2003 Chevrolet Astro Recalls

NHTSA lists 1 recall campaign for the 2003 Chevrolet Astro. A recall applies only to vehicles built within the affected range, so check your own VIN at nhtsa.gov/recalls. Repairs for recalls are free at a franchised dealer.

• 03V328000Sep 12, 200341,477 vehicles potentially affected
  Suspension › Front › Control arm › Lower ball joint
  Covers: Chevrolet Astro 2003, GMC Safari 2003

  Reported issue: Certain minivans have an interference condition between the lower ball joint rubber boot and the steering knuckle (both left/right sides), which could result in cutting of the boot that is intended to seal the ball joint. If the lower ball joint boot were cut, contamination from the road (salt, dirt, water, etc.) could enter the ball socket area of the ball joint causing the joint to wear out too quickly.

  Possible consequence: The steering knuckle could separate from the lower control arm, dropping down the affected corner of the vehicle. The coil spring would push the control arm down into contact with the ground, creating a drag that would slow the vehicle. The driver could have difficulty in maintaining the directional control of the…

  Remedy: Dealers will replace the steering knuckles. Owner notification is expected to begin on april 8, 2004. Owners should contact chevrolet at 1-800-630-2438 or gmc at 1-866-996-9463.

  Full campaign details →

← All problems reported for the 2003 Chevrolet Astro