2025 BMW X7 Technical Service Bulletins

70 technical service bulletins (TSBs) are on record for the 2025 BMW X7. TSBs are notes manufacturers send to dealers about repair procedures for issues seen in the field. They are not recalls and do not by themselves mean a vehicle has a fault.

• 11037533Sep 10, 2026Exterior lighting. Moisture, condensation, and/or fogging are visible in one or both Daytime Running Lights (DRL) upper headlight assemblies.
• 11037534Sep 2, 2026Other or unknown. Delivery Stop - VIN Label
• 11036435Aug 22, 2026Other or unknown. Fastening Elements Return
• 11036376Aug 12, 2026Engine. This Service Bulletin provides instructions to clean the intake valves using the BMW Carbon Blaster Tool P/N 81 29 2 208 034 and the S68T / XB1T Kit P/N 83 30 5 BAD 3D5. Refer to SI B04 12 11 for existing documentation about the carbon blaster tool and SI B04 02 26 for the S68T /XB1T tool kit.
• 11035491Aug 3, 2026Transmission and drivetrain. Shaft Return
• 11035392Jul 16, 2026Engine. This Service Bulletin provides instructions to clean the intake valves using the BMW Carbon Blaster Tool
• 11035396Jul 10, 2026Engine. Due to an implementation error in various OBD diagnostics in the vehicle's control units, in very rare cases itmay happen that stored fault memory codes (DTCs) and the MIL (warning light) are not automaticallydeleted even though the underlying malfunction has already been rectified. This does not comply with the statutory OBD specifications.
• 11034449Jun 19, 2026Electrical system. Due to an implementation error in various OBD diagnostics in the vehicle's control units, in very rare cases itmay happen that stored fault memory codes (DTCs) and the MIL (warning light) are not automaticallydeleted even though the underlying malfunction has already been rectified. This does not comply with the statutory OBD specifications.
• 11034462Jun 11, 2026Electrical system. During vehicle start-up the Secure Element (SE) of the BCP may fail causing communication errors. TheCheck Control message “Drive carefully. Driving stabilisation.” will appear. In addition, the fault memoryentries below will be stored within 40 seconds of each other.
• 11034467Jun 4, 2026Electrical system. The vehicle may experience various operational issues with Apple CarPlay Projected Modes such as: Dropped connections No automatic reconnection Display errors
• 11032744May 5, 2026Electrical system. After replacing the Multifunctional Display (MFD), the Central Information Display (CID) is black. The backlight of the CID is illuminated, and touch function does register an audible sound.
• 11032741May 4, 2026Body and structure. The center console and front cup holder get noticeably too warm to the touch on long journeys with the interior "Heating on".
• 11032738May 4, 2026Seats. In vehicles equipped with the second row 60% / 40% split seat, the flex cable assembly can come out of the seat rail mechanism (circled). This stops the forwards and backwards travel of the seat.
• 11032737May 4, 2026Body and structure. There are two possible situations (rear left, right or both sides): A. The electric sunshade in the rear door does not function or sticks upon operation, and/or B. The electric sunshade is wavy.
• 11030319Mar 25, 2026Brakes. It was determined that your vehicle was fitted with a brake booster that potentially has a faulty hydraulic valve. This may result in a modified pedal feel and a sporadic red Check Control message. The brake booster should be replaced.
• 11030305Mar 19, 2026Other or unknown, Engine. Program control units (obd)
• 11030306Mar 18, 2026Body and structure. On the main door seal, detachment behaviorcan be detected at the sealing joint . Over time, the seal gradually and increasinglydetaches which can cause it to- Dangle Become visible to the customer Prevent the door from closing properly
• 11030312Mar 16, 2026Electrical system. After the software update to version …25-07-5XX, existing activation points for the “Automate My Habits”function no longer work.
• 11030061Mar 11, 2026Electrical system. BMW AG is conducting Voluntary Emissions Recall (effective March 11, 2026) on certain Model Year 2023 -2026 BMW vehicles that were produced between January 14, 2022, and September 16, 2025.
• 11030063Mar 9, 2026Seats. The customer brings vehicle in with one or both of the second row 60/40 split seats in the folded position.The seat does not respond to any requests from the second seat row seat switch button(s).
• 11029070Feb 20, 2026Electrical system. During vehicle start-up the Secure Element (SE) of the BCP may fail causing communication errors. TheCheck Control message “Drive carefully. Driving stabilisation.” will appear. In addition, the fault memoryentries below will be stored within 40 seconds of each other.
• 11028927Feb 11, 2026Electrical system. The vehicle may experience various operational issues with the infotainment system such as: Resets of the head unit Delayed start-up of the head unit (longer than 30 seconds) Failed start-up of the head unit Sporadic or permanent problems with navigation Sporadic or permanent Bluetooth connection problems Sporadic or permanent audio problems Sporadic or permanent speech / IPA (international phonetic alphabet)…
• 11028925Feb 2, 2026Electrical system. SITUATION During vehicle start-up the Secure Element (SE) of the BCP may fail causing communication errors. TheCheck Control message “Drive carefully. Driving stabilisation.” will appear. In addition, the fault memoryentries below will be stored within 40 seconds of each other.
• 11027777Jan 15, 2026Electrical system. After replacing the Multifunctional Display (MFD), the Central Information Display (CID) is black. Thebacklight of the CID is illuminated, and touch function does register an audible sound.
• 11027760Jan 9, 2026Electrical system. The threaded connection at the 48 power electronics (EME 48) may not have been properly secured. Further loosening of the connection could lead to a no-start or breakdown .
• 11027767Jan 6, 2026Other or unknown. A reference label for the tailgate SmartOpener (SMO) function (aka “touchless open,or “kick to open”) was mistakenly applied tothe bottom edge of the tailgate trim panel(either of the general locations circled) duringvehicle production.
• 11026960Dec 18, 2025Electrical system. When performing a vehicle test, diagnostic trouble code “ 8013FE Software run time error” is found in theIHKA module. If this fault is set for two consecutive life cycles, it will turn on the check engine light on vehicles with an I-level lower than 24-11-570. This fault memory entry does not cause an impairment of functionality of the automatic air conditioningsystem.
• 11025670Nov 12, 2025Electrical system. RSU availability. The engine cranks but will not start.
• 11025678Nov 7, 2025Electrical system. RSU availability. Due to a software error in the BCP, the Calibration Identification Number (CAL ID) and the Calibration Verification Number (CVN) of the vehicle are not stored correctly. They are generated with eachprogramming session and are used to identify official BMW software.
• 11024727Oct 10, 2025Electrical system. After the software update to I-level version …25-07-530, the Alexa app may disappear from the App Menu in the head unit (HU-H5).
• 11024211Oct 3, 2025Electrical system. In some situations, an emergency call may be triggered in the vehicle without either the customer pressing the SOS Call button, or an airbag deployment event. In some cases, the customer may not even be inside the vehicle.
• 11024205Sep 18, 2025Electrical system. Starting from I-level …24-07-500, it is possible that the Automatic Hold function is not automatically storedfor the next journey. The function must be activated again by the driver at the beginning of every trip. After asoftware update to 25-03-500 and higher, this occurs more frequently.
• 11023247Sep 18, 2025Engine. Due to an assembly error the upper oil pan screws may not have been torqued correctly.
• 11024228Sep 10, 2025Engine. Oil Drain Plug Return
• 11024225Sep 5, 2025Suspension. Control Arm Return
• 11022857Aug 30, 2025Other or unknown. On the main door seal, detachment behavior can be detected in the sealing joint area. Overtime, the sealing material continues to detach more and more, which can cause the seal to dangle and become visible to the customer.
• 11022864Aug 29, 2025Electrical system, Seats. The electric actuator for the third row (3SR) seat changed design and part number, and is used in productionvehicles as of March 28, 2025. There are two such actuators at this seat row, one for the left seating position; and one for the right
• 11022856Aug 26, 2025Electrical system. Central Information Display (CID) in the vehicle is black or only displays “BMW”. The head unit (HU-H5) is not responding in ISTA. Additionally, the Receiver Audio Module (RAM), Instrument Cluster (KOMBI) and Telematic Module 4 (TCB4) may not be responding in ISTA.
• 11022855Aug 26, 2025Electrical system. After replacing the Multifunctional Display (MFD), the Central Information Display (CID) is black. Thebacklight of the CID is illuminated, and touch function does register an audible sound.
• 11022870Aug 22, 2025Other or unknown. Tension Strut Return
• 11022859Aug 20, 2025Body and structure. A groaning sound from the front of the vehicle while driving can be heard, particularly while cornering. The groaning sound can be heard in the A-pillar/instrument panel area.
• 11022104Aug 20, 2025Body and structure. While driving on rough/uneven roads, a buzzing sound can be heard from the upper tailgate interior trim panel.
• 11022863Aug 19, 2025Engine. Due to an assembly error the upper oil pan screws may not have been torqued correctly.
• 11021167Aug 11, 2025Engine. Delivery stop: oil pan top screw connection
• 11021815Aug 4, 2025Engine. Due to an assembly error the upper oil pan screws may not have been torqued correctly.
• 11021813Aug 4, 2025Engine. Due to an assembly error the upper oil pan screws may not have been torqued correctly.
• 11020908Jul 10, 2025Electrical system. A software error in the transmission control unit (EGS) will prevent OBD/emissions related information from being read out with a “scan tool”.
• 11020906Jul 1, 2025Engine. The “Check Engine Oil Level” warning is displayed while driving due to one of the following: Shortly after a detailed measurement has been carried out Shortly after engine oil has been topped up Shortly after an engine oil service has been carried out
• 11019565Jun 12, 2025Suspension. The air line on the air suspension supply system may not be properly installed. In the event of a fault, residual pressure is maintained in the struts and corresponding check control message.
• 11019572Jun 11, 2025Electrical system. When navigation is selected, only the start animation with the text “Starting navigation system...” isdisplayed. The Navigation application does not start. This only applies to vehicles where Navigation hasbeen enabled and has been verified to work previously.

← All problems reported for the 2025 BMW X7