2003 BMW Z4 Recalls
NHTSA lists 4 recall campaigns for the 2003 BMW Z4. A recall applies only to vehicles built within the affected range, so check your own VIN at nhtsa.gov/recalls. Repairs for recalls are free at a franchised dealer.
- Air bagsCovers: BMW Z4 2003
Reported issue: On certain passenger vehicles, incompatible electronic air bag system processors may have been installed.
Possible consequence: In the event of a crash, air bag deployment may not occur, increasing the risk of injuries to the driver and/or front passenger.
Remedy: Dealers will inspect and, if necessary, replace the air bag system processors. The recall began june 11, 2004. Owners should contact bmw at 1-800-831-1117.
- Fuel system, gasoline › Delivery › Fuel pumpCovers: BMW Z4 2003–2004
Reported issue: On certain passenger vehicles, under certain environmental conditions, a vapor lock in the fuel pump could occur causing the engine to stall. If this were to happen, the engine would not be able to be restarted for approximately 15 to 20 minutes.
Possible consequence: If stalling were to occur, the driver would be unable to maintain vehicle speed or accelerate, increasing the risk of a crash.
Remedy: Dealers will install a resistor in the electrical line powering the fuel pump in order to prevent an occurrence of vapor lock. The recall began may 11, 2004. Owners should contact bmw at 1-800-831-1117.
- TiresCovers: BMW Z4 2003
Reported issue: On certain vehicles equipped with 18" tires, it is possible that the tire has been damaged during the mounting process to the rim.
Possible consequence: Consequently, a loss of tire pressure, or a tire failure, could occur. Depending on traffic conditions and the driver's reactions, this could lead to a crash.
Remedy: Dealers will unseat the tire from its rim, inspect for any damage, and then reseat the tire to its rim. If inspection reveals that a front tire has incurred damage during the mounting process, it will be replaced. Owner notification began july 14, 2003. Owners should contact bmw at 1-800-831-1117.
- Seat belts › Front › Buckle assemblyCovers: BMW Z4 2003, X5 2002
Reported issue: On certain passenger vehicles, the connection of the safety belt buckle to the steel rope of the tensioner does not meet bmw specifications. In severe frontal crashes, this connection can detach.
Possible consequence: If the connection detaches, the protection provided by the safety belt is likely to be impaired, and serious injuries to the driver and/or front passenger could occur that might otherwise be mitigated.
Remedy: Dealers will inspect both front safety belt tensioner and buckle assemblies, and if necessary, replace these parts. Owner notification began march 19, 2003. Owners who take their vehicles to an authorized dealer on an agreed upon service date and do not receive the free remedy within a reasonable time should contact…
NHTSA investigations
- PE10020Sticky SteeringClosed · Jun 28, 2010
← All problems reported for the 2003 BMW Z4
About this data. Data from NHTSA (ODI) complaints, recalls, TSBs and investigations, updated Oct 29, 2026. Complaints are unverified consumer reports and may be duplicated or inaccurate.