2001 Chevrolet Astro Engine cooling Problems
- Complaints
- 4about this part
- Share
- 4%of 91 total for the year
- Median mileage
- 90,000miles
- Trend
- Not enough dataFewer than 15 complaints, too few for a reliable trend.
NHTSA recorded 4 complaints about the engine cooling of the 2001 Chevrolet Astro, 4% of the 91 complaints for this model year. Where a mileage was given, the median is 90,000 miles. 1 of these say a crash was involved, according to the filers.
Fewer than 15 complaints name this part, so treat the figures as a rough indication only.
Example complaints
Selected from NHTSA records; personal details are removed. They are consumer reports, not findings.
“I have had a miss when vehicle is warm. Dealer says it is fuel, but I am using the recommended fuel according to dealer. The check engine light comes on and then goes off. Dealer cannot locate problem. This is an ongoing issue since I have purchased it. Also had to replace front brake pads and shocks at 26000 miles. After approximately one year use.”
NHTSA complaint #10014333, filed 2003-04, 500 miles“2001 Astro van chevy panic stop brakes no response to floor 1st. Time had looked at pass. Side wear 1 side brake pad wear repair. 2nd time need to stop fast hit brakes to floor no response both 35 MPH to 45 MPH called GM acted like don't care . Turn signal switch replace 710.00 will not reimburse engine light on and off replace sensors $275.00 catalytic converter $1000.00 then motor failure dealer could not pin point problem new motor 6538.00 bought van from dealer said o.k. For 150000 to 200000 had 47000 now 130000 will not buy g.m.”
NHTSA complaint #10152540, filed 2006-03, 90,000 miles“The contact owns a 2001 Chevrolet Astro van. During brake application, the vehicle would stall without warning. The vehicle has not been diagnosed. The current and failure mileages were 152000.”
NHTSA complaint #10296201, filed 2009-12, 152,000 miles“While driving the consumer noticed that the rear of the vehicle was smoking. The consumer stated that the vehicles cabin filled with smoke fumes which caused the passenger to become sick. The dealer has serviced the vehicle three time but the problem returns.”
NHTSA complaint #10040188, filed 2003-09Related service bulletins
- 10251890Mar 13, 2024This technical bulletin advises of a new fuel injection cleaner kit used for decarbonizing the intake valves to correct conditions of rough idle, Crank no start, extended crank…
- 10250775Feb 22, 2024This service bulletin provides service information to technicians on guidelines to replace Oil Cooler, Oil Cooler Lines and Oil Tank if the engine was replaced where large…
- 10249579Jan 12, 2024This PI bulletin advises the technician on the proper way to install the pistons in an engine.
- 10242843Sep 1, 2023The service bulletin advises the tech of a normal transmission shift condition and the delay in throttle response when the throttle plate is opened rapidly and advises the…
- 10242262Aug 24, 2023This service bulletin provides graphics, information and guidelines for engine component wear to assist service personnel as a guideline to perform necessary engine repairs and…
- 10236164Apr 24, 2023This Preliminary information communicates information that will need to be provided to TAC to aid in diagnosing if a vehicle comes in with misfire and DTC Codes P0300 - P0308…
- 10234110Mar 17, 2023This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.
- 10228888Dec 14, 2022This service bulletin provides diagnostic tips/steps on testing for possible EVAP leaks in the system to correct a customer concern of an MIL Illuminated with DTCs P0442 and/or…
- 10227056Nov 9, 2022This service bulletin provides service information to technicians on guidelines to replace Oil Cooler, Oil Cooler Lines and Oil Tank if the engine was replaced where large…
- 10222796Sep 14, 2022This service bulletin provides service information on new torque specification and installation procedure for ACDelco Spin-On Oil Filters.
Engine cooling: other model years
| Year | Complaints | Share of year |
|---|---|---|
| 2003 | 3 | 5% |
| 2002 | 3 | 4% |
| 2001 | 4 | 4% |
| 2000 | 16 | 9% |
| 1999 | 10 | 8% |
| 1998 | 27 | 11% |
| 1997 | 37 | 10% |
| 1996 | 18 | 7% |
| 1995 | 28 | 6% |
| 1994 | 16 | 5% |
| 1993 | 9 | 7% |
| 1992 | 6 | 5% |
| 1991 | 2 | 2% |
| 1990 | 3 | 4% |
| 1989 | 5 | 9% |
| 1988 | 14 | 25% |
| 1987 | 3 | 10% |
Other parts of the 2001 Chevrolet Astro
34 complaintsExterior lighting
19 complaintsElectrical system
7 complaintsSuspension
6 complaintsFuel system
5 complaintsSeat belts
5 complaintsBody and structure
5 complaintsTransmission and drivetrain
5 complaintsVehicle speed control
4 complaintsSteering
3 complaintsAir bags
2 complaintsTires
2 complaints
← All problems reported for the 2001 Chevrolet Astro
About this data. Data from NHTSA (ODI) complaints, recalls, TSBs and investigations, updated Oct 27, 2026. Complaints are unverified consumer reports and may be duplicated or inaccurate.
To check a specific vehicle for open recalls, use its VIN at nhtsa.gov/recalls. Methodology