. After refueling, the fuel gauge will display an incorrect fuel level. When this occurs, the fuel gauge shows the fuel level as 3/4 full. CAUSE Due to a high proportion of ethanol in the fuel, the internal mechanisms of the fuel level sensors may swell. This may inhibit the movement of one or both of the fuel level sensors.
• 10051419Dec 1, 2012Fuel system. Bmw: service action: replace the left and right fuel level sensor. Due to high proportion of ethanol in the fuel, the internal mechanisms of the fuel level sensors may swell. This may inhibit the movement of one or both of the fuel level sensors.
• 10051299Dec 1, 2012Engine. Bmw: see document search button for owner letter. N52k engine dmtl pump: emissions warranty extensions to 10 years/120,000 miles. Bmw has become aware of a potential problem with the durability of the tank leak diagnostic module (dmtl) pump on my 2007,2008, and 2009.
• 10045282Nov 1, 2012Engine. Bmw: while driving vehicle, at times would be rough running; white or blue smoke seen exiting exhaust system and the engine oil is consumed above specifications. *pe updated 1/11/13.
• 10032779Nov 1, 2012Engine cooling. Bmw vehicle: the service engine soon (mil) lamp is illuminated and a power reduction is clearly perceptible. This situation may occur after driving for some time with the engine already at full operating temperature. If the ignition is cycled, the engine then usually performs normally. *pe updated 2/7/11. *pe updated on 06/09/2011. *kb updated 8/10/11. *pe updated 1/11/13.
• 10150335Oct 1, 2012Equipment. PERFORM THE PROCEDURE OUTLINED IN THIS SERVICE INFORMATION ON ALL AFFECTED VEHICLES BEFORE CUSTOMER DELIVERY OR THE NEXT TIME THEY AREIN THE SHOP FOR MAINTENANCE OR REPAIRS. BMW centers must ensure recalls are completed after having been notified by BMW of North America, LLC (BMWNA) that a safety-related defect or noncompliance exists in any motor vehicle or item of replacement equipment in the center's possession…
• 10150334Oct 1, 2012Equipment. "Service Action: CIC - Install Navigation Road Map Database 2013. Before delivering affected vehicles to the customer, the Car Information Computer (CIC) road map database 2013 must be installed onto the CIC internal Hard Disc Drive (HDD). Note: The INITIAL enabling code ""FSC CIC map, N. America 2013 INITIAL"" is necessary to start the installation process and to activate the road map database."

← All problems reported for the 2010 BMW X5