2011 BMW X5 Technical Service Bulletins

322 technical service bulletins (TSBs) are on record for the 2011 BMW X5. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 10051971Mar 1, 2013Electrical system. Bmw: batter discharged because of unfavorable driving profile. This is caused on short trips (less than 3 miles) or when the telephone or entertainment system is used for up to 30 minutes while vehicle is stationary. Models x5, x6 all model years affected.
• 10041407Mar 1, 2013Engine cooling. Bmw: service engine soon light is on and the engine has reduced power with trouble codes stored. *rm updated on 4/24/2013.
• 10040177Mar 1, 2013Exterior lighting. Bmw: the brake light fails and the bulb holder is deformed due to high temperatures and the composition of the holder. *rm updated on 4/25/2013.
• 10038217Mar 1, 2013Engine cooling. Bmw: crankcase pressure diagnosis and information for all vehicles. *rm updated on 4/24/2013.
• 10149443Feb 1, 2013Electrical system. Various Faults Concerning the Automatic Tailgate Operation. Complaints of sporadic or permanent faults may exist with the automatic tailgate function. One or more of the following fault codes have been stored: A2AB, A2B1, A2B2, A2B3, A2B4, A2B5, A2B6, A2B7, A2B8, A2B9, A2BA, A2BC, A2BE, and A6E2. CAUSE The following four main faults are currently known: 1. The lower tailgate does not close completely. 2. The…
• 10149441Feb 1, 2013Visibility (wipers, defrost, mirrors). "Outside Door Mirror Moves when Locking or Unlocking the Vehicle. The door mirror tilts immediately after unlocking or locking. The mirror position does not correspond to the memory position preset by the customer. Pressing the seat memory button typically will return the mirror to the stored position. Poor electrical contacts of the mirror drive in the mirror housing INFORMATION The problem has been integrated…
• 10149428Feb 1, 2013Steering. N63: Drop in Engine Speed While Turning at Low Speeds. The engine speed may drop significantly below normal idling speed if the steering wheel is turned sharply at lower road speeds. Unfavorable DME software
• 10149300Jan 1, 2013Fuel system. N63 and S63 Engine: High-pressure Fuel Injector Replacement Procedures. The customer complains that one of the following scenarios has been encountered while operating the vehicle: * During a cold start in the morning, the engine runs very roughly and the Service Engine Soon lamp is illuminated. * During a hot start, the engine runs very roughly and the Service Engine Soon lamp is illuminated. * While driving or…
• 10149296Jan 1, 2013Engine. N51, N52K, N52T and N55 Engine: Various Faults Stored in DME Related to VANOS and Camshaft Position. A rattling noise can be heard from the engine compartment; the engine has a loss of power; and the Service Engine Soon lamp is illuminated. One or more of the following faults may be stored.
• 10149295Jan 1, 2013Engine, Electrical system. N55 - Delayed Throttle Response When Driving Off. Delayed throttle response when driving off with a high engine load This problem occurs mainly under the following conditions: * High ambient outside temperatures * The air conditioning is switched on * The steering wheel is turned slightly DME software calibration
• 10149294Jan 1, 2013Engine. ?SI B11 11 12 January 2013 EngineTechnical Service This Service Information bulletin supersedes SI B11 11 12 dated November 2012. PERFORM THE PROCEDURE OUTLINED IN THIS SERVICE INFORMATION ON ALL AFFECTED VEHICLES BEFORE CUSTOMER DELIVERY OR THE NEXT TIME THEY ARE IN THE SHOP FOR MAINTENANCE OR REPAIRS.
• 10150389Dec 1, 2012Equipment. Service Action: CIC - Install Navigation Road Map Database 2013. The Car Information Computer (CIC) road map database 2013 must be installed onto the CIC internal Hard Disc Drive (HDD).
• 10150385Dec 1, 2012Equipment. "CCC - ""Please Insert Navigation DVD"" Appears on CID. The navigation map DVD cannot be read or detected. The message ""Please insert navigation DVD"" appears in the CID (Central Information Display). The navigation system is inoperative. This situation may also occur when upgrading to a new navigation map. The old map is recognized but the new one is not. CAUSE Faulty DVD drive; read error due to hardening of the…
• 10051419Dec 1, 2012Fuel system. Bmw: service action: replace the left and right fuel level sensor. Due to high proportion of ethanol in the fuel, the internal mechanisms of the fuel level sensors may swell. This may inhibit the movement of one or both of the fuel level sensors.
• 10051299Dec 1, 2012Engine. Bmw: see document search button for owner letter. N52k engine dmtl pump: emissions warranty extensions to 10 years/120,000 miles. Bmw has become aware of a potential problem with the durability of the tank leak diagnostic module (dmtl) pump on my 2007,2008, and 2009.
• 10045282Nov 1, 2012Engine. Bmw: while driving vehicle, at times would be rough running; white or blue smoke seen exiting exhaust system and the engine oil is consumed above specifications. *pe updated 1/11/13.
• 10032779Nov 1, 2012Engine cooling. Bmw vehicle: the service engine soon (mil) lamp is illuminated and a power reduction is clearly perceptible. This situation may occur after driving for some time with the engine already at full operating temperature. If the ignition is cycled, the engine then usually performs normally. *pe updated 2/7/11. *pe updated on 06/09/2011. *kb updated 8/10/11. *pe updated 1/11/13.
• 10150335Oct 1, 2012Equipment. PERFORM THE PROCEDURE OUTLINED IN THIS SERVICE INFORMATION ON ALL AFFECTED VEHICLES BEFORE CUSTOMER DELIVERY OR THE NEXT TIME THEY AREIN THE SHOP FOR MAINTENANCE OR REPAIRS. BMW centers must ensure recalls are completed after having been notified by BMW of North America, LLC (BMWNA) that a safety-related defect or noncompliance exists in any motor vehicle or item of replacement equipment in the center's possession…
• 10150334Oct 1, 2012Equipment. "Service Action: CIC - Install Navigation Road Map Database 2013. Before delivering affected vehicles to the customer, the Car Information Computer (CIC) road map database 2013 must be installed onto the CIC internal Hard Disc Drive (HDD). Note: The INITIAL enabling code ""FSC CIC map, N. America 2013 INITIAL"" is necessary to start the installation process and to activate the road map database."
• 10150330Oct 1, 2012Electrical system. "Discharged Battery: Energy Diagnosis Must Be Performed. The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. This document covers important information for the dealer on how to handle ""discharged battery"" complaints. A discharged battery can have various causes, most of which do not concern…
• 10150323Oct 1, 2012Transmission and drivetrain. Clicking Noise from Front Axle. Clicking noises are heard from the front axle area while maneuvering at low speeds (e.g., parking lot maneuvers). CAUSE Movement between the contact surfaces of the wheel bearing and swivel bearing (knuckle)
• 10150318Oct 1, 2012Fuel system. "N63 and N74 Engine: ISTA/D 2.33 Diagnostic Error in the Low-pressure Fuel Supply Sensor Value. INFORMATION When diagnosing the low-pressure fuel supply sensor with one of the following test plans and ISTA/D 2.33, an error will be encountered in the display. The value of the low-pressure fuel supply sensor will read 0 bar at all times. * B1214_DI6KNDR * D18KHDR * AT1214_DIKNDR * AT1214_DIKHDR Do not replace the…
• 10150317Oct 1, 2012Electrical system. Service Action: Program Control Units (OBD). A software update is available for the DDE (Digital Diesel Electronics) for monitoring Exhaust Gas Recirculation (EGR) and Selective Catalyst Reduction (SCR).
• 10046859Aug 1, 2012Engine. Bmw: due to damaged seal ring, during assembly, engine oil is leaking from engine oil pump volume control valve gasket seal ring. Models e70, e71, f01, f02, f04, f07, f10, f12, f13. No model years listed.
• 10043862Aug 1, 2012Electrical system. Bmw: electronic malfunction and various check control messages are displayed in cid (central information display) and instrument cluster. *pe models 2009-2012 e70, e71, e72, e82, e88, e90, e91, e92, e93, f01, f02, f04, f07, f10, f12, f13, f25. Updated 11/2/12.
• 10044290May 1, 2012Engine. Bmw: service engine soon light comes on. Engine breather line (crankcase ventilation hose) failed, causing vehicle to run rough. This is due to plastic material used for crankcase ventilation hose becomes brittle and break.
• 10042471Mar 1, 2012Fuel system. Bmw: fuel gauge sensor is not registering correct fuel level of full or near empty properly. Improvement task force available to help with diagnosis and repair of fuel level sensor. *pe updated 4/23/12. *pe updated 5/1/2012.
• 10037071Mar 1, 2012Transmission and drivetrain. The transmission warning light is on and the vehicle will not move forward or backwards. Engine speed only increases while in neutral or park. *rm updated on 5/1/2012.
• 10039767Jan 1, 2012Fuel system. Bmw: a process has been created to identify causes of customer complaints related to the tank ventilation valve. *rm updated 4/24/12.
• 10039765Jan 1, 2012Fuel system, Electrical system. Bmw: the service engine soon light is on while driving. This is a programming issue. *rm updated 1/4/12. *pe updated 4/24/12.
• 10035009Jan 1, 2012Fuel system. Bmw vehicle: teileclearing for diagnostic module tank leakage (dmtl) system. Teileclearing process has been developed to help identify the root causes of customer complaints relating to the dmtl system (e.g., evaporative system leaks, check filler cap message, etc.). This process can help expedite the defect eradication process, once the root cause been determined. No model years listed. *pe updated 8/3/11. *pe…
• 10042469Nov 1, 2011Engine cooling. Bmw: over the lifetime of the vehicle, corrosion formation could occur due to water entering the engine compartment. Engine compartment center bulkhead partition should be sealed.
• 10042465Nov 1, 2011Electrical system. Bmw: vehicle not operating properly because of various electrical malfunctions not working.
• 10039594Oct 1, 2011Engine cooling. Bmw: the engine will not start because the engine compartment partition wall is fitted incorrectly allowing water to drip onto the connector strip of the dme control unit leading to internal damage of the dme. E70/e71. *rm updated 11/21/11.
• 10042724Sep 1, 2011Equipment. Bmw: on certain vehicles, under the engine hood, an incorrect emission label (2011) has been installed instead of the 2012 emission label.
• 10042704Sep 1, 2011Exterior lighting. Bmw: on certain vehicles, the xenon headlamp often have no trouble found when returned and tested thru warranty parts system. The root cause is not possible to be identify.
• 10042686Sep 1, 2011Electrical system. Bmw: on certain vehicles, the jbe (junction box electronics) module fails programming during a software update of the vehicle.
• 10041408Aug 1, 2011Tires. Bmw: changes have been made to the vehicle¿s display elements of the tire pressure monitor system.
• 10041395Aug 1, 2011Electrical system. Bmw: there may be multiple electrical malfunctions such as: high-beam headlight switches on when using the one-touch directional. Turn signal indicator works only when the high-beam headlight is on. Turn signal indicator cannot be switched off. Glove compartment button is not working. Interior light dimming is inoperative. Horn is not working. Central locking for fuel filler door is inoperative.
• 10040852Jul 1, 2011Engine cooling. Bmw: the service engine soon light is on. There are trouble codes stored for the crankshaft sensor. No driveability issues.
• 10040175Mar 1, 2011Exterior lighting. Bmw: check control message is displayed with a stored trouble code related to headlights.
• 10040172Mar 1, 2011Transmission and drivetrain. Bmw: a software problem is causing the transmission to enter safety mode with the transmission light on. There is a stored trouble code.
• 10038185Feb 1, 2011Engine cooling. Bmw: an intkae manifold linkage rod problem is causing the service engine soon light to come on with a stored trouble code.
• 10037704Jan 1, 2011Engine cooling. Bmw: on low mileage vehicles the engine runs rough, mifires, or fails to crank. This is caused by multiple short start-ups without the engine properly going through a warm-up phase.
• 10037703Jan 1, 2011Engine cooling. Bmw: there are high fuel pressure faults stored due to a software error.
• 10037701Jan 1, 2011Engine cooling. Bmw: the service engine soon light is on due to software problems.
• 10034676Dec 1, 2010Engine cooling, Fuel system. Bmw: teile clearing for engine drivability and fuel system. An enhanced technical support (teileclearing) process has been developed to help identify the root causes of complaints relating to the drivability and fuel system (e.g., long crank, loss of power, ses lamp on, etc.). This process can also help expedite the defect eradication process, once the root cause has been determined.
• 10037046Nov 1, 2010Engine cooling. Bmw: the service engine soon light is on due to faults with a filter in the exhaust system.
• 10035010Oct 1, 2010Transmission and drivetrain. Bmw vehicle: transmission warning light is illuminated and the transmission enters failsafe mode. Fault code 4f81 (ratio monitoring, clutch a), in some cases combined with the subsequent faults 507b/507c (parking gear sensor implausible signal) or 507d (parking gear incorrectly disengaged), are stored in the egs control module. E60, e51, e65, e66, e70, e90, e91, e92, e93. No model years listed.
• 10034671Oct 1, 2010Engine cooling. Bmw: various vvt faults stored in dme memory. Service engine soon lamp is illuminated, and one of the following drivability concerns has occurred-engine cranks but will not start; loss of power; engine has poor throttle response (reduced power mode is displayed). No model years listed. *pe updated 2/7/11.

← All problems reported for the 2011 BMW X5